Instruction/ maintenance manual of the product SUMMIT 650 Weber
Go to page of 18
SUMMIT TM 450 & 650 LP Gas Barbecues Operating Guide W E B E R W E B E R W E B E R W E B E R 72626 01/24/02 Read before assembly D ANGER If y ou smell gas: 1.
2 D ANGER Failure to f ollow the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injury or death, or in a fire or an explosion causing dama g e to property . W ARNINGS Do not store a spare or disconnected liquid pr opane cylinder under or near this barbecue .
3 T ABLE OF CONTENTS W arnings 2 W arranty 4 A W or d of Thanks 4 General Instructions 5 Operating Area 5 Storage 5 *REFER T O Y OUR STEP-BY-STEP SECTION A T THIS TIME Lighting 6-7 Crossov er Ignition.
4 Thank you for choosing a W eber Barbecue. Our family here at W eber has worked har d to produce the highest quality pr oducts for your satisfaction. While we give much attention to our products, an occasional err or may occur . Our knowledgeable Customer Service staf f is pr epared to help you with any pr oblems with parts or assembly .
5 GENERAL INSTRUCTIONS Y our W eber Gas Barbecue is a por tab le outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer ® Bars produce that “ outdoor ” flav or in the f ood.
1 3 2 1 3 2 6 Crosso ver Ignition System LIGHTING Crosso ver Ignition System Summit 450 Summit 650 EA CH HEA T ZONE OPERA TES INDEPENDENTL Y Summar y lighting instructions are on the control panel.
7 EA CH HEA T ZONE OPERA TES INDEPENDENTL Y . 1) Open the lid. 2 ) Make sure all burner control knobs are tur ned OFF . (Push each burner control knob down and turn clockwise.) W ARNING: The storage space under the cooking module is intended for stora g e of nonflammable items only .
8 3) T ur n the tank on by turning the tank valv e counterclockwise . 4) Select heat zone . 5) Put a match in the match holder and strike the match. 6) Inser t match holder and lit match through matchlight hole to ignite LEFT burner . W ARNING: Do not lean over open barbecue.
9 COOKING W ARNING: T urn your W eber Gas Barbecue OFF and wait for it to cool bef ore cleaning. CA UTION: Do not clean your Fla vorizer ® Bars or cooking grates in a self-cleaning o ven.
10 The Steam-N-Chips Smoker cooks with both W eber FireSpice Wood Chips and Chunks . For best results with f aster cooking foods lik e steaks, burgers and chops , etc., we recommend using the FireSpice Chips because the y ignite and create smoke f aster .
11 REFILLING THE LIQUID PROP ANE CYLINDER W e recommend that you refill the LP cylinder bef ore it is completely empty . Remov al of the LP cylinder 1) Close cylinder v alve (turn clockwise). 2) Unscre w regulator coupling by tur ning counterclockwise , by hand only .
12 Hook the liquid propane cylinder onto the fuel gauge. Loosen the cylinder lock wing n ut. Swing the cylinder loc k down. Tighten the wing n ut. Remov e plastic dust cov er from the fuel cylinder valv e. Screw the regulator coupling onto the cylinder v alve(1), clockwise , or to the r ight.
13 Spider/Insect screens Y our Gas Barbecue, as w ell as any outdoor gas appliance, is a target f or spiders and other insects. They can nest in the v enturi section V enturi(1) of the burner tubes. This b locks the normal gas flow , and can cause the gas to flow bac k out of the air shutter .
14 GENERAL MAINTENANCE Replacing Main Burners 1. Y our Weber Gas Barbecue m ust be OFF and cool. 2. T ur n OFF gas at source. 3. Disconnect regulator . 4. T o remov e control panel refer to “ Remov e the control panel and the front panel ” in the Step-By-Step Guide.
15 10. Slide the burner assembly from each Heat Zone . The left and right burners are connected by the Crossov er tube. ( 1) 9. Pull the manifold(1) out of the b ur ners.
16 GENERAL MAINTENANCE 11. Lift and twist the burner assembly slightly to separate the crossov er tube(1) from the burners. Remov e the burners from the cooking bo x. Separate here (1) 12. T o reinstall the burners, re verse steps 3 through 11. CA UTION: The burner openings m ust be positioned properl y over the v alve orifices.
17 Prob lem Burners b urn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: CA UTION: Do not line the bottom tra y with aluminum f oil. Burner flame pattern is erratic.
©2000 W eber -St ephen P roducts C o ., 200 East Danels Road, P alatine, IL 60067 -6266.U .S.A. P rinted in the U .S.A. 18.
An important point after buying a device Weber SUMMIT 650 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber SUMMIT 650 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber SUMMIT 650 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber SUMMIT 650 you will learn all the available features of the product, as well as information on its operation. The information that you get Weber SUMMIT 650 will certainly help you make a decision on the purchase.
If you already are a holder of Weber SUMMIT 650, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber SUMMIT 650.
However, one of the most important roles played by the user manual is to help in solving problems with Weber SUMMIT 650. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber SUMMIT 650 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
