Instruction/ maintenance manual of the product EBZ7001-CA RedMax
Go to page of 60
W ARNING OWNER / OPERA T OR MANUAL MODE D’EMPLOI MANUAL DE INSTRUCCIONES BA CKP A CK BLO WER SOUFFLANTE DORSALE SOPLADOR DE MOCHILA 848-L5C-93A2 (802) The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
2 SAFETY FIRST Instructions contained in warnings within this manual and warning seals marked with a symbol on the blower concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail.
3 SECURITE Les instructions contenues dans les mises en garde de ce mode d’emploi portant le symbole concernent les points critiques qui doivent être pris en considération pour éviter les blessures graves, c’est pourquoi ces précautions doivent être rigoureusement suivies.
4 1. Parts location English English ■ MODEL EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA Dimensions (L x W x H) mm (in) EBZ7001/EBZ7001-CA ················································································371x487x495 (14.
5 1. Emplacement des pieces 1. Situación de las piezas Français Español 1. Cadre 2. Sangle d' epaule 3. Chapeau de bougie d’allumage 4. Levier des gaz 5. Contacteur d'arrêt (derrière) 6. Grille 7. Levier de starter 8. Filtre à air 9.
3. W arning labels on the machine 6 English (1) Read owner's manual before operating this machine. (2) Wear head, eye and ear protection. (3) Handling this machine improperly could result in accidents causing serious injury or death.
3. Etiqueta de advertencia en la máquina 3. Etiquettes d’avertissement sur la machine 7 Français Español (1) Lire le mode d’emploi avant d’utiliser cette machine. (2) Porter un casque et des lunettes de sécurité, un casque antibruit. (3) Une manipulation incorrecte de cette machine peut provoquer des accidents graves ou mortels.
8 For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to make a mistake. (a) The port to refuel the "MIX GASOLINE" Position: FUEL TANK CAP (b) The direction to close the choke Position: INTAKE CUP (c) The direction to open the choke Position: INTAKE CUP 4.
9 Des symboles en relief ont été placés sur la machine pour assurer la sécurité à l’usage et faciliter l’entretien. Prendre soin d’observer les indications suivantes afin d’éviter les erreurs.
10 1. Read this Blower Owner/Operator Manual carefully. Be sure you understand how to operate this unit properly before you use it. Failure to do so could result in serious injury. 2. Be sure to keep this manual handy so that you may refer to it later whenever any questions arise.
11 1. Lea detenidamente el “Manual del propietario/operador” de este soplador. Asegúrese de comprender la forma de uso correcta de este aparato antes de usarlo. De lo contrario, podrá sufrir graves lesiones. 2. Asegúrese de guardar este manual en un lugar cercano y accesible, de modo que pueda consultarlo cada vez que tenga una duda.
12 vibration are mentioned as factors. In order to reduce the risk of whitefinger disease, the following precautions are strongly recommended; a) Keep your body warm. Never use blower during rains. b) Wear thick anti-vibration gloves. c) Take more than 5 minutes of break in warm place frequently.
symptômes sont une sensation de picotement et de brûlure suivis de la décoloration des doigts et de leur engourdissement. Cette maladie est mal connue, mais il semblerait qu’elle soit provoquée entre autres par le froid, les maladies du tabac ou l’état physique ou encore une exposition prolongée aux vibrations.
14 4. Check your equipment before operation, especially the muffler, air intakes and air filters. ■ WORKING PLAN • When planning your work schedule, allow plenty of time to rest.
15 3. Travaillez au régime le plus bas possible de votre soufflante à amplificateur de puissance. 4. Vérifiez votre appareil avant de l’utiliser, notamment le silencieux, les arrivées d’air et les filtres à air. ■ PLAN DE TRAVAIL • Lorsque vous tracez votre plan de travail, prévoyez suffisamment de pauses.
16 Check to see if the shock-absorbing rubber mount has become cracked or otherwise damaged. Note that failing to replace this rubber mount when it has become cracked or damaged may cause the engine to come loose from its frame during use, thus resulting in possible serious bodily injury.
17 des blessures graves. • Vérifiez si la garniture du caoutchouc du ressort auxiliaire n’est pas fendue ou endommagée. Si la garniture n’est pas remplacée alors qu’elle est fendue ou endommagée le moteur risque de se détacher du cadre lorsque vous utiliserez la machine et vous pourriez être grièvement blessé.
18 c) Conserve water by using power blowers instead of hoses for many lawn and garden applications, including areas such as gutters, screens, patios, grills, porches and gardens. 4. Never to touch the spark plug or plug cord while the engine is in operation.
19 légèrement la surface ou utilisez le brumisateur s’il y a de l’eau dans les parages. c) Utilisez des souffleurs à amplificateur de puissance à la place des flexibles pour les gazons ou les jardins afin d’économiser l’eau. Ceci s’applique également aux gouttières, aux grilles, aux porches, aux cours, aux jardins.
20 5. For safe operation English maintenance or repair work not described in this manual must be performed, please contact a representative from the store nearest RedMax authorized servicing dealer for assistance. 7. Do not use any accessory or attachment other than those bearing the RedMax mark and recommended for the unit.
