Instruction/ maintenance manual of the product 06 edge va Quantum
Go to page of 36
QUANTUM Product Serial # Q6 Edge V A Q6 Edge V A.
SAFETY GUIDELINES Copyright © 2013 Pride Mobility Products Corp. INFMANU4409/Rev B/September 2013 Quantum Rehab Provider: Address: Phone Number: Purchase Date: NOTE: This owner’s manual is compiled from the late st specifications and product information available at the time of publication.
Q6 Edge VA www.pridemobility.com 3 I. INTRODUCTION .............................................................................................................................. ..... 4 II. SAFETY ......................................................
4 www.pridemobility.com Q6 Edge VA I. INTRODUCTION SAFETY WELCOME to Quantum Rehab, a division of Pride Mobil ity Products (Pride). The power chair you have pur- chased combines state-of -the-art components with safety , comfort, and styling in mind.
Q6 Edge VA www.pridemobility.com 5 Power chair information label. Manufactured in Read and follow the information in the owner’s manu al. II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the power chair to identi fy warnings, mandatory acti ons, and prohibited actions.
6 www.pridemobility.com Q6 Edge VA II. SAFETY GENERAL GUIDELINES MANDATORY! Do not operate your new power chair for the first tim e without completely reading and understanding this owner’s manual. Your power chair is a state-of-the-a rt life-enhancement device designed to increase m obility.
Q6 Edge VA www.pridemobility.com 7 III. YOUR POWER CHAIR THE Q6 EDGE VA POWER CHAIR Your power chair has two main assemblies: the seat assembly and the power base assembly. See figure 1. Typically, the seat assembly includes the armrests, seatback, and seat base.
8 www.pridemobility.com Q6 Edge VA III. YOUR POWER CHAIR PROHIBITED! The spring tension on your power chair was factory set to meet the needs of the demographic majority of users.
Q6 Edge VA www.pridemobility.com 9 III. YOUR POWER CHAIR Main Circuit Breaker (located on the rear main frame): The main circuit breaker is a safety feature built into your power chair.
10 www.pridemobility.com Q6 Edge VA MANUAL FREEWHEEL LEVER MANUAL FREEWHEEL LEVER III. YOUR POWER CHAIR Manual Freewheel Levers For your convenience, your power chair is equipped with a manua l freewheel lever mounted on each motor. The levers allow you to disengage the drive motors and maneuver the chair manually.
Q6 Edge VA www.pridemobility.com 11 MANUAL FREEWHEEL LEVER MANUAL FREEWHEEL LEVER III. YOUR POWER CHAIR Figure 5A. Drive Mode (Left Drive Motor Engaged) Figure 5B.
12 www.pridemobility.com Q6 Edge VA INITIAL ASSEMBLY Your power chair may require some assembly either before initial use or after trans portation. It may also require disassembly to make some comfort adjustments.
Q6 Edge VA www.pridemobility.com 13 Seat Installation It may be necessary to install the seat either prior to initial operation or after tr ansporting your power chair. For unoccupied transit power chairs, contour seats are attached to the power base with the Universal Mount- ing System (UMS).
14 www.pridemobility.com Q6 Edge VA IV. ASSEMBLY MANDATORY! Prevent controller harness damage! Avoid routing the controller harness on the outside of the armrest pad.
Q6 Edge VA www.pridemobility.com 15 SECUREMENT BRACKETS (3 OF 4 SHOWN) POSITIONING BELT ANCHORING BR ACKET LOCATIONS (1 OF 2 SHOWN) IV. ASSEMBLY Figure 11. Power Elevat ing Seat Actuator ACTUATOR SEAT PLATE INTERFACE BRACKET Power Elevating Seat Option Your power chair may be e quipped with a power ele- vating seat option.
16 www.pridemobility.com Q6 Edge VA You may need the following to make comfort adjustments: metric/standard socket set and ratchet adjustable wrench metric/standard hex key set thread .
Q6 Edge VA www.pridemobility.com 17 Figure 14. Seat Po sition Adjustment V. COMFORT ADJUSTMENTS SEAT MOUNTING HOLES 7. Remove the hardware that attaches the trapeze bars to the seat interface weldments. See figure 13. 8. Move the trapeze bars up or down to the desired height.
18 www.pridemobility.com Q6 Edge VA V. COMFORT ADJUSTMENTS Seatback Angle Adjustment If your power chair is equippe d with an adju stable seat- back, you can adjust it to f our (4) different angles: 90°, 102°, 105°, or 107°. To adjust the seatback angle: 1.
