Instruction/ maintenance manual of the product 1163141 Invacare
Go to page of 60
User Manual EN This manual MUST be given to the user of the product. BEFORE using this product, read this manual and save for future reference. Invacare® Leo™ Scooter.
CONTENTS Invacare® Leo™ Scooter 2 Part No. 116 3141 1 GENERAL 4 Symbols .............. ..................... ......................... ..................... ..................... ......................................... .................... ......
CONTENTS Part No. 1163141 3 Invacare® Leo™ Scooter 8 TILLER ADJUSTMENT 41 Adjusting the Tiller Angle ............................ .......................... ..................... .................... ...... .............................. ..........
1 GENERAL Invacare® Leo™ Scooter 4 Part No. 116 3141 1 General 1.1 Symbols Warnings Signal words are used in this manu al and apply to hazards or unsafe practices which co uld resu lt in personal injury o r property damage. See the information below for definitio ns of the signal words.
1 GENERAL Part No. 1163141 5 Invacare® Leo™ Scooter 1.2 Lim ited Warranty This warranty is extended onl y to the original purchaser/user o f our products. This warranty gives you specific legal rights and you ma y also have other legal rights w hich vary from state to state.
2 SAFETY Invacare® Leo™ Scooter 6 Part No. 116 3141 2 Safety The Safety section contains important information for the safe operatio n and use of this product.
2 SAFETY Part No. 1163141 7 Invacare® Leo™ Scooter 2.2 O peration Inform ation Setup Driving Transport WARNING Before using the sco oter, verify that the motor is plugged into the harness. WARNING DO NOT operate on roads, streets or highways.
2 SAFETY Invacare® Leo™ Scooter 8 Part No. 116 3141 Follow this procedure for moving the po wered scooter between floors when an elevator i s not available: 1. Remove the occupant from the powered scooter. 2. Disassemble the scooter. Refer to Transporting the Scooter on page 52.
2 SAFETY Part No. 1163141 9 Invacare® Leo™ Scooter Repair or Service Information Safety/Handling of Powered Scooters “Safety and Handling ” of the powered scoote r requires the c lose a tte ntion of the user. Thi s manual points out the most commo n p rocedures and techniques involve d in the safe operation and maintenance.
2 SAFETY Invacare® Leo™ Scooter 10 Part No. 116 3141 To assure stability and prope r operation of your powere d scooter, you MUST, at all times, maintain proper bala nce. Your powered scooter has been designed to remain upright and stab le during no rmal daily activities.
2 SAFETY Part No. 1163141 11 Invacare® Leo™ Scooter WARNING When negotiating ramps, if the throt tle control lever is re le ased while in the forward moti on, the pow ered scooter will roll back approximately one foot before the br ake engages.
2 SAFETY Invacare® Leo™ Scooter 12 Part No. 116 3141 Storage WARNING Scooters that are used by incontinent us ers and/or are frequently e xposed to water may require replacement of electrical components more frequently. RAIN TEST Invacare has tested its powered scooters in accordance with ISO 7176 “Rain Test”.
2 SAFETY Part No. 1163141 13 Invacare® Leo™ Scooter Electrical and Grounding Battery Weight Training Ꮨ WARNING Check to ensure that all electrical connections are secu re at all times. GROUNDING INSTRUCTIO NS DO NOT, under any circums tances, cut or remove the round groun ding prong from any plug used with or for Invacare products.
2 SAFETY Invacare® Leo™ Scooter 14 Part No. 116 3141 Weight Limitation Disposal 2.1 EMI Information Electromagnetic Interference (E MI) From Radio Wave Sources Powered wheelchairs and motorized sco.
2 SAFETY Part No. 1163141 15 Invacare® Leo™ Scooter The sources of radiated EMI can be broadly classified into three types: 1. Hand-held Portable transceivers (trans mitters-receivers with the anten na mounted directly on the transmitting unit.
2 SAFETY Invacare® Leo™ Scooter 16 Part No. 116 3141 WARNING 1) DO NOT operate hand-held transceiv ers (transmitters receivers), such as citi zens band (CB) radios, or turn ON personal communic.
