Instruction/ maintenance manual of the product BVC-50Y FMI
Go to page of 44
FIREBO X MODELS BV C-36Y , BV C-42Y AND BVC-50Y NA TURAL GAS MODULE MODELS BBM-36N-TKA, BBM-42N-TKA AND BBM-50N-TKA PROP ANE/LP MODULE MODELS BBM-36P-TKA, BBM-42P-TKA AND BBM-50P-TKA SPLIT BRICK P ANE.
www .fmiproducts.com 122280-01E 2 - .
www .fmiproducts.com 122280-01E 3 SAFETY W ARNING: This product con - .
www .fmiproducts.com 122280-01E 4 1 1. Keep the area arou nd y our repl ace clear of combustible materials, gasoline and other ammable vapor and liquids. Do not run re place where t hese a re use d or st ored . Do not pl ace it ems su ch as clo thin g or decorations on or around replace.
www .fmiproducts.com 122280-01E 5 INTRODUCTION Models BBM-36(N,P)-TKA, BBM-42(N,P)- TKA and BBM-50(N,P)-TKA are vented gas appliances that use an electronic control valve and electronic ignition system.
www .fmiproducts.com 122280-01E 6 SPECIFICA TIONS GAS RA TING - NA TURAL BBM-36N-TKA BBM-42N-TKA BBM-50N-TKA Max. Input Rating: 52,000 Btu/Hr 56,000 Btu/Hr 60,000 Btu/Hr Manifold Pressure: 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) Min.
www .fmiproducts.com 122280-01E 7 29" 14 1 / 2 " 22 1 / 2 " 26 5 / 8 " 4 1 / 2 " 15 5 / 8 " 4 1 / 2 " 1" 58" 7 1 / 4 " 1 1 " 15 1 / 4 " 3 1 .
www .fmiproducts.com 122280-01E 8 PRODUCT DIMENSIONS Continued 22 3 / 4 " 30 1 / 2 " 29" 4 3 / 8 " 15 3 / 4 " 5/8" 17 5 / 8 " 67" 61" 49" 7" 1&qu.
www .fmiproducts.com 122280-01E 9 PRODUCT DIMENSIONS Continued 38 1 / 2 " 28 1 / 2 " 4 3 / 8 " 17 5 / 8 " 19 1 / 4 " 24" 49" 30" 1 1 " 61" 67" 58.
www .fmiproducts.com 122280-01E 10 Figure 6 - Rough Opening Dimensions for Installing in a Wall 59 1 / 4 " (50") 58 1 / 8 " 30 1 / 8 " (42", 50") 28 1 / 4 " (36".
www .fmiproducts.com 122280-01E 11 PREINST ALLA TION PREP ARA TION Continued 6. Using screws or nails, secure replace to framing through anges located on sides of replace.
www .fmiproducts.com 122280-01E 12 VENTING INST ALLA TION A FMI PRODUCTS, LLC or an 8" B-type vent - ing sys tem mus t be con nect ed to appli ance for venting to the outside of building. T ransition pipe model BTC-8 is required for use with B-type venting.
www .fmiproducts.com 122280-01E 13 Figure 12 - T ypical Residential Installations VENTING INST ALLA TION Continued VENTING INST ALLA TION USING FMI .
www .fmiproducts.com 122280-01E 14 VENTING INST ALLA TION Continued ASSEMBL Y AND INST ALLA TION OF DOUBLE W ALL CHIMNEY SYSTEM Each double wall chimney section consists of a galvanized outer pipe, a stainless steel in - ner ue pipe and a wire spacer .
www .fmiproducts.com 122280-01E 15 VENTING INST ALLA TION Continued Pitch Slope Opening Used Flashing Model No. Flat 0° 15" V6F-8DM 0-6/12 26.
www .fmiproducts.com 122280-01E 16 Fireplace system must be terminated with listed round top or chase terminations. In any case, refer to insta llation instructions supplied with termination.
www .fmiproducts.com 122280-01E 17 Check this area along entire top edge of replace opening. Smoke or ame should be drawn into appliance opening. Figure 21 - Checking for Spillage VENTING INST ALLA TION Continued FINISHING FIREPLACE Combustible materials, such as wallboard, gypsum board, sheet rock, drywall, plywood, etc.
www .fmiproducts.com 122280-01E 18 IN PI L O T IN OUT VENT TH TP TH TP INST ALLA TION Continued Figure 25 - Connecting Incoming Gas Line to Flex Gas Line Gas Shutoff V alve Flexible Gas Line Do NOT Ki.
www .fmiproducts.com 122280-01E 19 REMOVING AND INST ALLING SMOKE SHELF 1.