21 5. Consignes de securite 5. Instrucciones de seguridad Français Español RedMax ou des produits dont RedMax a certifié l’utilisation pour ses machines.
22 6. Set up English ■ BLOWER TUBES 1. Connect the blower and swivel joint with flexible hose. Clamp both ends of the flexible hose securely with the hardware supplied with the unit. 2. Align the protrusion and the groove provided on the tube ends and twist the tube until connection is locked up.
23 6. Assemblage 6. Montaje Français Español ■ TUYAUX DE SOUFFLERIE 1. Connecter la soufflerie et le joint à rotule au flexible. Serrer fermement les deux extrémités du flexible avec le matériel fixé à l’appareil.
■ FUEL • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m (10ft) away from the fueling point before starting the engine.
■ COMBUSTIBLE • La gasolina es muy inflamable. Evite fumar o producir cualquier llama o chispa cerca del combustible. Asegúrese de detener el motor y dejar que se enfríe antes de repostar la unidad.
26 7. Fuel English ■ HOW TO MIX FUEL Pay attention to agitation. 1. Measure out the quantities of gasoline and oil to be mixed. 2. Put some of the gasoline into a clean, approved fuel container. 3. Pour in all of the oil and agitate well. 4. Pour In the rest of gasoline and agitate again for at least one minute.
27 participer ainsi à la protection de l’environnement et de votre santé. • De l’essence ou de l’huile de basse qualité risque d’endommager les joints, les conduites d’essence ou le réservoir d’essence du moteur. ■ COMMENT OBTENIR UN BON MELANGE Faire attention à ne pas trop remuer le carburant.
28 7. Fuel English FOR YOUR ENGINE LIFE, AVOID; 1. FUEL WITH NO OIL(RAW GASOLINE) – It will cause severe damage to the internal engine parts very quickly. 2. GASOHOL – It can cause deterioration of rubber and/or plastic parts and disruption of engine lubrication.
29 A EVITER POUR PROLONGER LA DUREE DE VIE DU MOTEUR : 1. ESSENCE SANS HUILE (ESSENCE PURE) – L’essence pure est capable d’endommager très rapidement les pièces du moteur. 2. ESSENCE-ALCOOL – Ce mélange risque de très rapidement détruire les pièces en caoutchouc et/ou en plastique et d’empêcher la lubrification du moteur.
30 8. Operation English ■ CONTROL ARM [EBZ7001] [EBZ7001-CA] (F5) • Hold the upper end of the control arm in hand and, while pulling it away from the unit, rotate arm forward (anti-clockwise as the arrow direction) until it clicks. (The first position) And if you want, you can rotate arm more forward until it clicks.
31 8. Fonctionnement 8. Uso Français Español ■ BRAS DE COMMANDE [EBZ7001] [EBZ7001-CA] (F5) • Tenir en main l'extrémité supérieure du bras de commande et, tout en l'éloignant de l&.
32 8. Operation English exhaust port. 6. Once the engine is running, gradually open the choke if it was set closed, and let the engine run at idle speed for a minute to warm it up. When the engine fails to start after several attempts due to overchoking, open the choke and repeat pulling the rope.
33 8. Fonctionnement 8. Uso Français Español prématurée du démarreur. •N e laissez personne s’approcher de la soufflante ou de l’orifice d’échappement. 6. Dès que le moteur tourne, ouvrir progressivement l’étrangleur, s’il a été fermé et laisser le moteur tourner au ralenti pendant une minute pour le préchauffer.
34 Maintenance, replacement, or repair of the emission control device and systems may be performed by any non-road engine repair establishment or individual. 9. Maintenance English Make sure that the engine has stopped and is cool before performing any service to the blower.
35 L’entretien, le remplacement ou la réparation du dispositif et des systèmes de lutte contre les émissions peuvent être effectués par toute société ou individu spécialisé dans la réparation des moteurs hors-route.
36 9. Maintenance English CLEANING AIR FILTER: 1. Unscrew 2 knob bolts and remove the air cleaner cover. Then remove a prefilter mounted inside the air cleaner cover. (1) Knob Bolt (2) Prefilter (3) Paper Filter 2. Wash the prefilter in fresh, non flammable cleaning solution (ex.
37 9. Entretien 9. Mantenimiento Français Español poussiéreux risque également d’être endommagé. NETTOYAGE DU FILTRE A AIR: 1. Dévissez les 2 vis de blocage puis déposez le couvercle du filtre à air. Retirez ensuite l’unité de pré-filtrage située sous le couvercle du filtre à air.
38 9. Maintenance English • Note that using any spark plugs other than those designated may result in the engine failing to operate properly or in the engine becoming overheated and damaged. • To install the spark plug, first turn the plug until it is finger tight, then tighten it a quarter turn more with a socket wrench.
39 9. Entretien 9. Mantenimiento Français Español • Veuillez noter que l’utilisation de bougies d’allumage autres que celles prescrites risque d’endommager le moteur, de provoquer des surchauffes et des pannes.
