Instruction/ maintenance manual of the product PLATINUM 2200 NG Weber
Go to page of 24
PLA TINUM ™ SERIES II Natural Gas Barbecues Operating Guide NO TICE T O INST ALLER: These instructions must be left with the o wner and the owner should keep them for future use. W ARNING: Follow all leak c heck procedures carefull y in this manual prior to barbecue operation.
2 T ABLE OF CONTENTS W arnings 3 W arranty 4 A Word of Thanks 4 Standards and Codes Information 5 Storage 5 Operating Area 5 Natural Gas Supply T esting 5 *REFER TO YOUR STEP-BY -STEP SECTION A T THIS.
3 W ARNINGS D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or a fire or an e xplosion causing damage to property . ■ Do not store a spare or disconnected LP tank under or near this barbecue.
4 ST ANDARDS AND CODES INFORMA TION Y our W eber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in the food.
5 Thank you for choosing a W eber Barbecue. Our family here at W eber has worked har d to produce the highest quality pr oducts for your satisfaction. While we give much attention to our products, an occasional err or may occur . Our knowledgeable Customer Service staff is pr epar ed to help you with any pr oblems with parts or assembly .
6 LIGHTING THE MAIN BURNERS W ARNING: Check hose before eac h use of barbecue for nic ks, cracking, abrasions or cuts. If the hose is found to be dama g ed in any wa y , do not use the barbecue. Replace using only W eber authoriz ed replacement hose.
7 MANUAL LIGHTING 1) Open the lid. Figure 2. 2) Make sure all burner control knobs are turned OFF . (Push each burner control knob down and turn clockwise.) For barbecues equipped with a side burner , push the burner control knob in and turn clockwise to OFF .
8 The side burner has a separate ignition system from the main cooking box. Lighting only the side burner . Figure 3. 1) Open the side burner lid. 2) Check that the side burner valve is OFF (push in and turn clockwise), and all main burner control knobs are OFF (push down and turn clockwise).
9 COOKING The W eber Gas Barbecue should not be moved when operating or hot. If burner s go out during cooking, open lid, turn off all burner s and wait 5 minutes before relighting.
10 The Steam-N-Chips Smoker cooks with both Weber FireSpice Wood Chips and Chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the FireSpice Chips because they ignite and create smoke faster . For longer cooking foods such as roasts, chicken and turkeys, etc.
11 MAINTENANCE Spider Stopper Guards Y our Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow , and can cause the gas to flow back out of the air shutter .
12 MAINTENANCE View from behind cooking box Wing nuts Figure 11 Guide screw Figure 12 Figure 10 Replacing Main Burners a) Y our W eber Gas Barbecue must be OFF and cool. b) T urn gas OFF at source. c) T o remove the control panel, see the Step-By-Step Guide.
13 Figure 16 White wire Black wire Crosso ver Ignition System Operations If the Crossover Ignition System fails to ignite the Front burner , light the Front burner with a match. If the Front burner lights with a match, then check the Crossover Ignition System.
14 TROUBLESHOOTING Prob lem Burners b urn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: CA UTION: Do not line the bottom tra y with aluminum f oil.
15 Problem Side burner does not light. Flame is low in HIGH position. Flame is very yellow in conjunction with the smell of gas, OR Burner makes popping noise in conjunction with the smell of gas. Push button ignition does not work. Flame is large or erratic.
16 W ARNING: All gas controls and supply valves should be in the OFF position. Figure 17 (a). Make sure black wire is connected between igniter and electrode. Make sure white wire is connected between igniter and ground. Check that igniter lock nut is tight.
17 Figure 19 T o Clean the Burner Head Remove the windshield and grate. Remove the burner cap. Figure 19 (a). Clean with soap and water . Soak if necessary . Remove the burner ring. Figure 19 (b). Clean with soap and water . Soak if necessary . CAUTION: Do not enlarge the slots in the burner ring.
18 PLA TINUM SERIES II 2200 NA TURAL GAS EXPLODED VIEW ® ® ® ® ® ® ® ® W E B E R W E B E R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37.
19 PLA TINUM SERIES II 2200 NA TURAL GAS REPLACEMENT P ARTS LIST 1 Hinge pin cotter (2) 2 Hinge pin (2) 3 Lid (assembly) 4 Thermometer 5 Weber warm-up basket 6 W arming rack 7 Steam-N-Chips Smoker 8 S.
20 PLA TINUM SERIES II 3200 NA TURAL GAS EXPLODED VIEW ® ® ® ® ® ® ® ® W E B E R W E B E R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37.
21 PLA TINUM SERIES II 3200 NA TURAL GAS REPLACEMENT P ARTS LIST 1 Hinge pin cotter (2) 2 Hinge pin (2) 3 Lid (assembly) 4 Thermometer 5 Weber warm-up basket 6 W arming rack 7 Steam-N-Chips Smoker 8 S.
22 PLA TINUM SERIES II 3400 NA TURAL GAS EXPLODED VIEW ® ® ® ® ® ® ® ® W E B E R W E B E R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37.
23 PLA TINUM SERIES II 3400 NA TURAL GAS REPLACEMENT P ARTS LIST 1 Hinge pin cotter (2) 2 Hinge pin (2) 3 Lid (assembly) 4 Thermometer 5 Weber warm-up basket 6 W arming rack 7 Steam-N-Chips Smoker 8 S.
P A TENTS AND TRADEMARKS © 1998 Weber . Weber , , Genesis, Flavorizer and Crossover are registered U.S. trademarks; Perma- Mount, Gas Catcher , FlameCheck, Steam-N-Chips, Spider Stopper , and W arm-Up are U.S. trademarks of Weber-Stephen Products Co.
An important point after buying a device Weber PLATINUM 2200 NG (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber PLATINUM 2200 NG yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber PLATINUM 2200 NG - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber PLATINUM 2200 NG you will learn all the available features of the product, as well as information on its operation. The information that you get Weber PLATINUM 2200 NG will certainly help you make a decision on the purchase.
If you already are a holder of Weber PLATINUM 2200 NG, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber PLATINUM 2200 NG.
However, one of the most important roles played by the user manual is to help in solving problems with Weber PLATINUM 2200 NG. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber PLATINUM 2200 NG along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