3 PRODUCT LABELING Part No. 1163141 17 Invacare® Leo™ Scooter 3 Product Labeling DO NOT operate the scooter unless the tiller is in the loc k ed position. DO NOT lean against or pull f orward on the tiller while mounting or dismounting the scooter.
3 PRODUCT LABELING Invacare® Leo™ Scooter 18 Part No. 116 3141 The battery wiring label is located on the underside of the top shroud. W ARNING Lights are for increased visibility of user and are NOT intended for use as automobile lights.
4 TECHNICAL DATA Part No. 1163141 19 Invacare® Leo™ Scooter 4 Technical Data 4.1 Typical Product Parameters Overall Dimensions Seat Dimensions Arm Dimensions 3 WHEEL 4 WHEEL Overall Length: 47.
4 TECHNICAL DATA Invacare® Leo™ Scooter 20 Part No. 116 3141 Driving Weight 3 WHEEL 4 WHEEL Speed: 5 mph Maximum Incline Capability : 6° Grade 8° Grade Turning Radius: 47.2 in 52 in 3 WHEEL 4 WHEEL Weight of Product: 173.7 lbs 184 lbs Maximum Weight Limitation: 350 lbs All dimensions are ± .
5 INSPECTION Part No. 1163141 21 Invacare® Leo™ Scooter 5 Inspection 5.1 Safety Inspection Checklists Initial adjustments should be made to suit your personal body s tructure needs and preference.
5 INSPECTION Invacare® Leo™ Scooter 22 Part No. 116 3141 Inspect/Adjust Initially ❑ Ensure powered scooter drives straight (no excessive drag or pull to one side). ❑ Check frame for damage and corrosion. ❑ Ensure that the brake release lever is easy to engage/disengage.
5 INSPECTION Part No. 1163141 23 Invacare® Leo™ Scooter Inspect/Adjust Monthly ❑ Check brake for binding or int erference with travel. ❑ Inspect front wheel/fork asse mbly for proper tension by spinni ng the wheel. The front wheel should come to a gradual stop.
6 OPERATING THE POWERED SCOOTER Invacare® Leo™ Scooter 24 Part No. 116 3141 6 Operating the Powered Scooter 6.1 Control Panel Battery Charge Display The battery charge display is located at the top center of the control panel. When the scooter is turned on, the LEDs on the ba ttery charge display light to indicate the amount of battery charge.
6 OPERATING THE POWERED SCOOTER Part No. 1163141 25 Invacare® Leo™ Scooter Speed Control Knob The speed control knob is located in the center of the control panel. The Turtle icon represents the slowest speed and the Rabb it icon repres ents the fastest speed.
6 OPERATING THE POWERED SCOOTER Invacare® Leo™ Scooter 26 Part No. 116 3141 FIGURE 6.1 Control Pane l Battery Charge Display Horn Status Display Speed Control Knob Left Direction Indicator Ligh.
6 OPERATING THE POWERED SCOOTER Part No. 1163141 27 Invacare® Leo™ Scooter 6.2 Operating the Scooter 1. Before operating the powered scooter, review Control Panel on page 24. 2. Install the batteries. Refer to Removing/Installing th e Batteries on page 48.
6 OPERATING THE POWERED SCOOTER Invacare® Leo™ Scooter 28 Part No. 116 3141 8. Insert the key into the ignition and turn it to the On position. 9. To operate the scooter, depress the throttle contr.
6 OPERATING THE POWERED SCOOTER Part No. 1163141 29 Invacare® Leo™ Scooter FIGURE 6.1 Operating the Scooter 6.3 Engaging/Disengaging the Brake Release Lever The brake release lever manually engages and disengages the brake. The brake release l ever is located under the seat on t he rig ht side.
6 OPERATING THE POWERED SCOOTER Invacare® Leo™ Scooter 30 Part No. 116 3141 When the brake release lever is disengaged and the key is remove d, the powered scoote r can be pushed. The powered scooter canno t b e driven with the brake in the dise ngaged position.
6 OPERATING THE POWERED SCOOTER Part No. 1163141 31 Invacare® Leo™ Scooter Activating/Deactivating the Audible Signals The scooter system emits an audible signal in the following situations: • Lo.
6 OPERATING THE POWERED SCOOTER Invacare® Leo™ Scooter 32 Part No. 116 3141 FIGURE 6.3 Activating/Dea ctivating the Audible Signals Battery Charge Display Left Direction Indicator Lighting Righ.
