Instruction/ maintenance manual of the product 450 Weber
Go to page of 16
SUMMIT TM 425 & 450 LP Gas Barbecues Operating Guide W E B E R W E B E R W E B E R W E B E R 92776 10/98 Serial Number Serial Number Summit 425 LP Summit 450 LP R A P P R O V E D CANADIAN GAS ASSOCIA TION ® National Association PROPANE GAS Read before assembly W ARNING 1.
2 W ARNINGS D ANGER Failure to f ollow the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or a fire or an e xplosion causing damage to pr oper ty . ■ Do not store a spare or disconnected LP tank under or near this barbecue.
3 T ABLE OF CONTENTS Warnings 2 Warranty 4 A Word of Thanks 4 Standards and Codes Information 5 Operating Area 5 Storage 5 *REFER TO YOUR STEP-BY-STEP SECTION AT THIS TIME Lighting 6 Crossov er Igniti.
4 Thank you for choosing a W eber Barbecue. Our family her e at W eber has worked har d to produce the highest quality pr oducts for your satisfaction. While we give much attention to our pr oducts, an occasional err or may occur . Our knowledgeable Customer Service staf f is prepar ed to help you with any problems with parts or assembly .
5 ST ANDARDS AND CODES INFORMA TION Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the Weber Gas Barbecue y ou can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer Bars produce that "outdoor" fla v or in the f ood.
6 EA CH HEA T ZONE OPERA TES INDEPENDENTL Y . Summar y lighting instructions are on the control panel. Figure 1 D ANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, may result in an e xplosive flame- up which can cause serious bodil y injury or death.
7 EA CH HEA T ZONE OPERA TES INDEPENDENTL Y . 1) Open the lid. Figure 2. 2) Check that fuel scale reads more than “E”. Note - E = empty; F = full. 3 ) Make sure all b urner control knobs are tur ned OFF . (Push each burner control knob down and turn clockwise.
8 W ARNING: Do not move the W eber Gas Barbecue when operating or hot. High Medium Low Off COOKING W ARNING: T urn y our W eber Gas Barbecue OFF and wait for it to cool bef ore c leaning. CA UTION: Do not clean y our Flav oriz er Bars or cooking grills in a self-cleaning o ven.
9 The Steam-N-Chips Smoker cooks with both Weber FireSpice W ood Chips and Chunks . For best results with f aster cooking f oods like steaks , b urgers and chops, etc., we recommend using the FireSpice Chips because the y ignite and create smoke f aster .
10 Spider/Insect screens Y our Gas Barbecue, as well as an y outdoor gas appliance, is a target f or spiders and other insects . They can nest in the venturi section of the b urner tubes. This bloc ks the normal gas flow , and can cause the gas to flow back out of the air shutter .
11 MAINTENANCE Main Burner Flame P attern The W eber Gas Barbecue b urners have been f actor y set f or the correct air and gas mixture. The correct flame pattern is shown in Figure 7. Figure 7 Burner inside cooking bo x Flames Tips occasionally yello wish Light blue Dark blue Figure 8 Figure 9 Replacing Main Burners 1.
12 10. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossov er tube. Figure 13 (a). Figure 13 Crossov er tube Pull out of here Manif old 9.
13 MAINTENANCE 11. Lift and twist the burner assembly slightly to separate the crossov er tube from the b urners. Remov e the burners from the cooking box. Figure 14. Figure 14 Separate here Crossov er tube 12. T o reinstall the burners, re v erse steps 3 through 11.
14 Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burners do not light. -or- Burners ha ve a small flickering flame in the HIGH position. -or- Barbecue temperature only reaches 250˚ to 300˚ degrees in the HIGH position.
.
P A TENTS & TRADEMARKS © 1997 W eber-Stephen Products Co . Weber , the silhouette, Fla v orizer and Crosso v er are registered U .S. trademarks; Summit, Grill Cozy , Gas Catcher , Spider Stopper , and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co .
An important point after buying a device Weber 450 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Weber 450 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Weber 450 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Weber 450 you will learn all the available features of the product, as well as information on its operation. The information that you get Weber 450 will certainly help you make a decision on the purchase.
If you already are a holder of Weber 450, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Weber 450.
However, one of the most important roles played by the user manual is to help in solving problems with Weber 450. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Weber 450 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
