Instruction/ maintenance manual of the product PTS2021050 Bazooka
Go to page of 17
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Preparation Part Number: PTS20-21050 NOTE: Part number of this accessory m ay not be the same as the part number shown.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure Care must be taken when installing this acce ssory to ensure dam a ge does not occur to th e vehicle. The installation of this accessory should follow approve d guidelines to ensure a quality installation.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure Fig. 3-4 Fig. 3-3 Fig. 3-2 (d) Proceed to remove and secure the rear foam passenger side storage compartment.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure (i) Using a 10mm socket, remove the passenger rear D-Ring (Tie Down Hook) (discard) and save the 10mm bolt for reuse. Fig. 4-1 Fig. 3-7 Release with Screwdriver Plastic Hoo k Fig. 3-6 (j) Remove and save, the Philips h ead screw from the upper rear passenger panel & save for reuse.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure Fig. 4-5 Fig. 4-4 Fig. 4-3 (d) Remove the radio unit, by removing the two (2) top 10mm nuts and two (2) bottom screws from the radio bracket. (Fig.4-3) (e) Open the glove compartment latch and press the outside edges of the glove compartment inwards, to remove.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure Fig. 5-3 Fig. 5-2 3 2 1 Fig. 5-1 5. Routing Wire Harness (a) Starting at the rear of the vehicle, route the pig tail end underneath the rear strut reinforcement access panel, and route towards rear passenger side taillight.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure (g) Attach wire harness with one (1) 4” wire tie at the junction plug located underneath kick well. (Fig.5-5) FRONT WASHER REAR WASHER REA R LOC K NUT FRONT LOCK NUT Fig. 5-5 (1) Using the diagonal cu tter pliers, clip the 4” wire tie.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure flat washer and lock nut using a 13mm ratcheting box end wrench or socket from behind the inner sheet metal panel. (Fig.7-2) Fig. 7-3 (1) Make sure antenna wire harness runs underneath hardware assembly (Fig.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure (e) Referencing Step 3. b, reassemble the rear Cargo Floor panel & fl oor mat (if equipped). Fig. 9-1 (f) Referencing Step 3. a, reassemble the rea r Tonneau Cover. (g) Referencing Step 3. e, reassemble the rear bench seat.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure 10. In Process Functional Test. (a) Reconnect the vehicle’s negative battery cable. (1) Position the negative terminal at an angle of 90 ˚ to the battery as shown. (2) Tighten the nut with 4.1 N-m (36 lbf-in) of torque.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure 11. Reassemble Front Cabin Interior Components (a) Referencing Step 4. g - f., reassemble all panels into their orig inal locations, making sure that all clips are securely f astened. (b) Referencing Step 4.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure 12. Resetting Vehicle Components (a) Reset the power windows. (1) Turn ignition key to ON position. (2) Push down the power window switches of each door, and lower the windows halfway. (3) Pull up the switches until the windo ws close and hold switches up for a further one (1) second (minimum.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Procedure 14. Clean Up (a) Clean up and remove any trash. (b) If required, wipe down all applicable interior surfaces with 3M TM Prep Solvent-70, to remove .
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Troubleshooting. Condition: Check For: Accessory Function Checks Turn on Radio Radio display turns on & sound is heard Verify CD & Satellite Tuner (.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Troubleshooting. Condition: Check For: 1. Is the green L.E.D. lit on the VSE Subwoofer? If not, check for 12 volts on pins of the VSE Subwoofer with the ignition on. If either pin doesn’t indicate 12 volts, check T-Harness connectors behind the radio.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Troubleshooting. Condition: Check For: Page 16 of 17 pages Dimming Radio Lights Dimming Radio Lights could occur when the VSE Subwoofer is played at high volumes. Radio does not come on Check to ensure that the main connector, antenna connector, and auxiliary connector have been correctly plugged back in.
SCION tC 2005 - VSE SUBWOOFER (BAZOOKA ® ) Wire Harness & Radio Wiring Schem atics. WIRING CONNECTOR SCHEMATICS: Harness Split Radio Connector Subwoofer Connector Harness Split Connector Pin No.
An important point after buying a device Bazooka PTS2021050 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Bazooka PTS2021050 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Bazooka PTS2021050 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Bazooka PTS2021050 you will learn all the available features of the product, as well as information on its operation. The information that you get Bazooka PTS2021050 will certainly help you make a decision on the purchase.
If you already are a holder of Bazooka PTS2021050, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Bazooka PTS2021050.
However, one of the most important roles played by the user manual is to help in solving problems with Bazooka PTS2021050. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Bazooka PTS2021050 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
