Instruction/ maintenance manual of the product 24763 Keating Of Chicago
Go to page of 26
KEEP THIS MANU AL FOR TRAINING NEW PERSONNEL 1-800-KEA TING www .keatingofchicago.com Part # 024763 Electric Pasta 0709 7/09 CUST OM P AST A ™ SYSTEM ELECTRIC SER VICE MANU AL.
i T his operating, inst allation, and service manual should be given to the user . T he operator of the Custom Past a ™ System should be familiar with the functions and operation of the cooker . T his manual must be kept in a prominent, easily reac hable location near the Past a System.
T ABLE OF CONTENTS 1 SECTION I SPECIFICA TIONS . . . . . . . . . . . . . . 2 SECTION II INST ALLA TION Shipment and T ransit . . . . . . . . . . . . . . . . . . . . . . . .4 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 A.
2 I INTRODUCTION Instructions in this manual should be read thoroughly before attempting to operate this Keating Electric Pasta Cooker . All installation and service on Keating Equipment must be performed by qualified, certified, licensed and/or authorized installation or service personnel.
SAFETY PRECAUTIONS THIS SYMBOL W ARNS YOU THA T SERIOUS BURNS OR OTHER INJURIES MA Y RESUL T IF SAFETY INSTRUCTIONS ARE NOT FOLLOWED. • This service manual should be retained in a safe place for future reference.
4 II INST ALLA TION This Custom Pasta ™ System MUST be installed, inspected, calibrated and serviced by qualified and/or certified and/or licensed service personnel – you may void your Keating warranty if installation is not completed per current local, national and Keating specifications.
5 Push the fryer forward as far as it will go holding the fryer on approximately a 15° angle, and then drop the rear of the past a cooker into its proper position lowering it down gently so you do not deform the table or equipment stand. POSITIONING The past a cooker must be no closer than 6" from any combustible material.
6 In most cases the health department will not allow a direct connection between the cooker drain and the floor receptical. Contact your local health dep artment for specific information in your area.
7 thermostat calls for additional heat at st art up or occasionally when water is added. Follow cooking procedures below for your model. NOTE : Use of sodium chloride during the cooking process will have a detrimental ef fect on the cooker tank and will void the warranty .
8 4. Fill Past a System vessel with water . See page 6 – Filling. UNDER NO CIRCUMST ANCES SHOULD THE P AST A SYSTEM BE LEFT UNA TTENDED DURING BOIL-OUT . TRAINED PERSONNEL MUST BE PRESENT DURING THE PROCEDURE TO PREVENT BOIL OVER OR T O TURN OFF THE POWER IF W A TER DROPS BELOW HEA T TRANSFER TUBES.
9 When the countdown has reached "00:00" the relay output contact s will open, the display will flash, and the audible alarm will sound. T o cancel the audible alarm, press any button. C. P AUSE FEA TURE T o pause a cycle in progress, press any button.
10 every calibration. Position near primary thermostat (center) bulb is recommended. 4. Pre-2000 model: If calibration of thermost at is found to be less than 15°F(9.44°C) off, simply loosen three dial plate retaining screws, rot ate dial plate to match thermometer reading and tighten screws.
V SER VICE DIAGNOSIS THE COOKER MUST BE DISCONNECTED FROM ITS POWER SOURCE OR SHUT DOWN A T THE BREAKER PRIOR TO SER VICE. AUTO-FILL SYSTEM The auto-fill system allows the automatic addition of water to the past a cooker during cooking or idle function.
12 COMMON PROBLEMS SOLUTIONS (FOLLOW IN SEQUENCE) W ater always filling 1. Clean sensors thoroughly with brush and vinegar . 2. Adjust the sensitivity of the B Board (for the top sensor) fully clockwise. 3. If filling persists, ground out the top sensor (if filling stops, replace sensor – Part #010212).
PROBLEM PROBABLE CAUSE SOLUTION Pasta Cooker has poor recovery or runs cold. a. Over-filling baskets. b.Thermostat out of calibration. c. Element is faulty . d. Thermostat is faulty . e. Contactor is faulty . a. Don’t overfill baskets. b. Calibrate thermostat.
VI P ARTS LIST 14 ITEM # DESCRIPTION QTY P ART # 1 INDICA TING LIGHT , AMBER, POWER ON 1 031624 2 TOGGLE SWITCH– MAIN ON-OFF 2 004499 3 INDICA TING LIGHT , GREEN, THERMOST A T HEA TING 2 010682 4 IN.
15 P ARTS LIST FOR CUSTOM P AST A SYSTEM ™ ITEM DESCRIPTION MODELS P ART # 14 18 20 24 1 HEA TING ELEMENT 220V 6500W 14" ONL Y 018668 2 1 HEA TING ELEMENT 220V 6000W 18" & 20" ONL Y 004353 3 3 1 HEA TING ELEMENT 220V 6000W 24” ONL Y 004355 4 (SEE DET AIL - QUANTITIES ARE PER ELEMENT ) B.
16 VII WIRING DIAGRAMS 14" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS) (2).
14" ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM 17.
18 14" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL).
19 14” ELECTRIC P AST A WITH BASKET -LIFT AND DIGIT AL TIMERS WIRING DIAGRAM.
20 18" & 20" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL).
21 18" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS).
22 24” ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM.
L IMITED W ARRANTY Keating Of Chicago, Inc. ("Keating”) warrants to the original purchaser . ("Customer"), all new Keating Fryers, Filter Systems, Griddles, Keep Krisp®, Custom Pasta.
K EA TI N G LI M ITE D W AR RANTY C AR D PLEASE C OM PLETE AN D MAI L A T O NC E–W AR RANTY IS NOT IN E F FE C T U NTI L C AR D I S RETU R N E D. W AR RANTY CARD I S AL S O A V AI LAB LE T O C OM P LETE ON LI N E A T Y OU R C ONVE NIENC E .
An important point after buying a device Keating Of Chicago 24763 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Keating Of Chicago 24763 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Keating Of Chicago 24763 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Keating Of Chicago 24763 you will learn all the available features of the product, as well as information on its operation. The information that you get Keating Of Chicago 24763 will certainly help you make a decision on the purchase.
If you already are a holder of Keating Of Chicago 24763, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Keating Of Chicago 24763.
However, one of the most important roles played by the user manual is to help in solving problems with Keating Of Chicago 24763. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Keating Of Chicago 24763 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
