Instruction/ maintenance manual of the product KD6016 Cal Flame
Go to page of 28
.
Copyright 2011 LMS, Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement progr ams, all models, operation, and/or specications are subject to change without prior notice.
1 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Planning the Best Location Here are some of the things that you will need to consider when determin- ing where to place your new barbecue island. Safety First Do not place your barbecue island near trees and shrubs.
2 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Preparing a Good Foundation Y our barbecue island needs a solid and level foundation. Damage caused by inadequate or improper foundation support is not covered by the warranty .
3 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Natural Gas Installation Y ou do not need to hire a contractor to install your natural gas service, but you need to make sure you have all required permits and ensure the installation complies with State and local code.
4 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Assembly This manual describes the assembly for both the KD6002 and KD6016 barbecue islands. Although the model shown in these instructions is the KD6002, assembly for both models is the same except where it is specically called out.
5 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m T wo side pieces Front piece.
6 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Counter top Back piece Note: Back piece shown above is for model KD6002.
7 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Assembly Locate the three base slats and place them where the barbecue 1.
8 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Do the same for the front piece. 4. Screw the back piece down using the provided screws.
9 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Slide the rst side piece in place. 5. Attach the side piece with four nuts and w ashers as shown below .
10 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Slide the other side piece in place and bolt it to the fr ont and back 7 . frame pieces. Place the granite counter top on the frame. There are ve bolts 8. welded to the bottom of the counter top that go through holes in the fr ame.
11 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Attach the counter top to the fr ame with nuts and washers in ve 9. places. Set the platform for the refriger ator in place. It does not need to 10. be attached to the platform.
12 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m The barbecue island is manufactured as a single unit and is split apart after stucco has been applied. After you have assembled all of the pieces, you may notice a small seam in the stucco.
13 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Cleaning and Maintenance About Natural Stone A natural characteristic of granite and marble is its inherent lack of uniformity .
14 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Granite Top Clean stone surfaces with a few drops of neutr al cleaner , stone soap (av ailable fr om Monticello Granite) or a mild liquid dishwashing deter- gent and warm water .
15 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Tile If spillage occurs, then clean up as soon as possible. Care Protect against chipping by using a cutting boar d. • Protect against scratches, especially on natur al stone tiles.
16 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m DO’s and DON’Ts of Tile Care Do test scouring pads in a small area rst. • Do use a silicone sealer on grout joints if continuous staining is a • problem.
17 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Stainless Steel All exposed stainless steel surfaces require special attention if you want to keep them looking clean and bright. F ollowing these simple instruc- tions will help avoid scratching or damaging the nish and keep your stainless steel attractiv e.
18 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Cleaning Products and Materials Avoid using these common cleaning products and materials – they will damage the surface of your stainless steel.
19 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil.
20 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof .
21 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Cleaning the Interior of Your Grill Thoroughly clean stains, food, and grime using a sponge or damp 1. cloth with warm water and a mild dish soap. Use F antastik or For- mula 409 to remove hea vier soil.
22 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Cooking Grates Use a solution equal parts detergent and hot water just as you would for any cooking equipment. A sti ff wire brush or steel wool may also be helpful in removing grime and f ood deposits.
23 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Limited Warranty All Cal Flame barbecue islands are manufactured with the highest qual- ity appliances and are warr anted to be free from defects in material and workmanship at time of delivery .
24 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m qualied to repair stone and tile or a service agent licensed to repair gas or electrical appliances.
25 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l a m e b b q . c o m Damage caused by dirt, sand, and/or water damage. • Damage caused by salty and humid conditions (especially in beach • or seaside communities) Damage caused by continued operation of the barbecue with ei- • ther known or unknown problems.
L TR50001101, Rev . A 2/1/11 LMS Customer Service Department 1462 East Ninth Street Pomona, CA 91766 T oll Free: 1-800-CAL -SP AS F ax: 1-909-629-3890 www.
An important point after buying a device Cal Flame KD6016 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Cal Flame KD6016 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Cal Flame KD6016 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Cal Flame KD6016 you will learn all the available features of the product, as well as information on its operation. The information that you get Cal Flame KD6016 will certainly help you make a decision on the purchase.
If you already are a holder of Cal Flame KD6016, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Cal Flame KD6016.
However, one of the most important roles played by the user manual is to help in solving problems with Cal Flame KD6016. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Cal Flame KD6016 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
