Instruction/ maintenance manual of the product 030208 Briggs & Stratton
Go to page of 36
Owner’s Manual Manual del Propietario Manual No . 195432GS Revision 0 (08/03/2004) Questions? Help is just a moment a wa y! Preguntas? La a yuda es justa un momento lejos! Call: Generator Helpline -.
2 3500W Portable Generator T ABLE OF CONTENTS Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 Know Y our Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Assembly . . . . . . . . . . . . . .
3 3500W Portable Generator • Operate generator ONL Y outdoors. • DO NO T operate generator inside any building or enclosur e , including the generator compartment of a recreational v ehicle (R V). Running generator gives off carbon mono xide , an odorless, colorless, poison gas.
3500W Portable Generator 4 • DO NO T tamper with gov erned speed. Generator supplies corr ect rated frequency and v oltage when running at gov erned speed. • DO NO T modify generator in any wa y . Excessivel y high operating speeds increase risk of injury and damage to generator .
3500W Portable Generator 5 120 V olt A C , 20 Amp, Duplex Receptacles — May be used to supply electrical pow er for the operation of 120 V olt A C , 20 Amp , single phase, 60 Hz electrical, lighting, appliance, tool and motor loads.
3500W Portable Generator 6 ASSEMBL Y Y our generator requir es some assembly and is ready for use after it has been properl y ser viced with the recommended oil and fuel. If you ha ve an y problems with the assembly of y our generator , please call the generator helpline at 1-800-743-4115 .
7 3500W Portable Generator 6. Retain wheel on axle stud with retaining pin. Install other wheel on remaining axle stud the same wa y . 7. Attach support leg using two 1/2” or 13mm wrenches with 20mm cap scr ews and lock nuts. 8. Center lifting handle on generator end of cradle.
3500W Portable Generator 8 USING THE GENERA T OR System Gr ound The generator has a system ground that connects the generator frame components to the ground terminals on the AC output r eceptacles. The system gr ound is connected to the AC neutral wir e (the neutral is bonded to the generator frame).
9 3500W Portable Generator NO TE: If engine starts after 3 pulls but fails to run, or if unit shuts down during operation, mak e sure unit is on a lev el surface and check for proper oil le vel in crankcase. This unit ma y be equipped with a low oil protection de vice.
3500W Portable Generator 10 120 V olt A C , 20 Amp , Duplex Receptacles Each duplex receptacle (Figur e 5) is protected against ov erload by a push–to–r eset circuit br eaker . Use each receptacle to operate 120 V olt A C, single–phase , 60 Hz electrical loads requiring up to 1,750 watts (1.
11 3500W Portable Generator DON'T O VERLO AD GENERA T OR Capacity Y ou must mak e sure your generator can suppl y enough rated (running) and surge (starting) watts for the items you will pow er at the same time. Follow these simple steps: 1. Select the items you will po wer at the same time.
3500W Portable Generator 12 SPECIFICA TIONS Maximum Surge W atts . . . . . . . . . . . . . . . . . .4,800 watts Continuous W attage Capacity . . . . . . . . . . . .3,500 watts P ower Factor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3500W Portable Generator 13 ST ORA GE The generator should be started at least once every seven da ys and allowed to run at least 30 minutes. If this cannot be done and you m ust store the unit f or more than 30 da ys, use the following guidelines to pr epare it for storage.
3500W Portable Generator 14 TR OUBLESHOO TING Pr oblem Cause Corr ection No AC output is a vailable, but generator is running. 1. One of the circuit br eakers is open. 2. Fault in generator . 3. P oor connection or defective cor d set. 4. Connected device is bad.
3500W Portable Generator 15 NO TES.
3500W Portable Generator 16 SCHEMA TIC.
3500W Portable Generator 17 WIRING DIA GRAM.
3500W Portable Generator 18 EXPLODED VIEW - MAIN UNIT.
3500W Portable Generator 19 EXPLODED VIEW - P AR TS LIST Item P ar t # Description 1 M194779GS CRADLE 2 194396GS KIT , Vibration Mount 4 186058A GS HOUSING, Engine Adapter 5 NSP ASSY , Alternator (see.
3500W Portable Generator 20 EXPLODED VIEW AND P AR TS LIST - AL TERNA T OR Item Part # Description 1 186059GS AD APTER, Mounting, Alternator 2 191685GS R O T OR 3 191686A GS ST A T OR 4 186060GS RBC, with O-Ring (p/n 189197GS) 5 86308GS HHCS, M6 - 1.0 x 115 SEMS 6 91825GS ASSY , Holder , Rectifier/Brush 7 66849GS T APTITE, M5 - 0.
3500W Portable Generator 21 EXPLODED VIEW AND P AR TS LIST - CONTROL P ANEL Item Part # Description 1 195112GS KIT , Cov er Control Panel 2 188889A GS CONTR OL P ANEL, Compact 6 68759GS OUTLET , 120V .
