Instruction/ maintenance manual of the product 151 Lochinvar
Go to page of 16
Outdoor Knight Boiler User’s Information Manual Models: 151 - 286 If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. This appliance MUST NOT be installed in any location where gasoline or flammable vapors are likely to be present.
2 Hazard definitions The following defined terms are used throughout this manual to bring attention to the presence of hazards of various risk levels or to important information concerning the life of the product.
Outdoor Knight Boiler User’s Information Manual Please read before proceeding The Outdoor Knight Boiler Installation and Operation Manual along with the Outdoor Knight Boiler Service Manual are for use only by a qualified heating installer/service technician.
1 Prevent combustion air contamination 4 If the boiler combustion air inlet is located in a laundry room or pool facility, for example, these areas will always contain hazardous contaminants. To prevent the potential of severe personal injury or death, check for areas and products listed in Table 1 before installing the boiler or air inlet piping.
2 Maintenance schedule 5 Service technician (see the Outdoor Knight Boiler Service Manual) General: • Reported problems • Inspect interior; clean and vacuum if necessary • Clean condensate trap .
2 Maintenance schedule 6 Maintenance procedures Boiler must be serviced and maintained WARNING The boiler must be inspected and started annually at the beginning of the heating season by a qualified service technician.
2 Maintenance schedule (continued) 7 3. Fill with fresh water until the water begins to pour out of the drain. 4. Replace the cap. Press the cap onto the trap until the cap makes contact with the drain. 5. Replace the retaining screw. WARNING The condensate trap (FIG.
2 Maintenance schedule 8 WARNING Have leaks fixed at once by a qualified service technician. Failure to comply could result in severe personal injury, death, or substantial property damage.
9 3 Operating instructions o C Outdoor Knight Boiler User’s Information Manual.
Figure 4 Control Panel Outdoor Knight boiler control module Use the control panel (FIG. 4) to set temperatures, operating conditions, and monitor boiler operation.
11 4 SMART SYSTEM control module (continued) Temperature Units The control can be configured to display temperature in either °F or °C. This parameter can be changed by the user or the installer by accessing the Temperature Units parameter . The default is °F.
12 Status Display Screens Section Display Description A (Boiler Status Bar) STANDBY The unit has not received a call for heat from a remote thermostat nor has it received a call for heat from a DHW thermostat. START The unit has begun a burn cycle and is checking all safety circuits.
4 SMART SYSTEM control module (continued) 13 Status Display Screens (cont’d) Section Display Description C (Operational Information) SYSTEM: The temperature read by the system supply sensor (if connected). TANK: The temperature read by the tank sensor (if connected).
14 4 SMART SYSTEM control module Status Display Screens (cont’d) Section Display Description D (LEFT SELECT key function) MENU Press and hold the LEFT SELECT key for 5 seconds to enter the Menu Screen. EXIT Press the LEFT SELECT key to exit the current screen or setting.
Notes 15 Outdoor Knight Boiler User’s Information Manual.
Revision Notes: Revision A (ECO C11234) initial release. OKB-USER Rev A 10/12.
An important point after buying a device Lochinvar 151 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Lochinvar 151 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Lochinvar 151 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Lochinvar 151 you will learn all the available features of the product, as well as information on its operation. The information that you get Lochinvar 151 will certainly help you make a decision on the purchase.
If you already are a holder of Lochinvar 151, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Lochinvar 151.
However, one of the most important roles played by the user manual is to help in solving problems with Lochinvar 151. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Lochinvar 151 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
