Instruction/ maintenance manual of the product Jazzy 600 XL Pride Mobility
Go to page of 43
Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com Owner’ s Manual.
4 4 www .pridemobility .com Jazzy 600 XL SAFETY GUIDELINES Copyright © 2005 Pride Mobility Products Corp. INFMANU3091/RevA/November 05 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information.
Jazzy 600 XL www .pridemobility .com 3 I. INTRODUCTION ................................................................................................................................. 4 I I . SAFETY ...................................................
4 www .pridemobility .com Jazzy 600 XL I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of- the-art components with safety , comfort, and styling in mind.
Jazzy 600 XL www .pridemobility .com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product’ s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at www .
6 www .pridemobility .com Jazzy 600 XL II. SAFETY Cor r osiv e chemicals contained in batter y . Use onl y AGM or Gel-Cell ba tteries to reduce the risk of leakage or explosive conditions. EMI-RFI - This product has been tested and passed at an immunity level of 20 V/m.
Jazzy 600 XL www .pridemobility .com 7 II. SAFETY Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid exposure to rain, snow , ice, salt, or standing wa ter w hene ver possible. Maintain and store in a clean and dr y condition.
8 www .pridemobility .com Jazzy 600 XL II. SAFETY SAFETY MAND A T OR Y! Do not operate y our new power c hair for the first time without completel y reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility .
Jazzy 600 XL www .pridemobility .com 9 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity v oids your warr anty and may r esult in personal injur y and/or damage to your power c hair .
1 0 www .pridemobility .com Jazzy 600 XL II. SAFETY Figure 1. Maximum Safe Slope (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications presented in this manual.
Jazzy 600 XL www .pridemobility .com 1 1 II. SAFETY Freewheel Mode Y our power chair is equipped with two manual freewheel levers to allow for manual maneuverability by a trained attendant. For more information about how to place your power chair into and out of freewheel mode, see III.
1 2 www .pridemobility .com Jazzy 600 XL II. SAFETY T ransfers T ransferring onto and off of your power chair requires a good sense of balance. Always have an attendant or health- care professional present while learning to properly trans- fer yourself.
Jazzy 600 XL www .pridemobility .com 1 3 II. SAFETY Inclement Weather Precautions Exposure of your power chair to inclement weather conditions should be avoided whenever possible. If suddenly caught up in rain, snow , severe cold or heat while operating your power chair proceed to shelter at the earliest opportunity .
1 4 www .pridemobility .com Jazzy 600 XL II. SAFETY Removable Parts WARNING! Do not attempt to lift or mo ve a po wer chair by any of its removable par ts.
Jazzy 600 XL www .pridemobility .com 1 5 III. YOUR POWER CHAIR THE JAZZY 600 XL The Jazzy 600 XL has two main assemblies: the seat assembly and the power base assembly . See figure 5. T ypically , the seat assembly includes the armrests, seatback, and seat base.
1 6 www .pridemobility .com Jazzy 600 XL J J J J J AZZY 600 XL S AZZY 600 XL S AZZY 600 XL S AZZY 600 XL S AZZY 600 XL S PECIFICA PECIFICA PECIFICA PECIFICA PECIFICA TIONS TIONS TIONS TIONS TIONS Suspension: Active-Trac Extreme Drive Wheels: 14 in., solid Front Caster Wheels: 5 in.
Jazzy 600 XL www .pridemobility .com 1 7 III. YOUR POWER CHAIR ELECTRICAL COMPONENTS The electrical components are located inside the power base. The ammeter and the charger power cord receptacle are located on the right side of the power base. The main circuit breaker is located on the front of the battery tray .
1 8 www .pridemobility .com Jazzy 600 XL III. YOUR POWER CHAIR Battery Connector: This is where the controller connects to the batteries. Controller Connector (FLIGHT Only): This is where the controller connects to the power module. Main Cir cuit Breaker: The main circuit breaker is a safety feature built into your power chair .
Jazzy 600 XL www .pridemobility .com 1 9 MANU AL FREEWHEEL LEVERS The Jazzy 600 XL has a manual freewheel lever on each motor . Manual freewheel levers enable you to disengage the drive motors from the gearboxes and maneuver the chair manually .
2 0 www .pridemobility .com Jazzy 600 XL INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation.
Jazzy 600 XL www .pridemobility .com 2 1 IV . ASSEMBL Y SEA T INST ALLA TION It may be necessary to install the seat either prior to initial operation or after transporting your power chair . Most seats are attached to the power base with the Universal Mount- ing System (UMS).
2 2 www .pridemobility .com Jazzy 600 XL V . COMFOR T ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair ’ s operation, you may find the need to make some adjustments to increase your comfort, such as seat height and angle, armrest angle, foot platform height and angle, and controller position.
Jazzy 600 XL www .pridemobility .com 2 3 ARMREST KNOB JAM NUTS ARMREST ANGLE ADJUSTING SCREW Figure 16. Seatback Angle Adjustment Figure 15. Seat Position Adjustment V . COMFOR T ADJUSTMENTS 12 . Reinstall each screw into the trapeze bars and tighten.
