Instruction/ maintenance manual of the product 600 SERIES Magikitch'n
Go to page of 18
L25-001 REV 1 (11/02) MAGIKITCH’N A MAYT AG COMP ANY 180 Penn Am Drive Quakertown, Penns ylv ania 18951-2435 USA Telephone 800-44 1-1492 Fax: (215 ) 538-3644 WEBSI TE: W WW. MA GI KI TCH N .CO M PN 31-01-10374 © 2000– Mag i Ki tch ’ n 600 SERIES GAS BROILER INSTALLATION – OPERATION - MAINTENANCE MAGIKITCH’N P.
L25-001 REV 1 (11/02) NOTICE: THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE ODOR OF GAS IS DETECTED ARE TO BE POSTED IN A PROMINENT LOCA TION. THESE INSTRUCTIONS SHALL BE OBT AINED FROM THE LOCAL GAS SUPPLIER. KEEP AREA AROUND APPLIANCES FREE AND CLEAR FROM COMBUSTIBLES.
L25-001 REV 1 (11/02) Table of Contents 1. Inst allation 2. Gas Hook Up 3. Gas Settings 4. Lighting Instructions 5. Initial Set Up 6. Cleaning and Maintenance 7.
L25-001 REV 1 (11/02) 1. INST ALLA TION Units are to be installed in non-combustible loca tions only to utilize a 0” minimum clearance to non-combustible construction. Not approved for installations in combustible constructions. This installation must conform to local codes.
L25-001 REV 1 (11/02) suggest a Dow Corning®, GE® or Permatex® s ilicone ‘RTV’ adhesive sealant or equivalent. (See NSF Basic Criteria C-2 for details). 2. GAS HOOK UP An adequate gas supply is imperat ive. Undersized lines or low-pressures will restrict the volume of gas required for satisfactory perform ance.
L25-001 REV 1 (11/02) 3. GAS SETTINGS Regulator pressure must be measured and adjusted before th e unit goes into service, following installation and when operational perfo rmance is in question. A soft blue flame, just short of a yellow tip, gives the best resu lts; combustion air can be adjusted by opening or closing the air shutter slightly.
L25-001 REV 1 (11/02) SMB 600 Series Models without safety pilot a.) Turn all burners to OFF. b.) Remove the top grid(s). d.) Turn the runner tube valve to ON. e.) Light the runner tube through the gap in the front of the coal support as shown. Note: If the runner tube does not light, wait a few seconds, then try again.
L25-001 REV 1 (11/02) RMB 600 Series -S Models with safety pilot 1. Turn all burners to OFF. 2. Remove the top grid. 3. Remove a radiant. 4. Turn the shut off valve to ON. 5. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds.
L25-001 REV 1 (11/02) 5. INITIAL SET-UP All Models PROPER SET UP OF THE BROILER - After the in stallation of the broiler by a qualified technician, a thorough cleaning is necessary. Afte r this cleaning, be sure the broiler is set up properly. TOP GRID - Your top cooking gr id has two positions, either fl at or tilted.
L25-001 REV 1 (11/02) RMB 600 Series models STAINLESS STEEL RADIANT - It is ve ry important that the stainl ess steel radiants are placed over the burners. This will prov ide radiant heat and protect the burners from dripping grease. PREHEATING - It is necessary to preheat a co ld broiler each time before cooking.
L25-001 REV 1 (11/02) COALS - Use only Magicoals supplied by MagiKitch'n. Do not use lava rock or other replacement coals. They do not perform as well or last as long as the Magicoals that were designed for this application. Place the coals ev enly across the surface of the coal support.
L25-001 REV 1 (11/02) 6. CLEANING AND MAINTENANCE DAILY CLEANING AND MAINTENANCE TOP GRID - The top grid can be cleaned in num erous ways. The recommended procedure is to remove the grid and clean the frame, tubes and angles on front, sides and back with steel wool.
L25-001 REV 1 (11/02) 8. TYPICAL 600 SERIES ILLUSTRATION ( Model RMB 636 shown ) Note: Your unit may vary from this typical diagram..
L25-001 REV 1 (11/02) 8. TYPICAL SMB 600 SERIES ILLUSTRATION (Model SMB 636 shown) Note: Your unit may vary from this typical diagram..
L25-001 REV 1 (11/02) 9. ACCESSORY / PARTS LIST FOR RMB/SMB 600 SERIES MODELS Not all parts are illustrated, nor ar e all parts are listed. If you need a part that is not listed here, call MagiKitch'n for a quote. Always have your model and unit serial numbers available when phoning or ordering.
L25-001 REV 1 (11/02) 10. WARRANTY ORIGINAL EQUIPMENT WARRANTY (For U.S. and Canada) MagiKich’n warrants to each original Buyer that it s electrically-heated or gas-fired charbroilers / outdoor grills will be free from defects in material and workmanship for the period specified below.
L25-001 REV 1 (11/02) card is not returned, then the warranty per iod will be deemed to have commenced on the date of invoice for the particular oven to the dealer or other intermediate customer, which may have the effect of reducing substantially the duration of the warranty period.
L25-001 REV 1 (11/02) P.O. BOX 501 CONCORD NH 03302-0501 509 ROUTE 3A BOW NH 03304 800-258-3708 603-225-6684 FAX 603-225-8497 WWW.PITCO.COM.
An important point after buying a device Magikitch'n 600 SERIES (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Magikitch'n 600 SERIES yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Magikitch'n 600 SERIES - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Magikitch'n 600 SERIES you will learn all the available features of the product, as well as information on its operation. The information that you get Magikitch'n 600 SERIES will certainly help you make a decision on the purchase.
If you already are a holder of Magikitch'n 600 SERIES, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Magikitch'n 600 SERIES.
However, one of the most important roles played by the user manual is to help in solving problems with Magikitch'n 600 SERIES. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Magikitch'n 600 SERIES along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
