Instruction/ maintenance manual of the product MSBVBN Desa
Go to page of 32
B-VENT FREEST ANDING FIREPLACE HEA TER OWNER’S OPERA TION AND INST ALLA TION MANUAL ® MSBVBN, MSBVBP REMOTE READY Save this manual for future reference. FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch • Do not use any phone in your building.
2 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY SAFETY INFORMA TION 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases unless a certified kit is used.
3 106022 OWNER’S MANUAL PRODUCT IDENTIFICA TION Install and use fireplace with care. Follow all local codes. In the absence to local codes, use the current National Fuel Gas Code ANS Z223.1 , also known as NFPA 54* (USA) or the current CAN/CGA-B149[.
4 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY LOCATION AND SPACE REQUIREMENTS Determine the safest and most efficient loca- tion for your Sun Valley B-vent freestanding fireplace. Make sure that rafters and wall studs are not in the way of the venting system.
5 106022 OWNER’S MANUAL Pallet Wood Bolted to Bottom of Stove Body STOVE BODY ASSEMBLY 1. Lift of f corrugated box enclosing sto ve body crating. 2. Remove all screws fastening the wood frame enclosure. Spread wood frame open and lift away from plastic-bagged stove body .
6 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY FREEST ANDING FIREPLACE ASSEMBL Y Continued Figure 12 - Attaching Stove Door Adjusting Nut Bolt Stop Catch Bolt Door Claw Door Figure 13 - Catch Bolt and Door Claw Orientation 10.
7 106022 OWNER’S MANUAL INSTALLING FIREPLACE INTO STOVE BODY 1. Attach the two brackets to the back of the stove (see Figure 17). Use the screws and washers from step 4 of Stove Body Assemb ly on page 5. 2. Carefully lift firebox and place into stove body from the rear of stove.
8 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY double wall construction enclosing an insu- lating air space. This air space both helps keep flue gases warm and reduce heat trans- ferred to nearby combustibles.
9 106022 OWNER’S MANUAL Figure 21 - Typical B-Vent Installation WARNING: Installation should only be made by qualified per- sons who are familiar with the safety procedures required for the installation of the product, who are equipped with the proper tools and testing instruments, and who have achieved proper certification of licensing.
10 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY VENTING INST ALLA TION Continued CHECKING VENT CAPACITY Complete all gas piping, electrical, and vent connections. After adjusting the fireplace and lighting the main burners, allow a couple of minutes for warm-up.
11 106022 OWNER’S MANUAL VENTING INST ALLA TION Continued HIGH ALTITUDE INSTALLATION Your Sun Valley B-vent freestanding fire- place heater has been AGA tested and ap- proved for elevations from 0-2000 feet and CGA certified for elevations from 0-4500 feet.
12 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY CAUTION: Use only new, black iron or steel pipe. Inter- nally-tinned copper tubing may be used in certain areas. Check your local codes. Use pipe of 1/2" diameter or greater to allow proper gas volume to fireplace.
13 106022 OWNER’S MANUAL Cap Pipe Nipple Tee Joint Pressure Testing Gas Supply Piping System Test Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect fireplace and its individual manual shutoff v alve from gas supply piping system. Pressures in excess of 1/2 psig (3.
14 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY FIREPLACE INST ALLA TION Continued Test Pressures Equal To or Less Than 1/2 PSIG (3.
15 106022 OWNER’S MANUAL FIREPLACE INST ALLA TION Continued INSTALLING OPTIONAL WALL MOUNTED THERMOSTAT - GWMT1, GWMS2 WARNING: Installation must be done by a qualified installer familiar with low voltage wiring procedures. WARNING: Do not connect this thermostat to any electrical source! Electrical shock and/or fire hazard will occur.
16 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY REMOVING/REPLACING GLASS DOOR CAUTION: Do not operate this fireplace with a broken glass door panel or without the glass door panel securely in place. For re- placement part information see Replacement Parts , page 25.
17 106022 OWNER’S MANUAL Each log is marked with a number. These numbers will help you identify the log when installing. It is very important to install these logs exactly as instructed. Do not modify logs. Only use logs supplied with freestanding fireplace.
18 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY TO TURN OFF GAS TO APPLIANCE 1. Open lo wer louv er panel. 2 a . Set selector switch in the “OFF” position. 2b. If Using Optional Hand-Held Re- mote: Set selector switch in the OFF position to pr e vent dr aining ba tter y .
19 106022 OWNER’S MANUAL 1 . After lighting , let pilot f lame b ur n f or about one min ute . T ur n contr ol knob on the contr ol v alve to ON position. T ur n f lame adjustment knob an y- wher e betw een HI and LO . Slide the selector s witc h to the REMO TE posi- tion.
20 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT ASSEMBLY The pilot assembly is factory preset for the proper flame height. Alterations may have occurred during shipping and handling.
21 106022 OWNER’S MANUAL CLEANING AND MAINTENANCE WARNING: Turn off fireplace and let cool before cleaning. CAUTION: You must keep con- trol areas, burners, and circulat- ing air passageways of fireplace clean. Inspect these areas of fire- place before each use.
22 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater.
23 106022 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Heater pr.
24 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building.
25 106022 OWNER’S MANUAL SER VICE HINTS When Gas Pressure is Too Low • pilot will not stay lit • burners will have delayed ignition • fireplace will not produce specified heat • propane/LP g.
26 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY SPECIFICA TIONS MSBVBN MSBVBP 21,000-30,000 Btu/h 20,000-28,000 Btu/h Gas Type Natural Propane/LP Ignition Piezo Piezo Manifold Pressure 3.5" w.c. 10.0" w.c. Minimum Inlet Supply Pressure 4.
27 106022 OWNER’S MANUAL ACCESSORIES Purchase these fireplace accessories from your local dealer. If they can not supply these accessories, call Sun Valley Stove Company’s Sales Department at 1-800-221-1425 for in- formation. You can also write to the address listed on the back page of this manual.
28 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY ILLUSTRA TED PA R T S BREAKDOWN MSBVBN MSBVBP L O H I P I L O T OFF ON 24 17 18 19 21 23 -1 23-4 23-2 23-3 26 27 4 22 1 10 30 11 8 .
29 106022 OWNER’S MANUAL P ARTS LIST MSBVBN MSBVBP This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 25 of this manual. KEY NO. PART NUMBER DESCRIPTION QTY.
30 B -VENT FREEST ANDING FIREPLACE 106022 SUN V ALLEY STOVE COMP ANY ILLUSTRA TED PA R T S BREAKDOWN SUN VALLEY STOVE MC(*) SERIES (* Indicates Color Suffix Designation) 1R 1C 1L 5 8 10 8 7-4 6 5 5 7-.
31 106022 OWNER’S MANUAL P ARTS LIST SUN VALLEY STOVE MC(*) SERIES (* Indicates Color Suffix Designation) This list contains replaceable parts used in your stove. When ordering parts, follow the instructions listed under Replacement Parts on page 25 of this manual.
LIMITED WARRANTY B-VENT FREESTANDING FIREPLACE AND SUN VALLEY STOVE CHASSIS DESA International warrants this product to be free from defects in materials and components for four (4) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions.
An important point after buying a device Desa MSBVBN (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa MSBVBN yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa MSBVBN - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa MSBVBN you will learn all the available features of the product, as well as information on its operation. The information that you get Desa MSBVBN will certainly help you make a decision on the purchase.
If you already are a holder of Desa MSBVBN, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa MSBVBN.
However, one of the most important roles played by the user manual is to help in solving problems with Desa MSBVBN. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa MSBVBN along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
