Instruction/ maintenance manual of the product 92774 Weber
Go to page of 20
W E B E R W E B E R SUMMIT ™ 4 BURNER & 6 BURNER Serial Number Serial Number Summit 4 Burner NG Summit 6 Burner NG 92774 10/98 ® R A P P R O V E D CANADIAN GAS ASSOCIA TION W E B E R W E B E R Read before assembly NA TURAL GAS COOKING MODULES Operating Guide W E B E R W E B E R W E B E R W E B E R W ARNING 1.
2 D ANGER Failure to f ollow the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or a fire or an e xplosion causing damage to pr oper ty . W ARNINGS ■ Do not store a spare or disconnected LP tank under or near this barbecue.
3 T ABLE OF CONTENTS W arnings 2 W arranty 4 A W or d of Thanks 4 Standards and Codes Inf ormation 5 Storage 5 Operating Area 5 Natural Gas Supply T esting 5 *REFER T O Y OUR STEP-BY-STEP SECTION A T .
4 A WORD OF THANKS W eber-Stephen Products Co . (W eber) hereb y warr ants to the ORIGINAL PURCHASER of this W eber Gas Barbecue that it will be free of def ects in material and workmanship from the d.
5 Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the Weber Gas Barbecue y ou can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer Bars produce that "outdoor" fla v or in the f ood.
6 LIGHTING 1) Open the lid. Figure 1. 2) Make sure all b urner control knobs are OFF . (Push each burner control knob down and turn clockwise.) 3) T ur n on gas supply . W ARNING: Do not lean over open barbecue. Keep your face and bod y at least one f oot awa y fr om the matchlight hole when lighting the barbecue.
7 Figure 1 Crosso ver Ignition System Summit 425 or 450 2 1 3 3 1 2 Crosso ver Ignition System Summit 625 or 650 1 3 2 Crosso ver Ignition System Summit 475 1 2 3 Crosso ver Ignition System Summit 675.
8 MANUAL LIGHTING EA CH HEA T ZONE OPERA TES INDEPENDENTL Y . Summar y lighting instructions are on the control panel. Manual Lighting Summit 425 or 450 High Medium Low Off 2 1 3 3 1 2 Manual Lighting.
9 5) Put a match in the match holder and strike the match. 6) Inser t match holder and lit match through matchlight hole to ignite LEFT burner . Figure 3. Figure 3 Control panel matchlight hole in control panel Hole in cooking bo x assembly Left burner tube MANUAL LIGHTING (CONTINUED) W ARNING: Do not lean over open barbecue.
10 W ARNING: T urn your Weber Gas Barbecue OFF and wait for it to cool bef ore c leaning. CA UTION: Do not clean y our Fla v orizer Bars or cooking grates in a self-cleaning o ven. Replacement cooking grates and Flav orizer Bars are a v ailable through y our retailer or the Weber -Stephen Customer Service Center .
11 The Steam-N-Chips Smoker cooks with both Weber FireSpice W ood Chips and Chunks . F or best results with f aster cooking f oods like steaks , b urgers and chops, etc., we recommend using the FireSpice Chips because the y ignite and create smoke f aster .
12 Spider/Insect screens Y our Gas Barbecue, as well as an y outdoor gas appliance, is a target f or spiders and other insects . They can nest in the venturi section of the b urner tubes. This bloc ks the normal gas flow , and can cause the gas to flow back out of the air shutter .
13 MAINTENANCE Figure 8 Figure 9 Replacing Main Burners 1. Y our W eber Gas Barbecue must be OFF and cool. 2. T ur n OFF gas at source. 3. T o remove control panel ref er to “Remo v e the control panel and the front panel” in the Step-By-Step Guide.
14 MAINTENANCE Manif old 8. Pull the manifold out of the b ur ners. Figure 12. Figure 12 7. Disconnect white and black wire from each igniter . Figure 11.
15 11. T o reinstall the bur ners, re v erse steps 3 through 10. CA UTION: The burner openings must be positioned properl y o ver the valve orifices. Figure 15(a). Check proper assemb ly bef ore f astening manif old in place. Figure 15 (b). Figure 15 (a) (b) Valve Burner MAINTENANCE 9.
16 MAINTENANCE Crosso ver Ignition System Operations If the Crossov er Ignition System f ails to ignite the Left burner , light the Left b urner with a match. If the Left burner lights with a match, then check the Crosso v er Ignition System. ■ Check that both the white and b lac k ignition wires are attached properly .
17 TROUBLESHOOTING Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: CA UTION: Do not line the bottom tray with aluminum f oil.
.
.
P A TENTS & TRADEMARKS © 1997 W eber-Stephen Products Co . W eber , the silhouette, Fla v orizer and Crossov er are registered U .S. trademarks; Summit, Grill Cozy , Gas Catcher , Spider Stopper , and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co .
An important point after buying a device Weber 92774 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber 92774 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber 92774 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber 92774 you will learn all the available features of the product, as well as information on its operation. The information that you get Weber 92774 will certainly help you make a decision on the purchase.
If you already are a holder of Weber 92774, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber 92774.
However, one of the most important roles played by the user manual is to help in solving problems with Weber 92774. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber 92774 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