www .fmiproducts.com 122280-01E 20 INST ALLA TION Continued RED IVOR Y QTY FULL (1 12140-01) FULL (1 12140-05) 4* ASH BRICK (120848-01) ASH BRICK (120848-02) 1 F012R F012W 2 F036R F036W 2 F079R F079W 2 F104R F104W 2 F128R F128W 2 F140R F140W 2 S109R S109W 2 * Includes 2 extra bricks.
www .fmiproducts.com 122280-01E 21 INST ALLA TION Continued 36" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 16 S043R S043W 1 S044R S044W 1 S04.
www .fmiproducts.com 122280-01E 22 INST ALLA TION Continued 42" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 17 S045R S045W 1 S046R S046W 5 S050.
www .fmiproducts.com 122280-01E 23 INST ALLA TION Continued 50" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 16 S043R S043W 1 S045R S045W 1 S046.
www .fmiproducts.com 122280-01E 24 INST ALLA TION Continued 36" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 12 S001R S001W 1 S002R S002W 1 S.
www .fmiproducts.com 122280-01E 25 INST ALLA TION Continued 42" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 19 S001R S001W 2 S002R S002W 9 .
www .fmiproducts.com 122280-01E 26 INST ALLA TION Continued 50" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 18 S001R S001W 2 S002R S002W 1 .
www .fmiproducts.com 122280-01E 27 Figure 29 - Grouting Brick GROUTING INSTRUCTIONS Material provided: 1 or 2 - 10 lb. bags of cement (depending on model) 1 or 2 - 10 lb. bags of sand (depending on model) Material required: 1 - Piping bag 1 - Joints striker 1 - Heavy duty mixing bucket 1 - T rowel 1.
www .fmiproducts.com 122280-01E 28 INST ALLING MODULE Before installing module, make sure all bat - teries have been installed (see Installing Bat- teries in Wireless Hand-Held Remote Control and Receiver . See Removing and Installing Smoke Shelf on page 18 to reinstall limit switch and smoke shelf.
www .fmiproducts.com 122280-01E 29 INST ALLA TION Continued Figure 34 - Installing Fireplace Screen Ring Screen Push On Nut Screen Rod Bracket Smoke Shelf Screen Rod Fireplace Front CAUTION: Gloves sh.
www .fmiproducts.com 122280-01E 30 INST ALLA TION Continued Figure 37 - Installing Bi-Fold Doors Spring Clip Insert Pin into Spring Clip Pivot Hole Insert Bottom Pivot Pin into Hole Fold Door and Slid.
www .fmiproducts.com 122280-01E 31 OPERA TION FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not fol- .
www .fmiproducts.com 122280-01E 32 OPERA TION Continued COMBUSTION AIR KIT MODEL AK4 (OPTIONAL) The outside air kit lever is located at the left and right hand sides of replace (see Figure 40). The vent can be installed through any outside wall a minimum of three feet below replace termination cap.
www .fmiproducts.com 122280-01E 33 CLEANING AND MAINTENANCE W ARNING: Installation and - .
www .fmiproducts.com 122280-01E 34 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . Contact authorized dealers of this product. If they can’t supply original replacement part(s), call FMI PRODUCTS, LLC at 1-866-328-4537.
www .fmiproducts.com 122280-01E 35 CONTROL MODULE BA TTERY RELA Y BA TTER Y PACK REMOTE RECIEVER V A L V E THTP TP TH Red Bk Bn Bk "D" SIZE "D" SIZE Bn 4 "AA" SIZE BA TTE.
www .fmiproducts.com 122280-01E 36 TROUBLESHOO TING Note: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1.
www .fmiproducts.com 122280-01E 37 TROUBLESHOO TING Continued .
www .fmiproducts.com 122280-01E 38 P ARTS 1 22 27 21 6 7 10 9 1 1 12 13 15/16 14 8 26 25 2 3.
www .fmiproducts.com 122280-01E 39 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual.
www .fmiproducts.com 122280-01E 40 P ARTS .
www .fmiproducts.com 122280-01E 41 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual.
www .fmiproducts.com 122280-01E 42 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual.
www .fmiproducts.com 122280-01E 43 _____________________________________________________ ______________________________________________________ ______________________________________________________ _.
122280-01 Rev . E 04/10 WARRANTY KEEP THIS WARRANTY FMI PRODUCTS, LL C LIMITED WARRANTIES Standard Warranty: F MI P RO D UC TS , LL C wa r ra nt s th is n ew p ro .
An important point after buying a device FMI BVC-50Y (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought FMI BVC-50Y yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data FMI BVC-50Y - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, FMI BVC-50Y you will learn all the available features of the product, as well as information on its operation. The information that you get FMI BVC-50Y will certainly help you make a decision on the purchase.
If you already are a holder of FMI BVC-50Y, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime FMI BVC-50Y.
However, one of the most important roles played by the user manual is to help in solving problems with FMI BVC-50Y. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device FMI BVC-50Y along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
