Instruction/ maintenance manual of the product 50PG03-16 Carrier
Go to page of 32
50PG03−16 Single−P ackage Rooftop Units Electric Heater and Single Point Box Accessories Installation Instructions Heater Part Numbers: CRHEA TER200A00 through CRHEA TER263A00 Single Point Box Par.
2 6. Remove the block-off plate from electric heater compartment and save screws. (See Fig. 2.) 7. Slide heater module into heater compartment by aligning the heater frame with the heater opening. Do NOT handle heater assembly by the heating coils. Handle by sheet metal panel only .
3 BLOCK-OFF PLA TE C06183 Fig. 2 − Block − Off Plate ACCESSORY ELECTRIC HEA TER ASSEMBL Y SINGLE POINT BOX ROUTE HEA TER POWER WIRES BEHIND COMPRESSORS AS SHOWN.
4 HEA TER ASSEMBL Y CONNECT PL3 PLUG AND RECEPT ACLE ROUTE HEA TER POWER WIRES THROUGH RACEW A Y AND BEHIND COMPRESSORS (COMPRESSORS REMOVED FOR CLARITY) POWER WIRES ARE ROUTED INTO BOTT OM OF SINGLE POINT BOX SINGLE POINT BOX C06185 Fig.
5 NOTE : Consult the Controls and T roubleshooting Guide for in depth instructions on using and configuring the Comfort Link control. The following instructions are written for the Scrolling Marquee Display or Navigator ™ accessory . 1. The Comfort Link control must be configured to use the electric heater accessory .
6 FUSE BLOCK TERMINAL BLOCK HINGED COVER C06190 Fig. 9 − Single Point Box CRSINGLE033A00 FUSE BLOCK TERMINAL BLOCK HINGED COVER C06191 Fig. 10 − Single Point Box CRSINGLE034A00 TERMINAL BLOCK C06192 Fig.
7 TERMINAL BLOCK HINGED COVER FUSE BLOCK C06192 Fig. 12 − Single Point Box CRSINGLE03 6 A00 TO FIELD POWER HEA TERS SINGLE POINT BOX UNIT CONTROL BOX UNIT POWER PIGT AILS HEA TER WIRES SUPPLIED WITH HEA TERS FUSE BLOCK C06194 Fig.
8 TO FIELD POWER HEA TERS SINGLE POINT BOX UNIT CONTROL BOX UNIT POWER PIGT AILS HEA TER WIRES SUPPLIED WITH HEA TERS FUSE BLOCK C06196 Fig. 15 − Heater Wiring CRSINGLE030A00 TO FIELD POWER HEA TERS SINGLE POINT BOX UNIT CONTROL BOX UNIT POWER PIGT AILS HEA TER WIRES SUPPLIED WITH HEA TERS FB1 FUSE BLOCK FUSE BLOCK C06197 Fig.
9 TO FIELD POWER FB1 TB1 UNIT POWER PIGT AILS HEA TER WIRES SUPPLIED WITH HEA TERS HEA TERS SINGLE POINT BOX UNIT CONTROL BOX 40,50,60 kW ONL Y FUSE BLOCK FUSE BLOCK C06200 Fig. 19 − Heater Wiring CRSINGLE033A00 C06201 Fig. 20 − Heater Wiring CRSINGLE034A00 C06202 Fig.
10 T able 1 — Electrical Data — Units W ithout Optional Power ed Convenience Outlet UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS− PH−H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
11 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS− PH−H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
12 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS− PH−H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
13 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y PRSINGL E PA R T N0.
14 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
15 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA .) OFM FLA IFMF LA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
16 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA .) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
17 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA .) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
18 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA .) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
19 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA .) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
20 T able 1 — Electrical Data — Units Without Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POWER SUPPL Y (V-PH-HZ ) VOL TAGE RANG E COMP R NO. 1 COMP R NO. 2 COMP R NO. 3 OF MFL A POWER EXH AUST IF M TYPE IFM FLA ELEC TRIC HEA T POWER SUPPL Y CRSI NGLE PAR T NO.
21 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
22 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEATC POWER SUPPL Y CRS INGLE PA R T NO.
23 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSOR (EA ) OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
24 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POWER SUPPL Y VOL TS-PH-HZ VOL TAGE RANG E COMPRESSOR OFM FLA IFM FLA POWER EXH AUST FLA IFM TYPE ELEC TRIC HEA T POWER SUPPL Y CRSI NGLE PAR T NO.
25 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSO R OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
26 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPLY VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSO R OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
27 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSO R OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
28 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSO R OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
29 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSO R OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
30 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POW ER SUPPL Y VO L TS- PH-H Z VOL TAGE RANG E CO MPRESSO R OFM FLA IFM FLA POW ER EXHA UST FLA IFM TYPE ELECTRIC HEAT POWER SUPPL Y CRS INGLE PA R T NO.
31 T able 2 — Electrical Data — Units With Optional Power ed Convenience Outlet (cont) UNIT 50PG NOMI NAL POWER SUPPL Y (V-PH-HZ ) VOL TAGE RANG E COMP R NO. 1 COMP R NO. 2 COMP R NO. 3 OFM POWER EXH AUST IF M TYPE IFM ELEC TRIC HEA T POWER SUPPL Y CRSING LE PAR T NO.
32 LEGEND FLA − Full Load Amps HACR − Heating, Air Conditioning and Refrigeration IFM − Indoor − Fan Motor LRA − Locked Rotor Amps MCA − Minimum Circuit Amps MOCP − Maximum Overcurrent P.
An important point after buying a device Carrier 50PG03-16 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Carrier 50PG03-16 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Carrier 50PG03-16 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Carrier 50PG03-16 you will learn all the available features of the product, as well as information on its operation. The information that you get Carrier 50PG03-16 will certainly help you make a decision on the purchase.
If you already are a holder of Carrier 50PG03-16, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Carrier 50PG03-16.
However, one of the most important roles played by the user manual is to help in solving problems with Carrier 50PG03-16. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Carrier 50PG03-16 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
