Instruction/ maintenance manual of the product CASTILEI-CE-MBK Quadra-Fire
Go to page of 36
R www .quadrare.com October 27, 201 1 CASTILE & SANT A FE PELLET INSERT Owner ’ s Manual Installation and Operation CASTILEI-CE-MBK SANT AFEI-CE-MBK Models: DO NOT DISCARD THIS MANUAL NOTICE • Important operating and maintenance instruc - tionsincluded.
Page2 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradition.
R October 27, 201 1 Page3 Castile & Santa Fe CE Insert 7069-101B T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury .
Page4 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B.
R October 27, 201 1 Page5 Castile & Santa Fe CE Insert 7069-101B.
Page6 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Appliance Certication B. Glass Specications D. Specications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass.
R October 27, 201 1 Page7 Castile & Santa Fe CE Insert 7069-101B HOT SURF ACES! Glassandothersurfacesarehotduringoperation ANDcooldown.
Page8 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Fire Safety T o provide reasonable re safety , the following should be givenseriousconsideration: • Install at least one smoke detector and CO monitor on each oorofyourhome.
R October 27, 201 1 Page9 Castile & Santa Fe CE Insert 7069-101B D. General Operating Information 1. Thermostat Calls For Heat The appliance is like most modern furnaces; when the thermostat callsfor heat,your appliancewill automaticallylight anddeliver heat.
Page10 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Fire Characteristics A properly adjusted re with the heat output control button seton“HIGH”hasashort activeamepatternthatextends outoftherepotapproximately102mm.
R October 27, 201 1 Page1 1 Castile & Santa Fe CE Insert 7069-101B J. Ignition Cycles 1. At the beginningof eachignition cycle, itis normalto see some smoke in the rebox. The smoke will stop once therestarts.
Page12 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 3 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Depending on the type of fuel you are burning will dictate how oftenyouhavetocleanyourrepot.
R October 27, 201 1 Page13 Castile & Santa Fe CE Insert 7069-101B 5. Disposal of Ashes • Frequency: Asneeded • By: Homeowner Ashes should be placed in a metal container with a tight-tting lid.
Page14 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B The amount of ash buildup in the repot will be a good guide to determine how often you should clean the heat exchangers.
R October 27, 201 1 Page15 Castile & Santa Fe CE Insert 7069-101B 12. Cleaning Combustion Blower - Requires No Lubrication • Frequency: Y earlyorasneeded • By: QualiedServiceT echnician • T ask: Contact your local dealer 13.
Page16 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B D. High Ash Fuel Content Maintenance • Frequency: Asneeded • By: Homeowner Correct Flame Size, Y ellow/White in Color Correct Figure 16.
R October 27, 201 1 Page17 Castile & Santa Fe CE Insert 7069-101B NOTICE: Odors and vapors are released during initial operation due to the curing of high tem - peraturepaint.Openwindowsforaircirculation.
Page18 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 5 Getting Started Installer ’ s Guide A . Design, Installation & Location Considerations W ARNING! Risk of Fire Damaged parts could impair safe operation.
R October 27, 201 1 Page19 Castile & Santa Fe CE Insert 7069-101B B. Thermostat Location The thermostat’s location will have some effect on the appliance’soperation.
Page20 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 6 Dimensions and Clearances A. A ppliance Dimensions Figure 20.3- Front View Figure 20.
R October 27, 201 1 Page21 Castile & Santa Fe CE Insert 7069-101B Figure 20.4 - T op View A B C D C. Minimum Opening for Masonry and Factory-Built Fireplaces Inches Millimeters A Insertsidetocombustiblesidewall 16 406 B Inserttoptomantel 12 305 C Inserttoptomaximum.
Page22 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Do not terminate vent inanyenclosedorsemi-enclosed areasuchasacarport,garage,attic,cr.
R October 27, 201 1 Page23 Castile & Santa Fe CE Insert 7069-101B V ent Congurations T oreduce probability ofreverse drafting duringshut-down conditions Hearth.
Page24 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B E. Chimney and Exhaust Connection 1. Chimney & Connector :Use76mmto102mmdiameter type "L" or "PL" venting system. It can be vented vertically orhorizontally .
R October 27, 201 1 Page25 Castile & Santa Fe CE Insert 7069-101B F. P ellet V enting Charts FireRisk. • Only LISTED venting components may be used. • NOOTHER ventcomponentsmaybe used. Substituteordamagedventcomponentsmay impairsafeoperation.
Page26 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 8 V enting Systems Figure 28.1 CAUTION Neverdrawoutsidecombustionairfrom: • W all,oororceili.
R October 27, 201 1 Page27 Castile & Santa Fe CE Insert 7069-101B B. Full Reline With V ertical Outside Air Figure 29.1 Outside Air T ermination at Chimney T op 12” (305mm) min. below 12” (305mm) min. above NOTE; Use metal plate around exhaust vent pipe and seal all edges with non-flammable insulation such as mineral wool or ceramic.
Page28 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 9 Appliance Set-Up A. Leveling System B. Outside Air Kit Instructions Parts Included in Kit: 1pieceof51mmx.
R October 27, 201 1 Page29 Castile & Santa Fe CE Insert 7069-101B C. Door Handle Removal 1. Opentheouterdoor . 2. Unlatchandopenthereboxdoor . 3. Continue to turn handle until it is free from the rebox door .
Page30 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Figure 32.2 1 2 3 4 5 6 7 8 F . Hearth Support For Standard Surround Only Figure 33.
R October 27, 201 1 Page31 Castile & Santa Fe CE Insert 7069-101B Base Plate Only Installation Parts Needed :(1)castring(2)basezeroclearancepanel extensions.Discardbalanceofparts. T ools Needed: Phillipsheadscrewdriver 1.
Page32 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Surround and Cast T rim Set (CASTILE INSERT) I ncluded in Surround Kit: (2)sidesurrounds,leftand right;(1)surroundtop;(1)fastenerpackage.
R October 27, 201 1 Page33 Castile & Santa Fe CE Insert 7069-101B I. Panel and T rim Set (SANT A FE INSERT) 1. Laypanel topand legs facedown onprotective cov - eringtopreventscratching. 1. Attachthe panellegs tothe toppanel usinga Phillips head screwdriver .
Page34 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 1. Opendoortoexposetherebox. 2. Install the left log rst and then the right log. Figure 37.1 3. Lean the logs against the cast iron brick in the back of therebox.
R October 27, 201 1 Page35 Castile & Santa Fe CE Insert 7069-101B 1 . A 12 volt ACthermostat is required to operate this pellet appliance.
Page36 R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI CORPORA TION www .quadrare.com CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer visit our website at www .
An important point after buying a device Quadra-Fire CASTILEI-CE-MBK (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Quadra-Fire CASTILEI-CE-MBK yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Quadra-Fire CASTILEI-CE-MBK - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Quadra-Fire CASTILEI-CE-MBK you will learn all the available features of the product, as well as information on its operation. The information that you get Quadra-Fire CASTILEI-CE-MBK will certainly help you make a decision on the purchase.
If you already are a holder of Quadra-Fire CASTILEI-CE-MBK, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Quadra-Fire CASTILEI-CE-MBK.
However, one of the most important roles played by the user manual is to help in solving problems with Quadra-Fire CASTILEI-CE-MBK. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Quadra-Fire CASTILEI-CE-MBK along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
