Instruction/ maintenance manual of the product COB-GS Bakers Pride Oven
Go to page of 16
FULL SIZE GA S CONVECTION O VENS Models: COB-G & COM-G INTENDED FOR OTHER THAN HOUSEHOLD USE. RET AIN THIS MANUAL FOR FUTURE REFERENCE. OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES.
I. INST ALLA TION INSTRUCTIONS S e c t i o n I t e m P a g e A Receiving 2 B Set Up / Mounting 2 C Installation with Casters (Optional) 3 D Location & Minimum Clearances 4 E Gas Connections 4 F Electrical Connection 5 G Flue Connection V entilation 5 H Burner Operation 5 I System Check Rotary Control 5 J Programming Menus 6 II.
3 For a single unit: Refer to Figure 4 (1) T ilt Oven over to left-hand side and attach two 31” legs on the right-hand side with three ½” bolts and washers. T ighten firmly . (2) Using proper lifting equipment, lift up the left-hand side and attach two 31” legs on the left-hand side the same way .
D. LOCA TION AND MINIMUM CLEARANCES: Move the oven to its final location keeping the minimum clearance from the back of the oven to the wall. This clearance is necessary for safe operation and to provide proper air flow to the burner chamber .
F. ELECTRICAL CONNECTION: The oven, when installed, must be electrically grounded in accordance with local codes and/or the latest edition of the National Electrical Code ANSI/NFP A No. 70 in the USA (Canadian Electrical Code CSA Standard C22.1, Part 1 in Canada).
(5) T urn Gas Cock Dial to “ON” position (only for USA and Canada). (6) T urn the thermostat knob. The indicator light near the thermostat will illuminate and the burners will come on. (7) T urn the Timer Knob and set a time of 2 minutes. At the end of 2 minutes, you should hear the buzzer .
(7) When timer reaches zero, a buzzer will sound. (8) T urn the timer knob to “O” position. (9) Remove the product from the oven. NOTE: TIMER IS A SIGNAL DEVICE ONL Y AND DOES NOT CONTROL THE OVEN. Cook and Hold Rotary Control: (1) Close the oven doors.
8 Clean The Stainless Steel Interior: Baked on splatter , oil, grease or discoloration on the stainless steel inside of the oven may be removed with stainless steel cleaner , or any other similar cleaning agent. NEVER use vinegar or any corrosive cleaner .
Figure 3 Stacking Instructions For: COB-G & COM-G Convection Ovens ITEM 1 ITEM 2 ITEM 3 E3770A E3771A 3/8”-16 Bolt 9 Wheel Puller Bolt 3/8”-Hex Blower Wheel Set Screws (2) Motor Cleaning The B.
10 WITH PLA TE CASTER WITHOUT PLA TE CASTER Figure 4 LEG ASSEMBL Y INSTRUCTIONS - MODEL: COB-G & COM-G 1. Attach four item 2 to four item 1 using item 3, 4 and 5. 2. Using proper lifting equipment attach item 1 to the corresponding hole patterns located in the bottom of the oven with item 6.
11 Single-Phase 120V Wiring Diagram (Push-Button Control) GROUND STUD T2 T3 T4 T5 T1 T8 T9 T7 T6 T12 T13 T1 1 T10 DOOR SWITCH PROBE 37 39 LIGHTS 120V LOW HIGH 120V 24V PROBE IGNITER FLAME SENSOR TRANS.
12 Single-Phase 120V Wiring Diagram (Dial Control) BLACK P1 P2 P3 P4 COM NC NO T6 T7 T8 T9 T10 T11 BLUE 4 1 2 3 YELLOW GROUND STUD POWER LIGHT T- S TAT LIGHT SWITCH LIGHTS BUZZER 60 MIN TIMER POWER SW.
13 PA R T S LIST Model Number: COB-G & COM-G T ype of Gas: N a t u r a l L . P . O t h e r 4/05 Note: When ordering, AL W A YS specify Part #, Model #, Serial #,V oltage/Phase & type of Gas.
14 E x t e r i o r / Interior / Controls / Doors 4/05 Note: When ordering, AL W A YS specify Part #, Model #, Serial #, V oltage/Phase & type of Gas.
15 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 R3164A R3165A N5019A E8188A P9900A E8144A S0420A S6819A S68.
16 WHA T IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or.
An important point after buying a device Bakers Pride Oven COB-GS (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Bakers Pride Oven COB-GS yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Bakers Pride Oven COB-GS - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Bakers Pride Oven COB-GS you will learn all the available features of the product, as well as information on its operation. The information that you get Bakers Pride Oven COB-GS will certainly help you make a decision on the purchase.
If you already are a holder of Bakers Pride Oven COB-GS, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Bakers Pride Oven COB-GS.
However, one of the most important roles played by the user manual is to help in solving problems with Bakers Pride Oven COB-GS. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Bakers Pride Oven COB-GS along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
