Instruction/ maintenance manual of the product PW3270 Campbell Hausfeld
Go to page of 28
Gasoline Power ed Pr essur e W ashers Product Manual PW2770, PW3270 and PW4070 Carefully read and understand these instructions before operating your pressure washer . © 2008 Campbell Hausfeld/ Scott Fetzer IN469600A V 9/08 Frequently Asked Questions .
Operating Instructions and Parts Manual www .chpower .com Fr equently Asked Questions How do I start my pr essure washer? 1. Make sure you have gas and oil in the engine. The engine does not come with oil. 2. T urn the water on, then squeeze the trigger on the gun to make sure the water will flow smoothly out of the tip.
3 Getting to Know Y our Pressur e W asher 1 Fuel T ank 2 T ip Holder with Spray Tips 3 Gun with T rigger 4 Engine switch - On/Off 5 Engine Oil Fill 6 Serial Number/Product Decal 7 Lance 8 Pressure Adj.
5. Know how to stop this product and bleed pressure quickly . Be thoroughly familiar with the controls. 6. Stay alert – watch what you are doing. 7. Do not operate the product when fatigued or under the influence of alcohol or drugs. 8. Keep operation area clear of all persons.
5 Pr e-Operation Keep hose away from sharp objects. Bursting hoses may cause injury . Examine hoses regularly and r eplace if damaged. Do not attempt to mend a damaged hose. UNP ACKING Remove the equipment and all parts from the carton. The carton should contain the following.
Figure 9 - T rigger unlocked Engaged Disengaged 6 Pr e-Operation (Continued) 7. Install quick connect tip (See Figure 7). Operation Never run the unit dry . Be sure the water supply is completely turned on before operating the unit. 5. T rigger the gun until water sprays from the tip indicating that all air is purged from the system.
7. Start the engine: Unlock the trigger safety latch on the gun. Grasp the starter rope and brace one foot on the chassis. While squeezing the trigger on the gun, pull the starter rope rapidly and firmly . Continue holding the rope as it returns. Repeat these steps until the engine starts.
Operating Instructions and Parts Manual NOTE : Use only detergents formulated for pressure washers.T est detergent in an inconspicuous area before use. DETERGENTS The use of detergents can dramatically reduce cleaning time and assist in the removal of difficult stains.
9 Operation (Continued) 5. Disconnect the spark plug wire and remove the spark plug. 6. Pour 1/2 oz. of engine oil into the spark plug hole. Never pull the starter rope on the engine when the spark plug is removed unless the spark plug hole is covered.
Engine Oil T ype SAE 10W-30 (See Honda’ s Owner Manual) Engine Oil Capacity Honda GX160 20 fl. oz. Honda GX270 37 fl. oz. Honda GX390 37 fl. oz. Engine Fuel Capacity Honda GX160 3.3 US quarts (3.1 L) Honda GX270 5.6 US quarts (5.3 L) Honda GX390 6.4 US quarts (6.
11 www .chpower .com 1 Base Plate PM237600SJ PM237600SJ PM237600SJ 1 2 Pneumatic Wheel WA005620A V WA005620A V WA005620A V 2 3 Pushnut AL066300A V AL066300A V AL066300AV 2 4 5/16 in.
Operating Instructions and Parts Manual 12 www .chpower .com T roubleshooting Chart - Gasoline Power ed Pressur e W ashers Only Symptom Possible Cause(s) Corrective Action(s) Engine will not start or .
13 www .chpower .com PW2770, PW3270, and PW4070 Notes T roubleshooting Chart - Gasoline Power ed Pressur e W ashers Only Pump noisy / pump runs rough Pressure washer will not spray detergent 1. Pump drawing in air/low water supply 2. V alves dirty or worn 3.
Operating Instructions and Parts Manual 14 www .chpower .com Limited W arranty 1. DURA TION: From the date of purchase by the original purchaser as follows: Three Y ears 2. WHO GIVES THIS W ARRANTY (WARRANTOR): Campbell Hausfeld / Scott Fetzer Company , 100 Production Drive, Harrison, OH 45030, T elephone: 1-800-330-0712 3.