7 SEAT AND ARMS Part No. 1163141 33 Invacare® Leo™ Scooter 7 Seat and Arms 7.1 Removing/Installing the Seat Removing 1. Pull up the seat lock lever. 2. Turn the seat to one side. 3. Hold the seat assembly firmly by the backrest and the front edge of the seat.
7 SEAT AND ARMS Invacare® Leo™ Scooter 34 Part No. 116 3141 FIGURE 7.1 Remo ving/Installing the Seat Seat Lock Lever Backrest Front Edge of the Seat.
7 SEAT AND ARMS Part No. 1163141 35 Invacare® Leo™ Scooter 7.2 Adjusting Seat Height 1. Remove the seat. Refer to Removing/Installing the Seat on page 33. 2. Pull up to remove the top shroud (Detail “A”) and expose th e seat post and mounting hardware (Detail “B”).
7 SEAT AND ARMS Invacare® Leo™ Scooter 36 Part No. 116 3141 FIGURE 7.2 Adjusting Seat Height DETAIL “C” - SEAT POST MOUNTING HARDWARE Seat Post Frame Tube Mounting Holes Washer Frame Tube M.
7 SEAT AND ARMS Part No. 1163141 37 Invacare® Leo™ Scooter 7.3 Adjusting 90° Seat Swivel 1. Pull up the seat lock lever to unlock the seat. 2. Rotate the seat to the desired position. 3. Release the seat lock lever to lock the se at in the desired position .
7 SEAT AND ARMS Invacare® Leo™ Scooter 38 Part No. 116 3141 7.4 Adjusting the Seat Position Forward/Rearward 1. Pull the seat position lever to disengage the seat. 2. Slide the seat forward or rear ward into the desired position. 3. Release the lever to lo ck the seat in positio n.
7 SEAT AND ARMS Part No. 1163141 39 Invacare® Leo™ Scooter 7.6 Replacing Armrest Pad 1. Remove the mounting screw and washer that secure the arm pad to the arm. 2. Remove the old arm pad. 3. Use the mounting screw and washer to install the ne w arm pad.
7 SEAT AND ARMS Invacare® Leo™ Scooter 40 Part No. 116 3141 7.8 Ins talling the Seat Positioning Strap 1. Locate the mounting bracket (Detail “A”) under the rear of the seat. 2. Secure one side of the seat positioning strap to the mountin g bracket using the bolt and nut (Det ail “B”).
8 TILLER ADJUSTMENT Part No. 1163141 41 Invacare® Leo™ Scooter 8 Tiller Adjustment 8.1 Adjusting the Tiller Angle 1. Pull and hold the tiller adjust ment lever. 2. Move the tiller to the desired position. 3. Release the tiller adjustment lever to lock the til ler into the desired position.
9 WHEELS AND CASTERS Invacare® Leo™ Scooter 42 Part No. 116 3141 9 Wheels and Casters 9.1 Removing/Installing the Drive Wheels Removing 1. Turn power off and remove the key from the ignition. 2. Remove the seat. Refer to Removing/Installin g the Seat on page 33.
9 WHEELS AND CASTERS Part No. 1163141 43 Invacare® Leo™ Scooter Installing 1. Place keystock in cutout on drive shaft as shown in FIGURE 9.1. 2. Install the large washer onto the drive shaft.
9 WHEELS AND CASTERS Invacare® Leo™ Scooter 44 Part No. 116 3141 FIGURE 9.2 Remov ing/Installing the Front Wheels - Four Wheel Models 9.3 Removing/Installing the Front Wheels - Three Wheel Models Removing 1. Turn power off and remove the key from the ignition.
9 WHEELS AND CASTERS Part No. 1163141 45 Invacare® Leo™ Scooter FIGURE 9.3 Removing/Installing the Front Wheels - Three Wheel Mode ls Short Spacer Wheel Bolt Axle Short Spacer Washer Nut Fork.
10 BATTERIE S Invacare® Leo™ Scooter 46 Part No. 116 3141 10 Batteries WARNING Before performing any main tenance adjustment or service, turn po wer off and remove key from igniti on. NEVER allow any of your tools and/ or battery cables to contact both battery terminals at the same time.
