Instruction/ maintenance manual of the product LTR20081044 Cal Flame
Go to page of 20
L TR20081044, Rev . A 4/21/08.
W ARNING If the information in this manual is not fol- lowed exactly , a re or explosion may re - sult causing property damage, personal injury or loss of life. Do not store or use gasoline or other am - mable vapors and liquids in the vicinity of this or any other appliance.
Cal Flame 2008 Owner ’s Manual Page 1 L TR20081044, Rev . A Safety Instructions Read all instructions before you operate your grill. Placement and Location C • al Flame™ grills are designed for outdoor use only .
Page 2 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Safety Instructions Never use the grill or side burner in windy conditions. • If used in a consistently windy area a windbreak will be required. Always adhere to the specied clear - ances listed in this manual.
Cal Flame 2008 Owner ’s Manual Page 3 L TR20081044, Rev . A Installation / Assembly Installation / Assembly Most cities and counties require permits for exterior con - struction and electrical circuits.
Page 4 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Installation / Assembly As a safety precaution, remember to always leak test your grill outdoors in a well-ventilated area. Never smoke or permit sources of ignition in the area while doing a leak test.
Cal Flame 2008 Owner ’s Manual Page 5 L TR20081044, Rev . A Installation / Assembly The grill unit must be used with the gas pressure regula - tor . The regulator will control and maintain a uniform gas pressure in the manifold. The burner orices have been sized for the gas pressure delivered by the regulator .
Page 6 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Installation / Assembly Remove the transformer and the metal screws from the plastic bag.
Cal Flame 2008 Owner ’s Manual Page 7 L TR20081044, Rev . A Installation / Assembly Installing the Rotisserie Attach the two brackets to the sides of the grill, one on each side, using two screws as shown below . Slide the rotis motor on one of the brackets as shown be - low .
Page 8 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Installation / Assembly Installing Side Burners Assemble a 9.5 mm pipe nipple to the 9.5 mm pipe tee using T eon tape or pipe sealant. Use only sealant that 1. is approved for use on LP gas.
Cal Flame 2008 Owner ’s Manual Page 9 L TR20081044, Rev . A Operating Y our Barbecue Light Switch Grill Grill Grill Grill Infrared Burner BBQ07874CPE - 4 Burner Grill Light Switch Grill Grill Grill .
Page 10 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Operating Y our Barbecue Each time you light the grill, check the following: Inspect the hose before using the grill. If there is • excessive abrasion or wear , or if the hose is cut, it must be replaced prior to using the grill.
Cal Flame 2008 Owner ’s Manual Page 1 1 L TR20081044, Rev . A Operating Y our Barbecue Basic Grill Operation Before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is pres - ent. Check the connection with a soap and water solu - tion after attaching the hose.
Page 12 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Operating Y our Barbecue Cooking with a Convection Grill A convection grill has an internal fan that circulates heated air evenly throughout the grilling area when the hood is closed.
Cal Flame 2008 Owner ’s Manual Page 13 L TR20081044, Rev . A Cleaning and Maintenance Cleaning and Maintenance Clean internal parts of the grill regularly as determined by the amount of use and foods cooked. The entire grill should be cleaned at least once a year .
Page 14 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Cleaning and Maintenance Light Bulb Replacement W ARNING: Never attempt to replace a light bulb when the grill is in use. Serious burns will result. W ARNING: Never touch halogen bulbs with your bare ngers.
Cal Flame 2008 Owner ’s Manual Page 15 L TR20081044, Rev . A Appendix Appendix T roubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure described in this manual.
Page 16 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Appendix Problem: Plugged orice Solution: Unplug the orice as follows: Remove cooking grills, ame tamer and grease tray .
Cal Flame 2008 Owner ’s Manual Page 17 L TR20081044, Rev . A Appendix Disconnect or shut off the gas line connect to the 1. grill. W ait until the burners cool down. Open the hood and remove the grate and ame 2. tamer on top of the burner you want to replace.
Location of Serial Number Plate The serial number of your Cal Flame grill is located on the back and is visible when the hood is down as shown at right.
An important point after buying a device Cal Flame LTR20081044 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Cal Flame LTR20081044 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Cal Flame LTR20081044 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Cal Flame LTR20081044 you will learn all the available features of the product, as well as information on its operation. The information that you get Cal Flame LTR20081044 will certainly help you make a decision on the purchase.
If you already are a holder of Cal Flame LTR20081044, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Cal Flame LTR20081044.
However, one of the most important roles played by the user manual is to help in solving problems with Cal Flame LTR20081044. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Cal Flame LTR20081044 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
