Instruction/ maintenance manual of the product 294001 Weber
Go to page of 32
43264 US 04/0 1/09 NG US ENGLISH #43264 S-660 ™ - NG G as Grill Built-In NG Gas Grill Owner’s Guide YOU MUST READ THIS OWNER’S GUIDE BEFORE OPERATING YOUR GAS GRILL. m DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames.
2 www . weber.com ® m DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. m WARNINGS m Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.
3 www . weber.com ® w arranty Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of defects in material and workmanship from .
4 www . weber.com ® 8 9 11 12 40 42 43 46 47 7 34 35 36 37 38 39 2 3 4 5 6 1 10 41 S660_NG_US 48 22 23 24 25 26 27 28 29 30 31 32 33 49 50 51 52 54 53 55 56 13 14 15 16 17 18 19 20 21 44 45 expl oded.
5 www . weber.com ® Shroud Har dware 1. Shroud 2. Thermometer 3. Thermometer Bezel 4. Handle 5. Qrill Out 6. TM Handle Light Rotisser ie Motor 7. Rotisser ie Brac ket 8. W arming Rack 9. Cooking Grat es 1 0. Flav orizer 11. ® Bars Burner T ubes 1 2.
6 www . weber.com ® OPERATING The natural gas supply is easy to use and gives you more cooking control than charcoal fuel. • Theseinstructionswillgiveyoutheminimumrequirementsforassemblingyour Weber ® gas barbecue.
7 www . weber.com ® Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, then rinse. Flavorizer ® bars and Cooking grates - Clean with a suitable stainless steel bristle brush. As needed, remove from grill and wash with warm soapy water, then rinse with water.
8 www . weber.com ® Gas instruc tions CHECK FOR GA S LEAKS m W ARNING: The gas connections of your Summit ® gas grill hav e been factory tested. We do how ever r ecommend that you leak c heck all gas connections befor e operating your Summit ® gas grill.
9 www . weber.com ® Gas instruc tions 3 1 2 A CHECK FOR GA S LEAKS m D ANGER Do not use an open flame t o check f or gas leaks. Be sur e there ar e no sparks or open flames in the ar ea while you chec k for leaks. Sparks or open f lames will result in a fir e or explosion which can cause ser ious bodily injury or death and damage to pr oper ty .
10 www . weber.com ® 3 1 2 7 6 4 5 Gas instruc tions Check: 1) Main g as line to manif old connection. 2) R otisserie (I.R. Bur ner) gas line connection. 3) Bulkhead and g as supply hose connection. 4) Bulkhead t o regulat or connection. 5) R egulator t o hose connection.
11 www . weber.com ® A B C D E SNAP IGNITION OPERATION m Always open the lid before igniting the burners Each control knob has its own igniter electrode built in. To create a spark you must push the control knob in (A) and turn to “START/High” (B) .
12 www . weber.com ® 3 1 2 4 5 LIGHTING Summary lighting instructions are inside the left hand cabinet door. m DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death.
13 www . weber.com ® 3 1 2 6 4 5 MAIN BURNER MANUAL LIGHTING m DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death.
14 www . weber.com ® opera tinG instruc tions GRILLING TIPS & HELPFUL HINTS • Alwayspreheatthegrillbeforecooking.Setallburnerson“HI”heatandcloselid; heatfor10minutes,oruntilthermometerregisters500˚-550˚F(260˚-288˚C).
15 www . weber.com ® opera tinG instruc tions USING THE SEAR ST A TION ™ Y our W eber ® gas barbecue includes a sear burner for searing meats such as steak, poultry par ts, fish, and chops). Searing is a direct grilling technique which br owns the surf ace of the food at a high temperatur e.
16 www . weber.com ® opera tinG instruc tions 1) Open the lid. 2) Make sur e all burner control knobs are turned of f. (Push contr ol knob in and turn clockwise t o ensure that it is in the “OFF” position.) 3) Turn on the gas supply at source. m W ARNING: Do not lean over the open barbecue.
