Instruction/ maintenance manual of the product 560sr Husqvarna
Go to page of 22
Owner ’ s Manual 560sr 532162421 02.17.98 REV.1 VB Printed in U.S.A..
2 Safe Operation Practices for Walk-Behind Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. SAFETY RULES SAFETY STANDARDS REQUIRE OPERATOR PRESENCE CONTROLS TO MINIMIZE THE RISK OF INJURY.
3 T ABLE OF CONTENTS SERVICE AND ADJUSTMENTS ................................. 12 STORAGE .................................................................... 13 TROUBLESHOOTING POINTS ................................... 16 WARRANTY ..................
ASSEMBL Y 4 CAUTION: Do not operate this mower without the discharge guard or an entire approved grass catcher in place. These guards are for your protection and are required by the American National Standards Institute and Consumer Products Safety Commission.
OPERA TION 5 HOW T O USE YOUR LA WN MOWER ENGINE SPEED CONTROL (See Fig. 4) Engine speed is controlled by the throttle control located on the upper handle. • Move lever forward for fast engine speed, starting, and for better grass bagging. • Move lever backward for slow engine speed.
OPERA TION 6 TO EMPTY GRASS CATCHER (See Fig. 7) • To remove grass catcher, release operator presence control bar to stop engine. • Lift up rear door and remove the grass catcher by the handle. • Do not drag the bag when emptying; it will cause unnecessary wear.
OPERA TION 7 BEFORE ST ARTING ENGINE OIL (See Fig. 9) Your lawn mower is shipped without oil in the engine. • Be sure mower is level and area around oil fill is clean. • Remove engine oil cap w/dipstick and fill to the full line on the dipstick. • Use 20 ozs.
OPERA TION 8 MOWING TIPS • For most cutting conditions and better bagging per- formance, the engine speed should be set in the fast position. • Under certain conditions, such as when mowing very t.
9 CUST OMER RESPONSIBILITIES GENERAL RECOMMENDA TIONS The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain mower as instructed in this manual.
CUST OMER RESPONSIBILITIES 10 LA WN MOWER Always observe safety rules when performing any mainte- nance. TIRES • Keep tires free of gasoline, oil, or insect control chemi- cals which can harm rubber. • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage.
11 CUST OMER RESPONSIBILITIES ENGINE Read the maintenance section of your engine manual. LUBRICATION Use only high quality detergent oil rated with API service classification SF ,SG or SH. Select the oil's SAE viscosity grade according to your expected operating temperature.
SER VICE AND ADJUSTMENTS 12 CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS - • Release operator presence control bar. • Make sure the blade and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place where it cannot come in contact with plug.
SER VICE AND ADJUSTMENTS 13 ENGI NE CARBURETOR The carb ureto r has been preset at the facto ry and adjustm ent should not be nec e ssar y . H ow eve r , min or a djustmen t may be required to compensate for differences in fuel, temperature, altitude or load.
STORAGE 14 Immediately prepare your lawn mower for storage at the end of the season or if the unit will not be used for 30 days or more. CAUTION: Never store the lawn mower with gasoline in the tank inside a building where fumes may reach an open flame or spark.
15 TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Does not start 1. Dirty air filter. 1. Clean/replace air filter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Drain tank and refill with fresh clean fuel. 4. Water in fuel. 4. Drain fuel tank and carburetor and refill tank with fresh gasoline.
16 REP AIR P ARTS ROT ARY LA WN MOWER - - MODEL NO. 560sr (954140061A).
17 RE P AIR P ARTS RO T A R Y L A WN MOWER - - MODEL NO . 560sr (954140061A) KEY PART DESCRIPTION NO. NO 37 532150078 Thread Cutting Screw 5/16-18 x 3/4 39 532162442 Handle Bracket Assembly (Left) 40 532162441 Handle Bracket Assembly (Right) 41 532150406 Engine Bolt 44 532162393 Lawn Mower Housing (Incl.
18 REP AIR P ARTS ROT ARY LA WN MOWER - - MODEL NO. 560sr (954140061A).
19 RE P AIR P ARTS RO T A R Y L A WN MOWER - - MODEL NO . 560sr (954140061A) KEY PART DESCRIPTION NO. NO. 1 532162716 Drive Control 2 532147715 Drive Head Kit 3 873031000 Nut, Metric 4 532144929 Screw.
20 KEY P ART NO. NO. DESCRIPTION 1 532148145 Case, Lower 2 532148123 Plate, Detent 3 5321481 18 Support, Fork, Shift 4 532148135 Ball, Detent 5 532148122 Spring, Detent 6 532148132 Support, Fork, Clutch 7 532148093 Key , Woodruf f 8 5321481 14 Axle, Shaft 9 532148095 Ring, 12.
21 SER VICE NOTES.
22 W ARRANTY ST A TEMENT SECTION 1: LIMITED WARRANTY Husqvarna Forest & Garden Company (“Husqvarna”) warrants Husqvarna product to the original purchaser to be free from defects in material an.
An important point after buying a device Husqvarna 560sr (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Husqvarna 560sr yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Husqvarna 560sr - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Husqvarna 560sr you will learn all the available features of the product, as well as information on its operation. The information that you get Husqvarna 560sr will certainly help you make a decision on the purchase.
If you already are a holder of Husqvarna 560sr, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Husqvarna 560sr.
However, one of the most important roles played by the user manual is to help in solving problems with Husqvarna 560sr. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Husqvarna 560sr along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