Q6 Edge VA www.pridemobility.com 19 V. COMFORT ADJUSTMENTS Figure 16. Underside of Armrest Controller Position You can move the controller in toward or out away from the armrest, or change the position of the control- ler for either left-hand or right-hand use.
20 www.pridemobility.com Q6 Edge VA V. COMFORT ADJUSTMENTS Foot Platform Height Adjustment The foot platform height is easily adjusted to several different heights. To raise or lower the foot platform: 1. Remove the hardware from the foot platform bracket.
Q6 Edge VA www.pridemobility.com 21 V. COMFORT ADJUSTMENTS Power Elevating Seat (Optional) If your power chair is equi pped with a power elevating seat, you can change the seat height either through the controller or through a toggl e switch mounted to one of the armrests.
22 www.pridemobility.com Q6 Edge VA 2. Insert the screw through the supplied washer, through the positioning belt and into the seat base for each side of the power chair seat. 3. Tighten both screws. To adjust the positioning belt for operator comfort: 1.
Q6 Edge VA www.pridemobility.com 23 VI. BATTERIES AND CHARGING BATTERIES AND CHARGING The Q6 Edge VA uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) le vel.
24 www.pridemobility.com Q6 Edge VA To charge the batteries using the off-board charger: 1. Position your power chair next to a standard electrical outlet. 2. Be certain the controller po wer is turned off and the power chair is in drive mode. 3. Plug the off-board charger into the off-board charger/ programming socket on the controller.
Q6 Edge VA www.pridemobility.com 25 Daily Use If you use your power chair on a daily basis, charge the batteri es as soon as you are finished using your power chair. Your power chair will be re ady each morning to give you a full day’s service. It is recommended that you charge the batteries at least 8 to 14 hours after daily use.
26 www.pridemobility.com Q6 Edge VA VI. BATTERIES AND CHARGING How can I ensure maximum battery life? A fully charged deep-cycle battery will provide reliabl e performance and extended ba ttery life. Keep your power chair’s batteries fully charged whenever possible.
Q6 Edge VA www.pridemobility.com 27 CARE AND MAINTENANCE Your Q6 Edge VA is a sophi sticated power chair. Like any motorized vehicle, it requires routine maintenance checks. You can perform some of these checks, but others require assistance from your Quantum Rehab Provider.
28 www.pridemobility.com Q6 Edge VA The body shroud has been spra yed with a clear sealant coating. You ca n apply a light coat of car wax to help it retain its high-gloss appearance. Check all electrical connections. Make sure they are tight and are not corro ded.
Q6 Edge VA www.pridemobility.com 29 Storage Your power chair should be stored in a dry place, free from temperature ex tremes. When storing, disconnect the batteries from the power chair. See VI. “Batteries and Charging.” WARNING! If you fail to store the uni t properly, the frame can rust and th e electronics can be damaged.
30 www.pridemobility.com Q6 Edge VA VII. CARE AND MAINTENANCE Follow these easy steps for a quick and safe repair for both pneumatic and solid tires: 1. Turn off the power to the controller. 2. Set the power chair up on blocks. 3. If you are changing a pneumatic tire, comple tely deflate it befo re removing the wheel.
Q6 Edge VA www.pridemobility.com 31 VII. CARE AND MAINTENANCE BATTERY WIRING DIAGR AM LABEL QUICK RELEASE BATTERY CONNECTORS FRONT BATTERY REAR BATTERY FRONT COVER To replace the batteries: 1. Turn off the power to the controller. 2. Make sure that the power chair is in drive mode.
32 www.pridemobility.com Q6 Edge VA VII. CARE AND MAINTENANCE When to See Your Quantum Rehab Provider for Service The following symptoms could indicate a serious probl em with your power chair.
Q6 Edge VA www.pridemobility.com 33 NOTES.
34 www.pridemobility.com Q6 Edge VA NOTES.
SAFETY GUIDELINES Copyright © 2013 Pride Mobility Products Corp. INFMANU4409/Rev B/September 2013 Quantum Rehab Provider: Address: Phone Number: Purchase Date: NOTE: This owner’s manual is compiled from the late st specifications and product information available at the time of publication.
QUANTUM Product Serial # Q6 Edge V A Q6 Edge V A.
An important point after buying a device Quantum 06 edge va (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Quantum 06 edge va yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Quantum 06 edge va - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Quantum 06 edge va you will learn all the available features of the product, as well as information on its operation. The information that you get Quantum 06 edge va will certainly help you make a decision on the purchase.
If you already are a holder of Quantum 06 edge va, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Quantum 06 edge va.
However, one of the most important roles played by the user manual is to help in solving problems with Quantum 06 edge va. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Quantum 06 edge va along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