17 www . weber.com ® SEAR ST A TION ™ BURNER MANU AL LIGHTING m D ANGER Failur e to open the lid while igniting the barbecue’ s bur ners, or not waiting 5 min utes t o allow the gas t o clear if the barbecue does not light, may result in an e xplosive flame-up which can cause serious bodil y injur y or death.
18 www . weber.com ® opera tinG instruc tions LIGHTING THE SMOKER BURNER SMOKER BURNER SNAP IGNITION Note: The control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate the energy for the spark by pushing in the control knob and turning to “START/HI”.
19 www . weber.com ® opera tinG instruc tions 1 3 2 6 7 8 9 4 5 MANUALLY LIGHTING THE SMOKER BURNER 1) Open the lid. m DANGER Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flare-up which can cause serious bodily injury or death.
20 www . weber.com ® m WARNING: Setup up the rotisserie with food before lighting rotisserie burner. OPERATING 1) Plug power cor d into power source . m C A UTION: Inspect power cord before each use. If cord is damaged, do not use. Contact the Customer Service Representative in your area using the contact information on our web site.
21 www . weber.com ® opera tinG instruc tions LIGHTING THE ROTISSERIE BURNER ROTISSERIE BURNER SNAP IGNITION Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate the energy for the spark by pushing in the control knob and turning to “START/HI”.
22 www . weber.com ® opera tinG instruc tions MANUALLY LIGHTING THE ROTISSERIE BURNER m ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas supply line to fill.
23 www . weber.com ® OPERATING THE HANDLE LIGHT The Weber Grill Out ™ Handle Light has a built-in “Tilt Sensor.” With the power button (a) activated, the light will come on when the grill lid is open. The light will turn off when the lid is closed.
24 www . weber.com ® PROBLEM CHECK CURE Rotisserie burner does not light. Did you hold the burner control knob in and hold in for 20 seconds until after burner ignited? Try to relight burner by holding burner control knob in and continue holding in until 20 seconds after burner has ignited.
25 www . weber.com ® maintenance REPLA CE MAIN BURNERS 1) Y our Summit ® gas grill must be of f and cool. 2) T urn gas off at sour ce. 3) Disconnect gas suppl y . 4) Remov e cooking grates . 5) Remov e smoker box. 6) Remov e Flavorizer ® bar s. REMO VE CONTROL P ANEL P ar t requir ed: Phillips Screwdriv er .
26 www . weber.com ® maintenance Be careful not t o break or disconnect the wir es for the contr ol panel lights. Rest the contr ol panel against the lef t side of the grill (A) exposing the val ves, burners , igniter , and manifold. 8) Remov ethet woscrewsthatsecur ethemanifoldtothecookbo x.
27 www . weber.com ® maintenance ANNUAL MAINTENANCE INSPECTION AND CLEANING OF THE SPIDER/INSECT SCREENS To inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens.
www . weber.com ® 28.
www . weber.com ® 29.
©2009The follo wing trademarks are regist ered in the name of Weber -Stephen P roducts Co., an Illinois cor poration, located at 200 East Daniels Road, Palatine, Illinois 60067 U.
PLEASE CONTINUE ON BACK / POR FA VOR CONTINÚE EN EL REVERSO / VEUILLEZ CONTINUER AU VERSO. ➤ ➤ ➤ thanK you F or purchasinG a weber ® Grill. you’ve made a wise investment , now t aKe a Few minutes and protec t it b y reGisterinG your produc t .
©2008 We ber-Stephen Products Co. All rights reserved. Printed in U.S.A. 557 98_07 08 Thanks for sha ring your contact information with us. Ag ain, it all stays strictly between us — Weber does not sh are customers’ names with anyone else.
An important point after buying a device Weber 294001 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber 294001 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber 294001 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber 294001 you will learn all the available features of the product, as well as information on its operation. The information that you get Weber 294001 will certainly help you make a decision on the purchase.
If you already are a holder of Weber 294001, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber 294001.
However, one of the most important roles played by the user manual is to help in solving problems with Weber 294001. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber 294001 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
