Instruction/ maintenance manual of the product 465611003 Thermos
Go to page of 28
WARNING CA UTION Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary. Failure to follow all manufacturer’s instructions could result in fire or explosion which could cause property damage, personal injury or death.
2 • Grill2Go D ANGER WARNING CA UTION FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance.
Grill2Go • 3 LP (Liquefied Petroleum Gas) • For Your Safety • LP gas is highly flammable and may ignite unexpectedly when mixed with air. Is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled.
4 • Grill2Go Warranty THERMOS GRILLS Consumer Warranty / P.O. Box 1240 Columbus, GA 31902-1240 Thermos warrants to the original consumer-purchaser that this product shall be free from defects in wor.
Grill2Go • 5 For Your Safety .............................................................2 Safety Symbols LP (Liquefied Petroleum Gas) .................................................3 Grill Service Center Installation Safety Precautions Warranty Information Warranty .
6 • Grill2Go Parts List and Diagram – Grill Lid Key Qty. Description Part No. Included in Model 465621303 Qty. Description Part No. A 1 Lid 65-6047-063-204 B 2 Upper Hinge 65-6047-093-200 C 1 Hand.
Grill2Go • 7 Parts List and Diagram – Grill Bottom and Burner System Key Qty. Description Part No. G 1 Ignitor Wire 69-6047-332-200 H 1 Regulator Lock 69-6047-340-200 I 1 Grate 65-6047-339-200 J 1.
8 • Grill2Go Parts List and Diagram – Plinth and Legs Key Qty. Description Part No. BB 1 Plinth 64-6047-359-203 CC 1 Leg - Left 1 1-6047-036-201 DD 1 Leg - Right 1 1-6047-037-201 EE 1 Leg Latch 21-6047-394-200 GG 4 Leveling Blocks 1 1-6047-065-200 HH 1 Match-Light Stick 63-6047-369-200 I I 1 Square Washer 21-6047-419-200 Key Qty.
Grill2Go • 9 Assembly Your grill will require minimal assembly. The Grill2Go™ is packaged in three major components. Additional parts are stored beneath grill lid.
10 • Grill2Go Coach bolts pass completely through holes in plinth and legs. NOTE: Use square hole, not round hole, when assembling plinth to legs. Plastic Fastener Washer NOTE: Do not fully tighten fasteners at this time. Fully unfold legs to position shown above and hand-tighten the four plastic fasteners.
Grill2Go • 11 Grease container slides onto slot on left side of plinth. Cap should be open when installing. Tab on grill bottom snaps under front lip of plinth. Grill fits firmly onto plinth. Ignitor on grill bottom fits into slot in plinth. A Attach 1 lb.
12 • Grill2Go Insert shelf rods into holes in sides of grill bottom. Shelf with valve cutout attaches to right side of grill. WARNING Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.
Grill2Go • 13 Your Grill2Go™ can be used with the legs fully extended or folded beneath the grill. To use grill on a table-top, fully loosen plastic fasteners (A), fold legs inward until they latch together (B), then hand-tighten the fasteners to secure legs in the closed position (C).
14 • Grill2Go Use and Care Propane Cylinder Use (1 lb. Disposable) • • • • Use only cylinder marked “Propane Fuel”. Size should be 4” diameter , 8” height, or 3” diameter , 10” height. Save cylinder cap and reinstall when not in use.
Grill2Go • 15 Propane Cylinder Use (20 lb. Refillable) The 20 lb. LP tank used with your grill must meet the following requirements: • • • Use only tanks equipped with this type of valve.
16 • Grill2Go Leak Testing (20 lb. Refillable) IMPORT ANT! For your safety • • • • Use mild soap and water. Do not use household cleaning agents. (A) Leak test must be repeated each time LP tank is exchanged or refilled. Do not smoke during leak test.
Grill2Go • 17 Connecting The Adapter Hose To The LP Tank (continued) 5. Hold hose end, insert nipple (A) into LP tank valve. Hand tighten coupling nut, (B) so as not to cross thread the connection. holding connector in a straight line with LP tank valve Position coupling nut and hose-end as shown for proper connection to LP tank valve.
18 • Grill2Go WARNING • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, close LP tank valve and call LP gas supplier or your fire department! immediately Leak Testing Valves, Hoses and Regulator Turn grill control knob to off.
Grill2Go • 19 For Safe Use Of Your Grill: • • • • • • • Operate grill with 1 lb. cylinder in correct position as shown in . • Always remove 1 lb. cylinder from grill when transporting. • Operate grill with 20 lb. cylinder in correct position as show in .
20 • Grill2Go Safety Tips s s s s s s s s The use of alcohol, prescription or nonprescription drugs may impair the consumer ’s ability to properly assemble or safely operate the appliance. When grill is not in use, disconnect 1 lb. cylinder or turn off 20 lb.
Grill2Go • 21 Ignitor Check Regulator/Valve must be in “Off” position. Ignitor Lighting Remove cooking grid. Press ignitor button rapidly . “Click” should be heard and spark seen each time between burner and electrode. Replace cooking grid. See T roubleshooting if no click or spark.
22 • Grill2Go Match Lighting 1. Push Regulator/V alve in and turn counterclockwise to LIGHTING POSITION. 2. Attach match to match lighting stick, light match. 3. Insert match lighting stick into vent hole at rear of grill. WARNING If burner does not light within 5 seconds, turn knob to OFF, wait 5 minutes, try again.
Grill2Go • 23 General Grill Cleaning Do not apply a caustic grill/oven cleaner to painted surfaces. Plastic Side Shelves: • Non-Stick Cooking Surface: • Grease Bottle: • Do not mistake brown or black accumulation of grease and smoke for paint.
24 • Grill2Go CA UTION Clean burner prior to use after storing, at the beginning of grilling season or after a period of one month not being used. Spiders and insects like to build nests in burner tubes (especially during colder months). These nests can cause fires in burner tubes or under grill.
Grill2Go • 25 Food Safety Clean: Separate: Cook: Chill: How to Tell if Meat is Grilled Thoroughly • • • • • Food safety is an important part of enjoying the outdoor cooking experience.
26 • Grill2Go Troubleshooting Problem Burner will not light using ignitor. Burner will not match light. Flames blow out. Flashback (fire in burner tube) Possible Cause Electrode and burner are wet. Electrode cracked or broken, "sparks at crack".
Grill2Go • 27 Recreational Vehicles THERMOS GRILLS has approved use of the Grill2Go™ with specific recreational vehicles subject to the following provisions: • The is to be directly connected to an additional 20 lb. or 30 lb. DOT/TC LP tank mounted on the RV .
® A Division of W.C. Bradley Company P .O. Box 1240 Columbus, GA 31902–1240 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, C.
An important point after buying a device Thermos 465611003 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Thermos 465611003 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Thermos 465611003 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Thermos 465611003 you will learn all the available features of the product, as well as information on its operation. The information that you get Thermos 465611003 will certainly help you make a decision on the purchase.
If you already are a holder of Thermos 465611003, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Thermos 465611003.
However, one of the most important roles played by the user manual is to help in solving problems with Thermos 465611003. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Thermos 465611003 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