Model PW2770 Model PW3270 Model PW4070 Lavadoras a pr esión con motor a gasolina Lea cuidadosamente y entienda estas instrucciones antes de poner en funcionamiento su lavadora a presión.
Pr eguntas Frecuentes Para encender la lavadora a pr esión 1. Asegúrese de que el motor tenga gasolina y aceite. El motor se entrega sin aceite. 2. Abra el pase de agua, luego presione el gatillo de la pistola para asegurarse de que el agua fluya con facilidad desde la boquilla.
PW2770, PW3270, y PW4070 17 Sp Conozca su Lavadora a pr esión 1 T anque de combustible 2 Soporte para boquillas con boquillas de pulverización 3 Pistola con gatillo 4 Interruptor de encendido/apagad.
7. No haga funcionar el producto cuando esté fatigado o bajo la influencia de drogas o alcohol. 8. Mantenga a todas las personas alejadas del área de funcionamiento. 9. No se estire ni se pare sobre un apoyo inestable. Mantenga un buen soporte y equilibrio en todo momento.
19 Sp Pr evio al funcionamiento DESEMP AQUE Retire el equipo y todas las piezas de la caja. La caja debe contener lo siguiente. • Una lavadora a presión (bomba, motor , base del carro) • Un conju.
Figura 9 – Gatillo sin seguro T rabado Sin trabar 20 Sp Pr e-Funcionamiento (Cont.) 7. Instale la boquilla de conexión rápida (V er Figura 7). Funcionamiento No haga funcionar nunca la unidad en seco. Asegúrese de que el suministr o de agua esté completamente abierto antes de hacer funcionar la unidad.
7. Arranque el motor: Destrabe el seguro del gatillo de la pistola. Agarre el cordón de arranque y coloque un pie en el marco. Mientras oprime el gatillo de la pistola, hale del cordón de arranque con rapidez y firmemente. Siga manteniendo el cordón mientras lo devuelve.
NOT A: Use sólo detergentes formulados para lavadoras a presión. Pruebe el detergente en un área poco visible antes de usar . DETERGENTES El uso de detergentes puede reducir radicalmente el tiempo de limpieza y ayudar a eliminar las manchas resistentes.
23 Sp Funcionamiento (continuación) la bujía. 6. V ierta 1/2 oz. de aceite de motor en el orificio de la bujía. Nunca hale del cordón de arranque después de haber quitado la bujía a menos de que haya cubierto el orificio de la bujía. La chispa puede encender el vapor del combustible.
Tipo de aceite para el motor SAE 10W-30 Capacidad del aceite para el motor Honda GX160 0,59 L (20 fl. oz.) Honda GX270 1,0 L (37 fl. oz.) Honda GX390 1,0 L (37 fl.
25 Sp 5 19 3 9 2 8 10 1 11 12A 13 12C 12B 14 6 7 4 15 16 17 18 17 20 Sírvase proporcionar la siguiente información: - Número de modelo - Número de Serie (de haberlo) - Descripción y número del r.
26 Sp Manuel de Instrucciones y Lista de Piezas T abla de solución de problemas – Sólo para lavadoras a pr esión a gasolina Síntoma Causa(s) posible(s) Acción(es) a tomar El motor no arranca o .
27 Sp PW2770, PW3270, y PW4070 T abla de solución de problemas – Sólo para lavadoras a pr esión a gasolina (continuación) Pérdida de aceite entre el motor y la bomba Presión fluctuante La pres.
28 Sp Manuel de Instrucciones y Lista de Piezas Garantía Limitada 1. Duracion: De la fecha de compra por el comprador original y de acuerdo a las siguientes clasificaciones: Normas (Standard Duty) – T res Años 2.
An important point after buying a device Campbell Hausfeld PW3270 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Campbell Hausfeld PW3270 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Campbell Hausfeld PW3270 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Campbell Hausfeld PW3270 you will learn all the available features of the product, as well as information on its operation. The information that you get Campbell Hausfeld PW3270 will certainly help you make a decision on the purchase.
If you already are a holder of Campbell Hausfeld PW3270, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Campbell Hausfeld PW3270.
However, one of the most important roles played by the user manual is to help in solving problems with Campbell Hausfeld PW3270. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Campbell Hausfeld PW3270 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
