Instruction/ maintenance manual of the product S39PT Desa
Go to page of 26
Save this manual for future reference. OWNER’S OPERA TION AND INST ALLA TION MANUAL VENT -FREE PROP ANE/LP GAS FREEST ANDING PEDEST AL STOVE SYSTEM S39PT 20,000 to 39,000 Btu/Hr Thermostaticall y- C.
2 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases. 2. Do not place propane/LP supply tank(s) inside any structure.
3 107435 OWNER’S MANUAL For more information, visit www.desatech.com O F F P I L O T O N H I L O SAFETY INFORMA TION Continued 16. Do not operate heater if any log is bro- ken. Do not operate heater if a log is chipped (dime-sized or larger). 17. T o prevent performance problems, do not use propane/LP fuel tank of less than 100 lbs.
4 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com Today’s homes are built more energy effi- cient than ever. New materials, increased insulation, and new construction methods help reduce heat loss in homes.
5 107435 OWNER’S MANUAL For more information, visit www.desatech.com AIR FOR COMBUSTION AND VENTILA TION Continued Continued DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this worksheet to determine if you have a confined or unconfined space.
6 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com AIR FOR COMBUSTION AND VENTILA TION Continued Figure 3 - Ventilation Air from Outdoors Figure 2 - Ventilation Air from Inside Building VENTILATION AIR Ventilation Air From Inside Building This fresh air would come from an adjoining unconfined space.
7 107435 OWNER’S MANUAL For more information, visit www.desatech.com WARNING: Never install the heater • in a bedroom or bathroom • in a recreational vehicle • where curtains, furniture, cloth.
8 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com Tee Joint Pipe Nipple Cap 3" Minimum Sediment Trap Gas Regulator of Heater From External Regulator (11" W.
9 107435 OWNER’S MANUAL For more information, visit www.desatech.com O N POSI T O PO S INST ALLA TION Continued WARNING: Never use an open flame to check for a leak. Apply a noncorrosive leak detection fluid to all joints. Bubbles forming show a leak.
10 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com O F F P I L O T O N H I L O Black Powercord Wire WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with this heater may result in property damage or personal injury.
11 107435 OWNER’S MANUAL For more information, visit www.desatech.com Figure 17 - Installing Blower Control Housing Power Cord Speed Control Housing Control Knob Figure 16 - Routing Power Cord Blowe.
12 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com Red Variable Fan Switch Fan Switch (N.O.) Green White On 110/115 V.A.C. Blower Motor Black Off 1 2 Black Blue INST ALLA TION Continued Power Cord Speed Control Housing Control Knob Figure 21 - Connecting Switch, Blower, and Speed Control Wires 120 V ac.
13 107435 OWNER’S MANUAL For more information, visit www.desatech.com 1. STOP! Read the safety inf ormation, column 2. 2. Make sure equipment shutoff v alve is fully open. 3. T ur n control knob clockwise Clockwise to the OFF position. 4. W ait fi ve (5) minutes to clear out any gas.
14 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com Figure 23 - Pilot 7. Keep contr ol knob pr essed in for 30 seconds after lighting pilot. After 30 seconds, release contr ol knob . • If control knob does not pop out when released, contact a qualif ied service person or gas supplier f or repairs.
15 107435 OWNER’S MANUAL For more information, visit www.desatech.com CLEANING AND MAINTENANCE WARNING: Turn off heater and let cool before cleaning. CAUTION: You must keep control areas, burner, and circu- lating air passageways of heater clean. Inspect these areas of heater before each use.
16 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. CAUTION: Never use a wire, needle, or similar object to clean ODS/pilot.
17 107435 OWNER’S MANUAL For more information, visit www.desatech.com TROUBLESHOOTING Continued OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition burner Burner backfirin.
18 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
19 107435 OWNER’S MANUAL For more information, visit www.desatech.com TECHNICAL SER VICE You may have further questions about in- stallation, operation, or troubleshooting. If so, contact DESA International’s Technical Service Department at 1-800-DESA LOG (1-800-337-2564).
20 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com ILLUSTRA TED PA R T S BREAKDOWN S39PT 6 5 8 4 10 3 2 1 12 13 11 10 9 7.
21 107435 OWNER’S MANUAL For more information, visit www.desatech.com P AR TS LIST S39PT This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 24 of this manual.
22 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com ILLUSTRA TED PA R T S BREAKDOWN S39PT 1 10 4 13 3 2 14 7 16 15 11 18 20 5 6 9 8 17 12 23 21 19 19 26 26 22.
23 107435 OWNER’S MANUAL For more information, visit www.desatech.com P AR TS LIST S39PT KEY NO. PART NO. DESCRIPTION QTY. 1 107085-01CK Top Panel, Stove 1 2 107077-01CK Pedestal Stove Assembly 1 3 .
24 107435 VENT -FREE PROP ANE/LP PEDEST AL STOVE For more information, visit www.desatech.com REPLACEMENT PA R T S Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealers of this product.
25 107435 OWNER’S MANUAL For more information, visit www.desatech.com NOTES _______________________________________________________________________________________________ __________________________.
2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 www.desatech.com INTERNA TIONAL 107435-01 Rev. B 06/01 LIMITED WARRANTY VENT-FREE PROPANE/LP GAS PEDESTAL STOVE DESA International war.
An important point after buying a device Desa S39PT (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa S39PT yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa S39PT - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa S39PT you will learn all the available features of the product, as well as information on its operation. The information that you get Desa S39PT will certainly help you make a decision on the purchase.
If you already are a holder of Desa S39PT, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa S39PT.
However, one of the most important roles played by the user manual is to help in solving problems with Desa S39PT. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa S39PT along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