2 4 www .pridemobility .com Jazzy 600 XL Armrest Wid th Adjustment Y ou can change each armrest’ s width independently of the other . NOTE: Changing the armrest width may increase the overall width of your power chair . T o change the armr est width: 1 .
Jazzy 600 XL www .pridemobility .com 2 5 V . COMFOR T ADJUSTMENTS two states: clamped and unclamped. When the lever is open, the quick release fastener is unclamped. When the lever is closed, the quick release fastener is clamped. T o clamp the quick release fastener: 1.
2 6 www .pridemobility .com Jazzy 600 XL V . COMFOR T ADJUSTMENTS Swing-away Footrests Swing-away Footrests (SFRs) enable you to rotate the foot- rests to the side before you transfer onto or off or your power chair . See figure 20. T o rotate the SFRs: 1.
Jazzy 600 XL www .pridemobility .com 2 7 Multi-Axis Foot Plates The multi-axis foot plate assembly can be installed on either a swing-away footrest or an elevating leg rest. The multi- axis foot plate has four adjustments: leg rest length (A), po- sition (B), tilt (C), and angle (D).
2 8 www .pridemobility .com Jazzy 600 XL VI. BA TTERIES AND CHAR GING BA TTERIES AND CHARGING The Jazzy 600 XL uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level.
Jazzy 600 XL www .pridemobility .com 2 9 VI. BA TTERIES AND CHARGING NOTE: If it is a Pride off-board charger , then there are two lights in it. The red light indicates that power to the off-board charger is on. The green light indicates that the batteries are fully charged.
3 0 www .pridemobility .com Jazzy 600 XL VI. BA TTERIES AND CHAR GING NOTE: Keep your batteries fully charged and avoid deeply discharging your batteries.
Jazzy 600 XL www .pridemobility .com 3 1 How should I store my power chair and its batteries? If you do not use your power chair regularly , we recommend maintaining battery vitality by charging the batteries at least once per week. If you do not plan on using your power chair for an extended period, fully charge the batteries prior to storage.
3 2 www .pridemobility .com Jazzy 600 XL Figure 24. FLIGHT Controller 2 3 4 5 1 VII. OPERA TION FLIGHT CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system.
Jazzy 600 XL www .pridemobility .com 3 3 Figure 25. FLIGHT Controller Keypad VII. OPERA TION On/Off Key The on/off key turns the FLIGHT on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the chair . T his will cause the power chair to stop abr uptl y .
3 4 www .pridemobility .com Jazzy 600 XL VII. OPERA TION Speed Keys There are two keys that control the speed. Press the hare key to increase the speed. Press the tortoise key to decrease the speed. The speed setting is displayed on the speed indicator .
Jazzy 600 XL www .pridemobility .com 3 5 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our Jazzy 600 XL is a sophisticated power chair . Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from your authorized Pride Provider .
3 6 www .pridemobility .com Jazzy 600 XL VIII. CARE AND MAINTENANCE ! Check all electrical connections. Make sure they are tight and are not corroded. Batteries must sit flat within the battery tray , with the battery terminals facing inward, toward each other .
Jazzy 600 XL www .pridemobility .com 3 7 VIII. CARE AND MAINTENANCE WARNING! If you fail to store the unit pr oper ly , the frame can r ust and the electr onics can be damaged. Cleaning Instructions WARNING! Ne ver hose off your power chair or place it in direct contact with wa ter .
3 8 www .pridemobility .com Jazzy 600 XL VIII. CARE AND MAINTENANCE Battery Replacement A battery wiring diagram is printed on a decal located on the front battery tray . See VI. “Batteries and Char ging” for correct battery specifications. WARNING! Prevent injur y .
Jazzy 600 XL www .pridemobility .com 3 9 BATTERY WIRING DIAGRAM LABEL VIII. CARE AND MAINTENANCE Figure 28. Battery Installation REAR SHROUD FASTENERS REAR SHROUD FRONT BATTERY REAR BATTERY DWR1234L80.
4 0 www .pridemobility .com Jazzy 600 XL VIII. CARE AND MAINTENANCE When to See Y our Authorized Pride Provider for Service The following symptoms could indicate a serious problem with your power chair . If necessary , contact your authorized Pride Provider .
Jazzy 600 XL www .pridemobility .com 4 1 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the origin.
4 2 www .pridemobility .com Jazzy 600 XL IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EX CLUSIONS This warranty does not extend to those items which may require replacement due to normal wear and tear .
Quality Control- Model 14 0 0 Quality Control - Jazzy 600 XL Thank you for making the Jazzy 600XL your choice in power chairs. W e have thoroughly inspected your power chair . The following checkmarks indicate that it has been test driven and inspected.
An important point after buying a device Pride Mobility Jazzy 600 XL (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Pride Mobility Jazzy 600 XL yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Pride Mobility Jazzy 600 XL - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Pride Mobility Jazzy 600 XL you will learn all the available features of the product, as well as information on its operation. The information that you get Pride Mobility Jazzy 600 XL will certainly help you make a decision on the purchase.
If you already are a holder of Pride Mobility Jazzy 600 XL, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Pride Mobility Jazzy 600 XL.
However, one of the most important roles played by the user manual is to help in solving problems with Pride Mobility Jazzy 600 XL. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Pride Mobility Jazzy 600 XL along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
