Instruction/ maintenance manual of the product 42373 Weber
Go to page of 15
SUMMIT ® BUILT-IN NA TURAL GAS GRILL OWNER'S GUIDE 42373 US 04/01/04 NG US English # 42373 SUMMIT ® SILVER A NOTICE TO INST ALLER: These instructions must be left with the owner and the owner should keep them for future use. DANGER If you smell gas: 1.
2 DANGERS & W ARNINGS DANGER Failure to follow the Dangers, W arnings and Cautions contained in this Owner ’ s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property . W ARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.
3 W ARRANTY W arranty Weber-Stephen Products Co. (W eber) hereby warrants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of defects in mate- rial and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accompanying it.
4 GENERAL INSTRUC TIONS CLEANING W ARNING: T urn your Weber ® gas barbecue OFF and wait for it to cool before cleaning. CAUTION: Do not clean your Flavorizer ® bars or cooking grates in a self-cleaning oven.
5 5 GAS INSTRUC TIONS Check for gas leaks DANGER Do not use an open fl ame to check for gas leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion which can cause serious bodily injury or death and damage to property .
6 6 GAS INSTRUC TIONS Remove the Front Panel by sliding the panel up and out of the slots. Check: 1) Gas line-to-manifold connections. W ARNING: If there is a leak at connection (1), retighten the fi tting with a wrench and recheck for leaks with soap and water solution.
7 7 OPERA TING INSTRUC TIONS The most important thing to know about grilling is which cooking method to use for a specifi c food, Direct or Indirect. The difference is simple: place the food directly over the fi re, or arrange the fi re on either side of it.
8 8 OPERA TING INSTRUC TIONS Indirect cooking The Indirect Method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor , and appearance you can’t get from an oven. T o set up for Indirect cooking, gas burners are lit on either side of the food but not directly be- neath it.
9 9 OPERA TING INSTRUC TIONS *The grill illustrated may have slight differences than the model purchased. T o Extinguish Push down and turn each burner control knob clock- wise to the OFF position. T urn gas supply OFF at the source. 1 2 2 3 6 4,5,8 7 Lighting Summary lighting instructions are on the control panel.
10 10 OPERA TING INSTRUC TIONS Manual Lighting *The grill illustrated may have slight differences than the model purchased. T o Extinguish Push down and turn each burner control knob clock- wise to the OFF position. T urn gas supply OFF at the source.
11 Problem Check Cure Burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section “Annual Maintenance”) Burner does not light, or fl ame is low in HIGH position.
12 12 MAINTENANCE WEBER ® SPIDER /INSECT SCREENS Y our Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas fl ow , and can cause the gas to fl ow back out of the air shutter .
13 13 MAINTENANCE Replacing Main Burners 1. Y our Summit ® gas grill must be OFF and cool. 2. T urn gas OFF at source. 3. Disconnect regulator . 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer ® bars. 7. T o remove control panel refer to “Remove the control panel” under “Check for Gas Leaks.
14 14 MAINTENANCE 1 1. Lift and twist the burner assembly slightly , to sepa- rate the Crossover ® tube (a) from the burners (b). 12. Remove the Crossover ® tube. 13. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube.
15 15 MAINTENANCE Crossover ® Ignition System Operations If the Crossover ® ignition system fails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossover ® ignition system.
An important point after buying a device Weber 42373 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber 42373 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber 42373 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber 42373 you will learn all the available features of the product, as well as information on its operation. The information that you get Weber 42373 will certainly help you make a decision on the purchase.
If you already are a holder of Weber 42373, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber 42373.
However, one of the most important roles played by the user manual is to help in solving problems with Weber 42373. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber 42373 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
