Instruction/ maintenance manual of the product R16 Harman Stove Company
Go to page of 44
.
.
3 XXV Pellet Stove Pellet fuel quality can uctuate from manufacturer to manufacturer , and even from bag to bag. Hearth & Home T echnologies recommends using only fuel that is certied by the Pellet Fuels Institute (PFI).
4 XXV Pellet Stove This label is located on the back of the unit. Please copy the Serial Number for future reference. FOR USE WITH PELLETIZED WOOD FUEL OR CORN/PELLET MIXTURE ONL Y .
5 XXV Pellet Stove Thank you for purchasing the Harman XXV Pellet Stove. The Harman XXV Pellet Stove is the culmination of elegance, convenience, functionality and dependability The XXV was thoughtfully designed to look captivating in every home.
6 XXV Pellet Stove .
7 XXV Pellet Stove Place the stove on a non-combustible floor pr ote cto r t hat e xte nds a mi nim um of 6 inc hes t o the front (152mm), 6 inches to the sides (152mm) and 6"(152mm) to the rear , which is ush with the rear of the hopper .
8 XXV Pellet Stove W ARNING: V enting terminals must not be recessed into a wall or siding.
9 XXV Pellet Stove A com bus ti on bl owe r is use d to ext ra ct the comb us ti on gas es fro m the re box . This caus es a neg at ive pres su re in the rebox and a positive pressure in the venting syste m as shown in Fig.
10 XXV Pellet Stove Outside air ex pipe goes here. Inlet Cover part# 1-10-08542 Flex pipe part# 1-00-08543 (25') Fig. 7 Fig.
1 1 XXV Pellet Stove This method provides excellent venting for normal operation and allows the stove to be installed closest to the wall. T wo inches from the wall is safe; however , four inches allows better access to remove the rear panel.
12 XXV Pellet Stove This method provides excellent venting for normal operation. This method also provides natural draft in the event of a power failure.
13 XXV Pellet Stove This method can be done with or without a ue liner .
14 XXV Pellet Stove .
15 XXV Pellet Stove It is recommended that outside air be installed with this venting conguration to reduce smoke and creosote smell in the room in the event of power failure.
16 XXV Pellet Stove Indicates that the ESP (Exhaust Sensing Probe) has gone out of range too many times.
17 XXV Pellet Stove These units are pre-tested at the factory with exactly 120 V olts A.C., 60 Hz. They are checked and adjusted for rebox tightness, gasket leakage, motor operation and igniter operation. The XXV is then factory set at a mid-point adjustment and in most cases will not need any adjustments.
18 XXV Pellet Stove This setting, see above, will produce a room temperature of 70 degrees with the distribution blower at medium speed.
19 XXV Pellet Stove Fig. 21 Thi s s etti ng, se e a bove , w ill pr oduc e c ont inuo us max imum he at out put wit h th e di str ibut ion blo wer at full sp eed.
20 XXV Pellet Stove Make sure the unit is plugged into a 120 V AC, 60 HZ electrical source. The power light should be the only light lit.
21 XXV Pellet Stove The XXV Pellet Stove is capa ble of manu al operat ion. This also all ows the oper ator to manually control operation during an emergency (i.e. igniter failure, or when using certain generators.) The unit can be switched between "AUTO" and "MANUAL" at any time during operation.
22 XXV Pellet Stove Fig. 28 1" See Hint #7. 1. Fines are small pieces of broken pellets (sawdust). Fines do not ow easily and often build up on the hopper funnel bottom angles.
23 XXV Pellet Stove The room sensor is a small temperature sensor on the end of a 60" wire. This sensor is installed much li ke a stand ard wall th ermost at. Becau se it is so small, it can be hidden along the trim of a doorway or even up the leg of a coffee table.
24 XXV Pellet Stove Fuel qual ity and moistu re conte nt will dicta te how often it will be necessary to empty the ash pan.
25 XXV Pellet Stove The products of combustion will contain small particles of yash. The yash will collect in the exhaust venting system and restrict the ow of the ue gases.
26 XXV Pellet Stove 1. Scrape the top holed surface and sides of the burn pot. (Fig 39) It is not necessary to completely remove all loose material from the burn pot.
27 XXV Pellet Stove The glass in your Harman stove is a special ceramic glass. • Do not abuse the glass by striking or slamming the door . • Never burn the appliance if the door glass is cracked or broken. • Replace only with Harman supplied 5mm ceramic glass.
28 XXV Pellet Stove The Harman Direct V ent W all Passthrough makes installing your Harman Pellet Stove with outside air a lot easier .
29 XXV Pellet Stove 1. No fuel in hopper . 2. Firebox draft may be too low for sensing switch in feeder circuit to operate. , loose or missing gasket on doors or hopper lid.
30 XXV Pellet Stove .
31 XXV Pellet Stove 31 XXV Pellet Stove 31 XXV Pellet Stove .
4021-645C 12-29-10 Page 1 of 2 Hearth & Home T echnologies Inc. LIMITED LIFETIME W ARRANTY Hearth & Home T echnologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer .
4021-645C 12-29-10 Page 2 of 2 W ARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor . A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation.
Harman pellet burning, free-standing stoves and inserts have been tested t o ASTM E1509 for burning shelled corn in a mixture with wood pellets. The listing appro ves up to a 50% corn and 50% pellet mixture. Di erent mixtures of corn will have distinctively di erent burn characteristics depending upon moisture con tent and variety .
04/12 .
04/12 IMPORT ANT : THIS IS DA TED INFORMA TION.
04/12 IMPORT ANT : THIS IS DA TED INFORMA TION.
04/12 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .
04/12 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .
04/12 IMPORT ANT : THIS IS DA TED INFORMA TION.
41 XXV Pellet Stove Date Of Service Performed By Description Of Service.
42 XXV Pellet Stove Date Of Service Performed By Description Of Service.
.
Proudly P rinted On 100% Recycled P aper At Harman, w e build each product to a standar d, not a price . This po werful heating appliance boasts uncompromising attention to detail and helps preserve our planet by using envir onmentally responsible fuels.
An important point after buying a device Harman Stove Company R16 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Harman Stove Company R16 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Harman Stove Company R16 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Harman Stove Company R16 you will learn all the available features of the product, as well as information on its operation. The information that you get Harman Stove Company R16 will certainly help you make a decision on the purchase.
If you already are a holder of Harman Stove Company R16, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Harman Stove Company R16.
However, one of the most important roles played by the user manual is to help in solving problems with Harman Stove Company R16. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Harman Stove Company R16 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
