Instruction/ maintenance manual of the product P61A-2 Harman Stove Company
Go to page of 28
R1 P61A-2 ! Pellet ! S tove ! Owners ! Manual SA VE ! THESE ! INSTRUCTIONS. Inst allation ! & ! Operating ! Manual R5 ìCe ! manuel ! est ! disponible ! en ! FranÁais ! sur ! demandeî SAFETY ! NOTICE PLEASE ! READ ! THIS ! ENTIRE ! MANUAL ! BEFORE ! YOU ! INST ALL ! AND ! USE ! YOUR ! NEW ! ROOM ! HEA TER.
2 P61A !! Pellet ! Stove Fig. ! 1.
3 P61A ! Pellet ! Stove T esting ! Lable 2 Assembly ! & ! Installation 4 Installation 5 V enting !!!!!!!!!! 6 Automatic ! Operation 1 2 ESP ! Control 1 6 Maintenance 1 7 T rouble ! Shooting 2 2 Fe.
4 P61A !! Pellet ! Stove !!!!! ! ! Assembly ! and ! Installation Unpacking The ! P61 ! is ! bolted ! to ! the ! skid ! to ! prevent ! movement during ! shipping. To ! free ! the ! stove ! from ! the ! skid ! you ! must ! remove the ! hold-down ! bolts ! in ! the ! rear ! of ! the ! pedestal ! base.
5 P61A ! Pellet ! Stove Installing Place ! the ! stove ! on ! a ! noncombustible ! floor ! protector that ! extends ! 6 ! inches ! to ! the ! front, ! 6 ! inches ! to ! the ! sides and ! 1 ! inch ! to ! the ! rear ! of ! the ! stove. ! The ! minimum ! floor protector ! material ! is ! 24 ! gauge ! sheet ! metal.
6 P61A !! Pellet ! Stove V enting Requirement s ! for ! T erminating ! the ! V enting W ARNING: ! V enting ! terminals ! must ! not ! be ! re- cessed ! into ! a ! wall ! or ! siding. NOTE: ! Only ! PL ! vent ! pipe ! wall ! pass-throughs and ! fire ! stops ! should ! be ! used ! when ! venting ! through combustible ! materials.
7 P61A ! Pellet ! Stove V enting A ! combustion ! blower ! is ! used ! to ! extract ! the ! com- bustion ! gases ! from ! the ! firebox. ! This ! causes ! a ! negative pressure ! in ! the ! firebox ! and ! a ! positive ! pressure ! in ! the venting ! system ! as ! shown ! in ! fig.
8 P61A !! Pellet ! Stove #2 ! Preferred ! method This ! method ! also ! provides ! excellent ! venting ! for normal ! operation ! but ! requires ! the ! stove ! to ! be ! installed farther ! from ! the ! wall.
9 P61A ! Pellet ! Stove #4 ! Installing ! into ! an ! existing chimney ! ( ! US ! only ! ) This ! method ! provides ! excellent ! venting ! for ! normal operation. !! This ! method ! also ! provides ! natural ! draft ! in the ! event ! of ! a ! power ! failure.
10 P61A !! Pellet ! Stove #6 ! Installing ! into ! an ! existing fireplace ! chimney ! ( ! US ! and Canada ! ) This ! method ! provides ! excellent ! venting ! for ! normal operation. !! This ! method ! also ! provides ! natural ! draft ! in the ! event ! of ! a ! power ! failure.
11 P61A ! Pellet ! Stove #8 ! Installing ! through ! the ! ceiling ! vent Through ! the ! ceiling ! vent, ! follow ! PLvent manufacturers ! recommendations ! when ! using ! wall ! and ceiling ! pass ! through. Fig. ! 14 No ! insulation ! or other ! combustible materials ! are allowed ! within ! 3" of ! the ! PL ! vent ! pipe.
12 P61A !! Pellet ! Stove The ! P61A ! pellet ! stove ! is ! more ! than ! just ! automatic ! ignition, ! it ! is ! also ! automatic ! temperature ! control. The ! automatic ! system ! will ! allow ! the ! fire ! size ! to ! be ! adjusted ! to ! match ! the ! heating ! needs ! and ! even ! put the ! fire ! out ! if ! necessary .
13 P61A ! Pellet ! Stove Starting ! First ! Fire Ignitor ! Switch ! to"AUTO"(up ! position) Make ! sure ! the ! unit ! is ! plugged ! into ! a ! 120 V AC, ! 60 ! HZ ! electrical ! source. ! The ! power ! light should ! be ! the ! only ! light ! lit.
14 P61A !! Pellet ! Stove The ! P61A ! Pellet ! Stove ! is ! capable ! of ! manual ! operation. ! This ! also ! allows ! the ! operator ! to manually ! control ! operation ! during ! an ! emergency ! (i.e. ! ignitor ! failure, ! when ! using ! a ! 502H ! battery backup, ! or ! when ! using ! certain ! generators.
