Instruction/ maintenance manual of the product VFGL-24VSP-4 SERIES Superior
Go to page of 20
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 1 Unvented Gas Log Room Heaters P/N 903623 REV. M 12/2007 MODELS ST ANDARD SERIES FOR USE ONLY WITH DECORATIVE TYPE UNVENTED ROOM HEATERS. FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 2 TABLE OF CONTENTS General Information ......................... page 2 Inventory ......................................... page 2 Tools Required ................................ page 2 Important Safety Information .
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 3 • The installation must conform with local codes or, in the absence of local codes with the National Fuel Gas Code, ANSI Z223.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 4 The space in the previous example is a confined space because the actual BTU/Hr used is more than the maximum BTU/Hr the space can sup- port. You must provide additional fresh air. Your options are: a.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 5 Noncombustible Material Requirements with No Mantel Installed (A) Noncombustible Material Measurement Requirements for Safe Installation 12" or more Adjustable canopy not required. 8" minimum to 12" Install adjustable canopy, P/N 053752 ( Figure 3 ).
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 6 To avoid any movement of the heater during operation, attach the grate to the floor of the fireplace or firebox using the screws provided.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 7 Union Regulator Fireplace or Firebox Wall Wal l Shut-Off Key 3" Manual Shut-Off Valve Fireplace or Firebox Wall Sediment Tr a p Down Each heater includes a unitized set of ceramic fiber logs. The heater and logs are assembled as shown in Figure 11 .
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 8 In normal operation, at full rate, after 15 min- utes the following flame appearance should be observed: CAUTION: YOU MUST KEEP CONTROL AR- EAS, BURNERS AND CIRCULATING AIR PAS- SAGEWAYS OF FIREPLACE CLEAN.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 9 ACCESSORIES Decorative Volcanic Stone P/N 110791 FDVS Black P/N 053752 AC - BLK Adjustable Canopy Damper Clamp P/N 110701 DCK Thermostat P/N 064248 WT.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 10 UNVENTED GAS LOG ROOM HEATER SPECIFICATION CHART Model No. Valve Operation BTU/hr Input Gas Type * Manual control models are also design certified for use as vented gas log sets. UNVENTED GAS LOG ROOM HEATER TECHNICAL CHART BTU/HR Regulator Gas Inlet Valve Model No.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 11 1. When igniter button is pressed, there is no spark at ODS/pilot. 2. Heater produces unwanted odors. 3. Heater shuts off in use (ODS operates). 4. Gas odor even when control knob is in “OFF” position.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 12 OPERATING INSTRUCTIONS — MANUAL CONTROL MODELS FOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONS 1. Stop! Read the safety information above. 2. Make sure manual shut-off valve is fully open.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 13 Figure 16 Figure 15 Control Knob Locations Pilot Location Turn Control Knob to “OFF” Position (Manual) Turn Control Knob to “IGN” Position (M.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 14 OPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONS 1. Stop! Read the safety information above. 2. Make sure manual shut-off valve is fully open. 3. Locate gas control knob and piezo.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 15 Note: Knob cannot be turned from “PILOT” to “OFF” unless the knob is pushed in slightly. Do not force.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 16 REPLACEMENT PARTS LIST 18N/18P 24N/24P 28N/28P No. Description Part No. Part No. Part No. 1. Valve - Manual (Natural) 110331 110331 110331 Valve - Manual (Propane, L.P.G.) 110331 110331 110331 2. Valve, Millivolt (Natural) 903489 903489 903489 Valve, Millivolt (Propane, L.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 17 REPLACEMENT PARTS 1 2 5 9 10 13 14 12 8 7 6 11 4 3.
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 18 NOTE: THIS PAGE INTENTIONALLY LEFT BLANK..
NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 19 NOTE: THIS PAGE INTENTIONALLY LEFT BLANK..
The manufacturer reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.
An important point after buying a device Superior VFGL-24VSP-4 SERIES (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Superior VFGL-24VSP-4 SERIES yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Superior VFGL-24VSP-4 SERIES - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Superior VFGL-24VSP-4 SERIES you will learn all the available features of the product, as well as information on its operation. The information that you get Superior VFGL-24VSP-4 SERIES will certainly help you make a decision on the purchase.
If you already are a holder of Superior VFGL-24VSP-4 SERIES, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Superior VFGL-24VSP-4 SERIES.
However, one of the most important roles played by the user manual is to help in solving problems with Superior VFGL-24VSP-4 SERIES. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Superior VFGL-24VSP-4 SERIES along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
