Instruction/ maintenance manual of the product 4638220 Char-Broil
Go to page of 16
THIS GRILL IS FOR OUTDOOR USE ONLY Failure to follow all manufacturer ’s instructions could result in serious personal injury and/or property damage. WARNING ! CA UTION ! Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary .
WARNING FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP Tank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1.
Table of Contents For Y our Safety ..................................2 Call Grill Service Center for Help and Parts .............2 W arranty Information ..............................2 Installation Safety Precautions .......................2 Safety Symbols .
Parts List - Model 4638220 Key Qty. Description Part # A 1 W arming Rack ............... 4152125 B 1 Cooking Grate ............... 4152741 C 1 Leg Extender Assembly ........ 4154468 D 1 Handle ..................... 4154488 E 1 Drip V apoRISER Bar ....
A B C H E F W V V U V V G I J J J J L L K M M N N O O O P P P P Q R S Y Z D X T T T T 4638220 • 5.
1 2 0000000000 0000000 This label contains the model and serial number for your grill. You should also write this information on page 2 of this manual in the “Warranty Information” box. Remove end of rating label located on your grill’s back panel (see parts list to identify) and apply to your warranty card in box #5.
1ST 2ND Do not let briquets cover burner port holes. BA CK OF GRILL 4 3 BA CK OF GRILL BACK PANEL BACK PANEL 1. Stand grill upside down and attach back panel to legs and brace with four bolts and nuts. 2. Facing back of grill, depress buttons and snap leg extender assembly into right legs and wheel assembly ( ) into left legs.
6 5 You may have: Hinge pin only OR Hinge pin and hitch pin 1. Place lid onto grill bottom. Attach with two hinge pins. 2. Insert handle into grill lid. Attach with two wing nuts. 3. Be sure clips are attached to logo plate posts. Snap logo plate into grill lid.
8 7 Qty. 4 1. Install side shelves by sliding shelf tubes over ends of leg tubes. Press firmly so that holes are aligned. Secure with one push-fastener on each leg. 1. Hang grease clip from center of grill bottom. Use an empty soup can to hang from grease clip.
9 1. Beneath control panel, attach 12’ natural gas hose to valve. 2. Tighten the connection with an adjustable wrench. 3. LEAK TEST AS SHOWN ON PAGE 12 BEFORE USING GRILL.
Connecting Your Grill to the Natural Gas Source 1. Coat pipe nipple with gas resistant dope. Screw socket onto gas manifold at gas source (A). 2. Connect unattached end of natural gas hose to socket. Push sleeve back on socket (B) and insert plug until sleeve snaps forward, locking plug into socket.
WARNING • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, immediately close LP tank Valve and call LP gas supplier or your fire department! Leak Testing Valve and Hose 1.
Ignitor Lighting s s Do not lean over grill while lighting. Open lid. Do not lean over grill while lighting. Open lid. 1. T urn on gas at gas source. 2. T urn LEFT knob to IGNITE. 3. Push IGNITOR Button rapidly to light. Be sure burner lights and stays lit.
Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. 2. Remove cooking grate and drip vaporiser bar . 3. Discard used briquets before removing burner and briquet grate.
Cooking Chart Cooking times and temperatures may vary according to specific recipes, cooking conditions or barbecue equipment used. T ake these factors into consideration to insure best results. If you use the indirect cooking method (lighting only one burner and placing food on opposite side of cooking grate), allow more grilling time.
Troubleshooting Problem Burner will not light using ignitor. Burner(s) will not match light. Flames blow out. Flare-up. Persistent grease fire (can damage the appearance of steel panels and aluminum castings on the grill). Flashback... (fire in burner tube(s) Possible Cause Wire and/or electrode covered with cooking residue.
An important point after buying a device Char-Broil 4638220 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil 4638220 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil 4638220 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil 4638220 you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil 4638220 will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil 4638220, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil 4638220.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil 4638220. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil 4638220 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