22 3500W Portable Generator EXPLODED VIEW AND P AR TS LIST - WHEEL KIT Item Part # Description 1 189715GS ASSY , Handle (Includes Item 11) 2 94034GS LEG, Mounting 3 52858GS NUT , Locking Hex M8 - 1.25 4 * HHCS, M8 - 1.25 x 45 5 93728GS AXLE 6 87280GS WHEEL 7 87005A GS PIN 8 * W ASHER, Flat M12 9 94222QGS NUT , 5/8 - 18 Jam Lock 10 * HHCS, M8 - 1.
BRIGGS & STRA TTON PO WER PRODUCTS GR OUP , LLC EQUIPMENT O WNER WARRANTY POLICY LIMITED W ARRANTY Briggs & S tratton Power Products Group, LLC will repair or replace, free of charge, any part(s), of the equipment that is defective in material or workmanship or both.
Generador Portátil de 3500W 24 T ABLA DE CONTENIDOS Reglas De Seguridad . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-26 Conozca Su Generador . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 Ensamblaje . . . . .
Generador Portátil de 3500W 25 • Opere el generador SOLAMENTE al air e libre. • NO opere el generador dentro de un edificio o lugar cerrado , incluyendo el compartimiento del generador en un vehículo recr eativo o R V . Al generador funcionar , se produce monóxido de carbono , un gas inodor o y venenoso .
Generador Portátil de 3500W 26 • NO cambie ninguna velocidad determinada. El generador suministra una frecuencia y un v oltaje calificado cuando funciona a una velocidad determinada. • NO modifique al generador en ninguna forma. Las velocidades de operación en exceso , aumentan los riesgos de heridas y daños al generador .
Generador Portátil de 3500W 27 CONOZCA SU GENERADOR LEA ESTE MANU AL DEL PROPIET ARIO Y LAS REGLAS DE SEGURID AD ANTES DE OPERAR SU GENERADOR. Compare las ilustraciones con su Generador para familiarizarse con las ubicaciones de los dif erentes contr oles y ajustes.
Generador Portátil de 3500W 28 MONT AJE Su generador requier e de cier tos procedimientos de montaje y solo estará listo para ser utilizado después de haberle suministrado ser vicio con el combustible y aceite recomendados.
Generador Portátil de 3500W 29 NO T A: Está seguro instalar la rueda con inboar d levantado de eje. 5. La unidad de la punta e instala la rueda. Coloque arandela plana sobre semental de eje. 6. Retenga la rueda en el eje llena de alfiler que retiene.
Generador Portátil de 3500W 30 USO DEL GENERADOR Tierra del Sistema El generador dispone de una conexión a tierra del sistema que conecta los componentes del bastidor a los terminales de tierra de los enchufes hembra de salida de CA.
Generador Portátil de 3500W 31 Conexion De Cargas Electricas • Deje que el motor se estabilice y se caliente por unos minutos después del arranque. • Conecte y encienda las cargas eléctricas de 120 y/o 240 V oltios A C monofásicas de 60 Hz que desse.
Generador Portátil de 3500W 32 120 V olt A C , 20 Amp , Receptáculos Dobles Cada receptáculo (Figura 12) está pr otegido en contra de sobrecargas por un corto-circuitos de, del tipo "empuje para reposicionar". Use cada receptáculo para operar 120 V oltios AC, de fase sencilla, de cargas de 60Hz que requier en hasta 1,750 vatios (1.
Generador Portátil de 3500W 33 NO SOBRECARGUE GENERADOR Capacidad Usted debe asegurarse que su generador puede pro veer el suficiente vataje calificado (cuando esté funcionando) y de carga (al encender) para los aparatos a los cuales va a pr ov eer la energía, al mismo tiempo.
Generador Portátil de 3500W 34 ESPECIFICA CIONES Potencia Máxima . . . . . . . . . . . . . . . . . . . . . . 4,800 V atios (4.8 kW) Potencia de Sobretensión . . . . . . . . . . . . . . . 3,500 V atios (3.5 kW) V oltaje Nominal AC . . . . . . . . . .
Generador Portátil de 3500W 35 ALMA CENAMIENT O El generador deberá ser encendido al menos una vez cada siete días y deberá dejarlo funcionar al menos durante 30 minutos. Si no puede hacer esto y debe almacenar la unidad por más de 30 días, siga las siguientes instrucciones para preparar su unidad para almacenamiento .
POLÍTICA DE GARANTÍA P ARA EL PROPIET ARIO DE EQUIPOS BRIGGS & STRA TTON PO WER PRODUCTS GROUP , LLC GARANTÍA LIMIT ADA Briggs & S tratton Power Products Group, LLC reparará o sustituirá sin cargo alguno cualquier componente del equipo que presente defectos de materiales y/o mano de obra.
An important point after buying a device Briggs & Stratton 030208 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Briggs & Stratton 030208 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Briggs & Stratton 030208 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Briggs & Stratton 030208 you will learn all the available features of the product, as well as information on its operation. The information that you get Briggs & Stratton 030208 will certainly help you make a decision on the purchase.
If you already are a holder of Briggs & Stratton 030208, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Briggs & Stratton 030208.
However, one of the most important roles played by the user manual is to help in solving problems with Briggs & Stratton 030208. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Briggs & Stratton 030208 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
