Instruction/ maintenance manual of the product S-640-NG Weber
Go to page of 24
YOU MUST READ THIS OWNER’S GUIDE BEFORE OPERATING YOUR GAS GRILL DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
2 WWW . WEBER.COM ® DANGERS AND W ARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
3 WWW . WEBER.COM ® 3 Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of defects in material and workmanship from the date.
4 WWW . WEBER.COM ® + , $$ $% &* &, '# '$ '% '& * &$ &% && &' &( &) % & ' ( ) $ $# &+ S640_NG_US $& $' $( $) $* .
5 WWW . WEBER.COM ® 5 Shroud Har dwar e 1. Shroud 2. Thermometer 3. Thermometer Bezel 4. Handle 5. Qrill Out 6. TM Handle Light Rotisser ie Motor 7. Rotisser ie Brack et 8. W arming Rack 9. Cooking Grat es 10 . Flav orizer 11. ® Bars Burner T ubes 12 .
6 WWW . WEBER.COM ® OPERATING The natural gas supply is easy to use and gives you more cooking control than charcoal fuel. • These instructions will give you the minimum requirements for assembling your Weber ® gas barbecue. Please read the instructions carefully before using your Weber ® gas barbecue.
7 WWW . WEBER.COM ® 7 Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, then rinse. Flavorizer ® bars and Cooking grates - Clean with a suitable brass bristle brush. As needed, remove from grill and wash with warm soapy water, then rinse with water.
8 WWW . WEBER.COM ® GAS INSTRUC TIONS CHECK FOR GAS LEAKS WARNING: The gas connections of your Summit ® gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your Summit ® gas grill.
9 WWW . WEBER.COM ® 9 3) Remove the control panel. Tilt panel forward and lift up and away from grill. Completely remove the control panel (3) from the cooking box assembly exposing the valves, burners, igniter, and manifold. 1 3 2 GAS INSTRUC TIONS CHECK FOR GA S LEAKS D ANGER Do not use an open flame t o check for gas leaks.
10 WWW . WEBER.COM ® 6 3 4 5 2 7 1 * The grill illustrated may have slight differences than the model purchased. Check: 1) Main g as line to manif old connection. 2) R otisserie (I.R. Burner) gas line connection. 3) Bulkhead and g as supply hose connection.
11 WWW . WEBER.COM ® 11 OPERA TING INSTRUC TIONS GRILLING METHODS Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the individual burners as desired. The control settings are START/HI , MEDIUM , LOW , or OFF .
12 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS GRILLING TIPS & HELPFUL HINTS • Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C).
13 WWW . WEBER.COM ® 13 OPERA TING INSTRUC TIONS 6 1 3 2 5 * The grill illustrated may have slight differences than the model purchased. 1 3 2 4 5 * The grill illustrated may have slight differences than the model purchased. LIGHTING Summary lighting instructions are inside the left hand cabinet door.
14 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS USING THE SMOKER The smoker uses presoaked wood chips. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using finer wood chips because they ignite and create smoke faster.
15 WWW . WEBER.COM ® 15 OPERA TING INSTRUC TIONS 2 3 10 5 1 8 9 4 7 MANUALLY LIGHTING THE SMOKER BURNER 1) Open the lid. DANGER Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flare-up which can cause serious bodily injury or death.
16 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS WARNING: Setup up the rotisserie with food before lighting rotisserie burner. OPERATING 1) Remove rotisserie shaft from grill. Remove one spit fork. 2) Push the rotisserie shaft through the center of the food.
17 WWW . WEBER.COM ® 17 OPERA TING INSTRUC TIONS MANUALLY LIGHTING THE ROTISSERIE BURNER ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas supply line to fill.
18 WWW . WEBER.COM ® OPERATING THE HANDLE LIGHT The Weber Grill Out™ Handle Light has a built-in “Tilt Sensor.” With the power button (a) activated, the light will come on when the grill lid is open. The light will turn off when the lid is closed.
19 WWW . WEBER.COM ® 19 PROBLEM CHECK CURE Rotisserie burner does not light. Did you hold the burner control knob in and hold in for 20 seconds until after burner ignited? Try to relight burner by holding burner control knob in and continue holding in until 20 seconds after burner has ignited.
20 WWW . WEBER.COM ® MAINTENANCE MAIN BURNER CLEANING PROCEDURE Turn off the gas supply. Remove the manifold (See “Replace Main Burners”). Look inside each burner with a flashlight. Clean the inside of the burners with a wire (a straightened-out coat hanger will work).
21 WWW . WEBER.COM ® 21 ANNUAL MAINTENANCE INSPECTION AND CLEANING OF THE SPIDER/INSECT SCREENS To inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect screens lightly with a soft bristle brush (i.
©2007 The follo wing trademarks are regist ered in the name of Weber -Stephen P roducts Co ., an Illinois cor poration, located at 200 East D aniels Road, P alatine, Illinois 60067 U .
▲ PLEASE CONTINUE ON BACK / POR F A VOR CONTINÚE EN EL REVERSO / VEUILLEZ CONTINUER A U VERSO. ➤ ➤ ➤ 1 . How Can We Reach Y ou? / ¿Cómo Podemos Ponernos En Conta cto Con Usted? / Comment Pouvons-nous V ous Joindre? First Name / Nombre / Prénom M.
Knowing more about wh o buys our grills helps the crew back in R&D come up with new cutting edge Weber products. Please fill i n the answers you feel comfortable shari ng with us, and pass by any question you prefer to leave bl ank. Thank you for being so generous.
An important point after buying a device Weber S-640-NG (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber S-640-NG yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber S-640-NG - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber S-640-NG you will learn all the available features of the product, as well as information on its operation. The information that you get Weber S-640-NG will certainly help you make a decision on the purchase.
If you already are a holder of Weber S-640-NG, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber S-640-NG.
However, one of the most important roles played by the user manual is to help in solving problems with Weber S-640-NG. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber S-640-NG along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