40 9. Maintenance English ■ PROCEDURES TO BE PERFORMED AFTER EVERY 100 HOURS OF USE 1. Remove the muffler, insert a screwdriver into the vent, and wipe away any carbon buildup. Wipe away any carbon buildup on the muffler exhaust vent and cylinder exhaust port at the same time.
41 9. Entretien 9. Mantenimiento Français Español ■ ACTIONS DEVANT ÊTRE ENTREPRISES TOUTES LES 100 HEURES D’UTILISATION 1. Déposez le silencieux, passez un tournevis dans l’aération et nettoyez les dépôts de carbone. Nettoyez de même les dépôts de carbone de l’aération du silencieux et de l’orifice d’échappement.
42 9. Maintenance English ■ SHOULDER STRAP • If the shoulder strap is damaged it may break during use, thus causing the product to fall and resulting in personal injury. Follow the instructions below to replace the shoulder strap with new one. • Pass the upper end of the strap through the hanger, making the FLAPPED SIDE OUTSIDE.
43 9. Entretien 9. Mantenimiento Français Español ■ SANGLE D' EPAULE • Si la sangle d' épaule est endommagée, elle peut rompre pendant l' utilisation, occasionnant la chute de la machine et entrainant des blessures corporelles. Suivre les instructions en-dessous pour remplacer la sengle d' épaule.
44 Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw .
45 13. Parts list 13. Liste des pièces 13. Lista de piezas NOTE : 1. Use RedMax/ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. RedMax/ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company.
46 Fig.1 BLOWER GROUP (EBZ7001/EBZ7001RH : S/N 60600101 and up) (EBZ7001-CA : S/N 70400101 and up) (EBZ7001RH-CA : S/N 70400101 and up) 13. Parts List : EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA.
47 EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA Fig.1 BLOWER GROUP (EBZ7001/EBZ7001RH : S/N 60600101 and up) (EBZ7001-CA : S/N 70400101 and up) (EBZ7001RH-CA : S/N 70400101 and up) Key# Part Number Descr.
48 13. Parts List : EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA Fig.2 ENGINE GROUP (EBZ7001/EBZ7001RH : S/N 60600101 and up) (EBZ7001-CA : S/N 70400101 and up) (EBZ7001RH-CA : S/N 70400101 and up).
49 EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA Fig.2 ENGINE GROUP (EBZ7001/EBZ7001RH : S/N 60600101 and up) (EBZ7001-CA : S/N 70400101 and up) (EBZ7001RH-CA : S/N 70400101 and up) Key# Part Number Descr.
50 13. Parts List : EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA Key# Part Number Description Q'ty 1 T1108-81450 BODY ASSY 1 2– SCREEN 1 3– VALVE 1 4– SPRING 1 5– SCREW 1 6– P I N 1 7– L.
51 13. Parts List : EBZ7001/EBZ7001RH/EBZ7001-CA/EBZ7001RH-CA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 1 22a 22b Fig.4 LEVER SET (EBZ7001 : S/N 60600101 and up) (EBZ7001-CA : S/N 70400101 and up) Fig.
The California Air Resources Board and ZENOAH AMERICA, INC. are pleased to explain the emission control system warranty on your 2007 and later small off-road engine. In California, new small off-road engines must be designed, built and equipped to meet the state’s stringent anti-smog standards.
La Commission des ressources en air de Californie et ZENOAH AMERICA, INC. sont heureux d'expliquer la garantie du système de contrôle des émissions de votre petit moteur hors route de 2007 et ultérieur.
La Comisión de Recursos del Aire de California y ZENOAH AMERICA, INC. tienen el agrado de explicar la garantía del sistema de control de emisiones para motores “todo terreno” modelo 2007 y posteriores .
EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE UNIT, RedMax / ZENOAH AMERICA, INC., THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP.
Pièces en rapport avec les émissions de gaz d'échappement : RedMax / ZENOAH AMERICA, INC., par l'intermédiaire de n'importe quel revendeur RedMax, réparera gratuitement ou remplace.
PIEZAS REALACIONADAS CON LAS EMISIONES, POR DOS (2) AÑOS A CONTAR DE LA FECHA DE ENTREGA ORIGINAL DEL UNIDAD, RedMax / ZENOAH AMERICA, INC., A TRAVÉS DE CUALQUIER DISTRIBUIDOR RedMax, REPARARÁ O RE.
.
.
Printed in U.S.A. ZENOAH AMERICA, INC. 1100 Laval Blvd. Suite 110 Lawrenceville, Georgia 30043.
An important point after buying a device RedMax EBZ7001-CA (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought RedMax EBZ7001-CA yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data RedMax EBZ7001-CA - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, RedMax EBZ7001-CA you will learn all the available features of the product, as well as information on its operation. The information that you get RedMax EBZ7001-CA will certainly help you make a decision on the purchase.
If you already are a holder of RedMax EBZ7001-CA, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime RedMax EBZ7001-CA.
However, one of the most important roles played by the user manual is to help in solving problems with RedMax EBZ7001-CA. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device RedMax EBZ7001-CA along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