15 P61A ! Pellet ! Stove P61A-2 !! MANUAL !! ST ART !! UP Starting ! First ! Fire Ignitor ! Switch ! to"MANUAL" (down ! position) Make ! sure ! the ! unit ! is ! plugged ! into ! a 120 ! V AC, ! 60 ! HZ ! electrical ! source. ! The power ! light ! should ! be ! the ! only ! light ! lit.
16 P61A !! Pellet ! Stove O O P61A-2 !! AUTOMA TIC ! IGNITION !! ESP !! CONTROL Feed ! adjuster Sets ! the ! maximum ! feed rate T est Runs ! all ! motors ! at ! full speed ! for ! one ! minute to ! check ! operation.
17 P61A ! Pellet ! Stove These ! units ! are ! pre-tested ! at ! the ! factory ! with ! exactly 120 ! V olts ! A.C., ! 60 ! Hz. ! They ! are ! checked ! and ! adjusted !! for firebox ! tightness, ! gasket ! leakage, ! motor ! operation ! and ! ignitor operation.
18 P61A !! Pellet ! Stove The ! room ! sensor ! is ! a ! small ! temperature ! sen- sor ! on ! the ! end ! of ! a ! 60" ! gray ! wire. ! This ! sensor ! is installed ! much ! like ! a ! standard ! wall ! thermostat.
19 P61A ! Pellet ! Stove Removing ! Ashes: When ! approximatly ! 1 ! ton ! of ! pellets ! has ! been burned ! it ! will ! be ! necessary ! to ! empty ! the ! ash ! pan. Ashes ! should ! be ! placed ! in ! a ! metal ! container with ! a ! tight ! fitting ! lid.
20 P61A !! Pellet ! Stove Latch ! "closed ! "with blower ! cover ! in ! place. Burn ! pot ! clean-out ! is closed. Latch ! "open ! "with ! blower cover ! partly ! removed. Burn ! pot ! clean-out ! is open. Exposed !! blower ! wheel and ! flue ! opening, NOTE: ! ESP ! probe ! is visible.
21 P61A ! Pellet ! Stove Burn ! Pot ! Cleaning ! and ! Maintenance 1. !! Scrape ! the ! top ! holed ! surface ! and ! sides ! of ! the ! burn pot.(Fig !! 34) ! It ! is ! not ! necessary ! to ! completely ! remove all ! material ! from ! the ! burn ! pot.
22 P61A !! Pellet ! Stove !! FEEDER ! DOES ! NOT ! FEED 1. ! No ! pellets ! in ! hopper . 2. ! Firebox ! draft ! may ! be ! too ! low ! for ! low ! draft ! pressure switch ! in ! feeder ! circuit ! to ! operate. ! Check ! for ! closed doors , ! loose ! or ! missing ! gasket ! on ! doors ! or ! hopper ! lid, faulty ! pressure ! switch.
23 P61A ! Pellet ! Stove W eight 24 9 ! lbs. Blower 13 5 ! cfm Feed ! Rate .75 ! to ! 7.5 ! lbs. ! per ! hr . Hopper ! Capacity 7 2 ! lbs. Fuel W o od ! Pellets Flue ! Size 3 ! inch Outside ! Air ! Size 2 ! 3/8 ! I.D. ! inch Fuse ! Rating 5 ! amp 32.375" 9" 23.
24 P61A !! Pellet ! Stove Door ! Options Optional ! T rim To ! install, ! lay ! the ! frame ! face ! down ! on ! a ! sof t surface. !! Fasten ! door ! frame ! by ! inserting ! the ! 4 threaded ! post s ! on ! the ! frame ! through ! the ! door .
25 P61A ! Pellet ! Stove OPTIONS Side ! Heat ! Shields Side ! heat ! shields ! are ! available ! to ! reduce the ! clearance ! to ! combustible ! materials. Hopper ! Extension The ! hopper ! extension ! allows ! you ! to put ! more ! pellet ! fuel ! in ! the ! hopper ! and ! extends burn ! time ! on ! one ! load ! of ! pellets.
26 P61A !! Pellet ! Stove P61A-2 ! Wiring ! Diagram.
27 P61A ! Pellet ! Stove Description Part ! Number Hopper ! Gasket(6 ! ft.) 0-88-00248 Ash ! Pan ! Assembly 1-10-05800 Burn ! Pot ! Weldment 1-10-05802 Right ! Rear ! Shield 2-00-06468-1 Left ! Rear !.
28 P61A !! Pellet ! Stove Harman ! S tove ! Company ! warrants ! its ! products ! to ! be ! free ! from ! defects ! in ! material ! or ! workmanship, ! in ! normal ! use and ! service, ! for ! a ! per.
An important point after buying a device Harman Stove Company P61A-2 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Harman Stove Company P61A-2 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Harman Stove Company P61A-2 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Harman Stove Company P61A-2 you will learn all the available features of the product, as well as information on its operation. The information that you get Harman Stove Company P61A-2 will certainly help you make a decision on the purchase.
If you already are a holder of Harman Stove Company P61A-2, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Harman Stove Company P61A-2.
However, one of the most important roles played by the user manual is to help in solving problems with Harman Stove Company P61A-2. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Harman Stove Company P61A-2 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
