Instruction/ maintenance manual of the product H500i Healthrider
Go to page of 28
Visit our website at www .proform.com new products, prizes, fitness tips, and much more! Visit our website at www .healthrider .com new products, prizes, fitness tips, and much more! Serial Number Decal Model No. HRTL71706.1 Serial No. CAUTION Read all precautions and instruc- tions in this manual before using this equipment.
T ABLE OF CONTENTS WARNING DECAL PLACEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 IMPORTANT PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1. Before beginning any exercise program, con- sult your physician. This is especially impor- tant for persons over the age of 35 or persons with pre-existing health problems. 2. It is the responsibility of the owner to ensure that all users of this treadmill are adequately informed of all warnings and precautions.
4 20. Use the dumbbells only as described in this manual. Properly store the dumbbells in the dumbbell holders on the console when you are not using them. If the dumbbells are im- properly stored, they may fall off the console, c ausing the user to trip.
5 T hank you for selecting the revolutionary H EALTHRIDER ® P RO H500i treadmill. The PRO H500i treadmill offers an impressive array of features designed to make your workouts at home more enjoy- able and e ffect ive.
1. Make sure that the power cord is unplugged. With the help of a second person, carefully tip the treadmill onto its left side as shown. Partially fold the Frame (58) so the treadmill is more sta- ble. Do not fully fold the Frame until the treadmill is completely assembled.
4. With the help of a second person, carefully raise the Uprights (84) to a vertical position. Have the second person hold the Handrail (20) near the Uprights (84). Inser t the Wi re Harn ess (77) into the hole in the bottom of the Handrail and out of the top as shown.
7. Set the console assembly on the Handrail (20). Be careful to avoid pinching any of the wires. Make sure that the ground wire (see step 5) and the wire from the console assem - bly (see step 6) are in the indicated channel. Hand tighten five Screws (3) into the Handrail (20) and the console assembly.
1. Remove the key from the console and unplug the power cord. Remove the Screw (3) and the Access Door (76) from the back of the Console Base (85). 2. Connect the wire on the receiver (A) to the indi- cated wire extending from the Console Base (85). Hold the receiver so the small cylinder is oriented as shown and is facing the Console Base.
10 OPERA TION AND ADJUSTMENT T HE PRE-LUBRICATED WALKING BELT Your treadmill features a walking belt coated with high- performance lubricant. IMPORTANT: Never apply sil- icone spray or other substances to the walking belt or the walking platform. Such substances will deteriorate the walking belt and cause excessive wear.
1 1 ETPF59806 PFTL59806 FEATURES OF THE CONSOLE The revolutionary treadmill console offers a selection of features designed to make your workouts more effective. When you select the manual mode of the console, you can c hange the speed and incline of the treadmill with the t ouch of a button.
12 HOW TO TURN ON THE POWER I MPORTANT: If the treadmill has been exposed to cold temperatures, allow it to warm to room tem- p erature before turning on the power. If you do not do this, the console displays or other electrical components may become damaged.
13 5. Follow your progress with the display. W hen you select the m anual mode, the display will show a track that repre- sents 1/4 mile (400 meters). As you walk or run, in- dicators will appear in succession around the track until the entire track appears.
14 HOW TO USE A CROSS TRAINER PROGRAM 1 . Insert the key into the console. S ee HOW TO TURN ON THE POWER on page 12. 2. Select one of the six cross trainer programs.
4. Perform the first strength exercise when prompted. When the f irst strength exercise segment be- gins (only one indicator will flash in the current segment column), the walking belt will slow to a stop and the name of the first strength exercise will appear in the display for a few sec- onds.
16 THE INFORMATION MODE T he console features an information mode that keeps track of treadmill usage information. The information m ode also allows you to select miles or kilometers as the unit of measurement and to turn on and turn off the demo mode.
17 HOW T O FOLD AND MOVE THE TREADMILL HOW TO FOLD THE TREADMILL FOR STORAGE B efore folding the treadmill, adjust the incline to the lowest position. If you do not do this, you may damage the treadmill when you fold it. Next, unplug the power cord. CAUTION: You must be able to safely lift 45 lbs.
18 HOW TO LOWER THE TREADMILL FOR USE 1. Hold the upper end of the treadmill with your right hand. Pull the latch knob to the left and hold it. Pivot the frame down- ward until the frame is past the latch pin. Then, slowly re- lease the latch knob. 2.
19 TROUBLESHOOTING Most treadmill problems can be solved by following the steps below. Find the symptom that applies, and follow the steps listed. If you need further assistance, please see the front cover of this manual. PROBLEM: The power does not turn on SOLUTION: a.
Locate the Reed Switch (63) and the Magnet (46) on the left side of the Front Roller (47). Turn the Front R oller until the Magnet is aligned with the Reed Switch. Make sure that the gap between the Magnet and t he Reed Switch is about 1/8 in. (3 mm).
21 These guidelines will help you to plan your exercise program. For detailed exercise information, obtain a reputable book or consult your physician. Remember, proper nutrition and adequate rest are essential for successful results.
22 SUGGESTED STRETCHES T he correct form for several basic stretches is shown at the right. Move slowly as you stretch—never bounce. 1 . Toe Touch Stretch Stand with your knees bent slightly and slowly bend forward from your hips. Allow your back and shoulders to relax as you reach down toward your toes as far as possible.
P ART LIST—Model No. HRTL71706.1 R 0108A Key No. Qty. Description Key No. Qty. Description 1 2 Foot Rail Decal 2 3 3/4" Belly Pan Screw 3 21 Screw 4 1 Reset/Off Circuit Breaker 5 10 Foot Rail S.
16 9 12 1 1 15 10 46 47 10 49 48 58 53 74 52 3 17 12 15 55 1 1 69 7 7 1 1 6 6 70 70 5 5 5 5 5 5 5 5 5 5 9 51 53 54 3 95 95 7 7 90 90 99 3 91 74 91 24 EXPLODED DRA WING A—Model No.
63 59 2 104 41 33 38 39 40 66 28 28 32 32 36 18 25 22 27 30 23 26 19 24 22 25 30 42 61 2 2 33 4 13 43 45 101 50 7 7 7 98 98 9 8 87 33 33 103 7 25 EXPLODED DRA WING B—Model No.
84 73 82 83 82 83 68 68 72 32 86 88 56 29 83 60 65 65 31 32 44 8 64 21 20 32 80 67 89 81 78 80 67 89 81 78 44 31 32 92 8 29 92 8 8 77 8 60 62 62 3 3 3 3 14 14 8 64 8 83 93 94 66 96 97 3 3 3 3 3 8 3 77 102 33 57 26 EXPLODED DRA WING C—Model No. HRTL71706.
3 76 79 75 71 34 85 3 3 3 37 35 3 5 33 3 100 100 7 27 EXPLODED DRA WING D—Model No. HRTL71706.1 R 0108A.
Part No. 263736 R0108A Printed in USA © 2008 ICON IP, Inc. ORDERING REPLACEMENT P ARTS To order replacement parts, please see the front cover of this manual.
An important point after buying a device Healthrider H500i (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Healthrider H500i yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Healthrider H500i - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Healthrider H500i you will learn all the available features of the product, as well as information on its operation. The information that you get Healthrider H500i will certainly help you make a decision on the purchase.
If you already are a holder of Healthrider H500i, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Healthrider H500i.
However, one of the most important roles played by the user manual is to help in solving problems with Healthrider H500i. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Healthrider H500i along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
