Instruction/ maintenance manual of the product HE32EF Majestic Appliances
Go to page of 21
- 1 - INSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FOR HOMEOWNER 10003395 07/01 Rev.0 Electric Fireplace Model HE32EF WARNING! IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, AN ELECTRICAL SHOCK OR FIRE MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
- 2 - T ABLE OF CONTENTS Please read the Installation & Operating Instructions before using this appliance. Thank you and congratulations on your purchase of a Vermont Castings Majestic Products Company fireplace. IMPORTANT: Read all instructions and warnings carefully before starting installation.
- 3 - LOCATING YOUR VERMONT CASTINGS MAJESTIC PRODUCTS COMPANY ELECTRIC FIREPLACE INST ALLA TION INSTRUCTIONS 15. To prevent a possible fire, do not block air intakes or exhaust in any manner. Do not use on soft surfaces, like a bed, where openings may become blocked.
- 4 - M I N I M U M O P E N I N G Fig. 1 1= SS or SSD Trim 2= SL or SLD Trim 3= SXL Trim 4= BSL Trim 5= BXL Trim HE32EF T R I M A1 26 5/8" 676 mm B1 38 3/8" 975 mm A2 29" 737 mm B2 41 1.
- 5 - CLEARANCE TO COMBUSTIBLES Non-combustible materials such as brick and tile can be extended over the face of the unit (Do not cover louvres or glass door) . If a Trim Kit is going to be installed, brick and tile will have to be installed flush with the side of this appliance.
- 6 - Fig. 4 Electrical outlet wiring must comply with local building codes and other applicable regulations to reduce the risk of fire, electrical shock and injury to persons. ELECTRICAL CONNECTION A 15 AMP, 120 Volt, 60 Hz circuit with a properly grounded outlet is required.
- 7 - LOUVRE REMOVAL SER VICE INSTRUCTIONS To remove top louvre pull louvre up and then lift out. See Figure 5. Disconnect power before attempting any maintenance or cleaning to reduce the risk of fire, electrical shock or personal injury. GLASS INFORMATION 1.
- 8 - MAINTENANCE OF MOT ORS The motors used on the fan and the drum assembly are prelubricated for extended bearing life and require no further lubrication. However, periodic cleaning/vacuuming of the fan/heater is recommended. Make sure that the power is turned off before proceeding.
- 9 - OPERA TING INSTRUCTIONS 1. MAIN ON/OFF SWITCH The On/Off switch supplies power to all of the functions of the fireplace. This is an illuminated switch which normally will light up when in the " On/Off " position. The control compartment is located behind the lower louvre panel.
- 10 - REPLACEMENT P ARTS - ELECTRIC FIREPLACE #2 COMPLETE LOG SET 2 3 4 / 5 7 6 8 9 17 15 18 19 21 22 20 14 13 305mm [12"] 216mm [8 1/2"] (DISTANCE BETWEEN TWO SOCKETS} 216mm [8 1/2"] .
- 11 - REPLACEMENT P ARTS LIST - ELECTRIC FIREPLACE D ESCRIPTION HE32EF 1. Log Set Complete 10003628 1a. Log Top Left N/A 1b. Log Top Right N/A 1c. Log Bottom N/A 2. Fan/Heater Assembly w/Bracket 10001815 3. Motor 12VDC (Flame generator) 10001978 4. Switch Rocker 53606 5.
- 12 - INSTALLATION WARNING: UNPLUG OR TURN THE POWER TO THE APPLIANCE OFF PRIOR TO BEGIN- NING THE INSTALLATION. IT IS NOT ACCEPTABLE TO USE THE “ON/OFF” SWITCH TO MEET THIS REQUIREMENT. 1. Turn the power to the appliance off, or unplug it from the power supply.
- 13 - FRAME ASSEMBLY 1. Lay Trim Top Facing and Trim Side Facings, face down on to an even surface such as a table or floor. Be sure not to scratch the painted surfaces.
- 14 - 1. Fit Decorative Frame to the fireplace and fasten (Fig. 12) Plastic on the trim must be removed before mounting onto the fireplace. Glass must be tightly pressed against the front of the frame in order to prevent screws from damaging glass edges.
- 15 - KEY DESCRIPTION RHESS (2) RHESL (3) RHESSD (3) RHESLD (3) RHESXL (4) 1 Trim Frame Top, Flat Black 57929 57932 57929 57932 57935 2 Trim Frame Left, Flat Black 57927 57930 57927 57930 57933 3 Tri.
- 16 - TRIM ASSEMBLY 1. Install trim channels (left and right sides). Use two screws to assemble each piece. 2. Slide on the trim top channel and fasten it from the back side. 3. Install the trim top deflector and use two screws to fasten it. (Fig. 13) 4.
- 17 - 3) RHEF A and RHEFP TRIMS Glass Frame Louvre Note: Position brass trim top as shown (small end up) to prevent heat discolouration Fig. 14 Fig. 15 1. Remove the front glass (see "Glass Frame Re- moval" section). 2. Install support window trim channel, top and bottom brass trim by using the shortest black screw.
- 18 - 4) HEBTKP , HESBTKP , HECBTK, HECBTKMB & HEBT A TRIMS HECBTK - Cast bay window and grills in classic black trim kit HECBKMB - Cast bay window and grills in midnight black porcelain enamel t.
- 19 - HEBTKP Trim Assembly 1) Install the hanging brackets, as per Fig. 20 2) Install bracket on each side of the cabinet as per Fig. 24. 3) Install the two ceramic pieces inside the bay window, as per Fig. 19. 4) Install the bay window by hanging it onto the lower tabs of the hanging brackets, as per Fig.
- 20 - KEY DESCRIPTION HECBTK HECBTKMB HESBTKP HEBTKP HEBTA 1 Trim Window Top/Bottom (1) - - 55188-PB 55188-PB 55188-AB 2 Plate Decorative Bottom - - - 52828-PB 52828-AB 3 Top Louvre (Grill) Assembly .
- 21 - 5) CAST TRIM OPTIONS CAST SURROUND AND FLAT FACE HECBL Cast Surround Black HECBLUE Cast Surround Blue HECCG Cast Surround Charcoal Grey HECGR Cast Surround Green CSSP Polished Brass Small Trim .
An important point after buying a device Majestic Appliances HE32EF (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Majestic Appliances HE32EF yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Majestic Appliances HE32EF - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Majestic Appliances HE32EF you will learn all the available features of the product, as well as information on its operation. The information that you get Majestic Appliances HE32EF will certainly help you make a decision on the purchase.
If you already are a holder of Majestic Appliances HE32EF, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Majestic Appliances HE32EF.
However, one of the most important roles played by the user manual is to help in solving problems with Majestic Appliances HE32EF. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Majestic Appliances HE32EF along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