10 BATTERIES Part No. 1163141 47 Invacare® Leo™ Scooter 10.1 Recommended Battery Type The powered scooters are de signed to use two 12 vo lt, 36-Amp-hour (36 AH) batteries. Recommended battery type is spi ll proof and requires no maintenance except routine charging.
10 BATTERIE S Invacare® Leo™ Scooter 48 Part No. 116 3141 10.2 Removing/Installing the Batteries Removing 1. Turn power off and remove the key from the ignition. 2. Remove the seat. Refer to Removing/Installing the Seat on page 33. 3. Pull up to remove the rear cover (Detail “A” of FIGURE 10.
10 BATTERIES Part No. 1163141 49 Invacare® Leo™ Scooter FIGURE 10.2 Removing/Ins talling the Batteries DETAIL “A” - PREPARING TO REMOVE BATTERIES Rear Cover Seat DETAIL “B” - BATTERY RE.
10 BATTERIE S Invacare® Leo™ Scooter 50 Part No. 116 3141 10.3 Charging the Batteries 1. Turn the key to the Off position. 2. Move the battery charger port cap t o expose the battery charger po rt. 3. Plug one end of the battery charger cable into the battery charger port.
10 BATTERIES Part No. 1163141 51 Invacare® Leo™ Scooter 6. Unplug the battery charger from the wall outlet. 7. Unplug the battery charger from the sco oter.
11 TRANSPORTING Invacare® Leo™ Scooter 52 Part No. 116 3141 11 Transporting 11.1 Transporting the Scooter Disassembling 1. Turn power off and remove the key from the ignition. 2. Remove the basket. 3. Remove the seat. Refer to Removing/Installin g the Seat on page 33.
11 TRANSPORTING Part No. 1163141 53 Invacare® Leo™ Scooter Assembling 1. Unfold tiller. Refer to Adjusting the Ti ller Angle on page 41. 2. Hold the seat post and align the curved brackets on the fr ont frame assembly with the posts on the rear frame assembly.
12 MAINTENANCE Invacare® Leo™ Scooter 54 Part No. 116 3141 12 Maintenance 12.1 Suggested Maintenance Procedures 1. Before using the powered scooter, make sure all nuts and bol ts ar e tight. Check any parts for damage or wear and replace. Che ck all parts for proper adjustment.
13 TROUBLESHOOTING Part No. 1163141 55 Invacare® Leo™ Scooter 13 Troubleshooting 13.1 General Troubleshooting SYMPTOM PROBABLE CAUSE SOLUTION Limited Driving Distance. Batte ry not charged long enough. Batteries weak, won’t hold charge. Charge batteries overnight or ensure eight hours of charge between use.
13 TROUBLESHOOTING Invacare® Leo™ Scooter 56 Part No. 116 3141 Scooter will not drive. Error Brake release lever disengaged. Batteries require charging. Key not fully plugged in. Charger plugged in. Fuse blown in battery box. Battery connections loose.
13 TROUBLESHOOTING Part No. 1163141 57 Invacare® Leo™ Scooter 13.2 Service Indicator Error Codes For the following table, refer to FIGURE 6.1 on page 26 . FLASH DESCRIPTION SCOOT ER STATUS MEANING 1 Battery Low Scooter continues to drive The batteries are running low.
NOTES Invacare® Leo™ Scooter 58 Part No. 116 3141 Notes.
NOTES Part No. 1163141 59 Invacare® Leo™ Scooter Notes.
Invacare Corporation www.invacare.com USA One Invacare Way Elyria, Ohio USA 44036-2125 800-333-6900 Canada 570 Matheson Blvd E Unit 8 Mississauga Ontario L4Z 4G4 Canada 800-668-5324 © 2011 Invacare Corporation.
An important point after buying a device Invacare 1163141 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Invacare 1163141 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Invacare 1163141 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Invacare 1163141 you will learn all the available features of the product, as well as information on its operation. The information that you get Invacare 1163141 will certainly help you make a decision on the purchase.
If you already are a holder of Invacare 1163141, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Invacare 1163141.
However, one of the most important roles played by the user manual is to help in solving problems with Invacare 1163141. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Invacare 1163141 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
