Instruction/ maintenance manual of the product AR-7EVH Alto-Shaam
Go to page of 44
W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 USA / CANADA FAX: 262.251.7067 • 800.
i Delivery .................................................................... 1 Unpacking ................................................................ 1 Safety Procedures and Precautions .......................... 2 Installation Installation Requirements .
DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section located in this manual.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 2 CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 3 INSTALLATION SITE INSTALLATION In order to maintain established National Sanitation Foundation standards, all counter- mounted models must be sealed to the counter with a R.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 4 INSTALLATION AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 4 SITE INSTALLATION C L Ele.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 5 INSTALLATION The appliance must be installed by a qualified service technician. The oven must be properly grounded in accordance with the National Electrical Code and applicable local codes.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 6 INSTALLATION Attach tray using two carriage bolts in base panel. Lift tray up and away to remove.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 7 INSTALLATION STACKING INSTRUCTIONS A rotisserie with ventless hood can be stacked on top of a matching holding cabinet. Only screws, lock washers, and hex nut are required to fasten units together when stacking a rotisserie on top of a matching holding cabinet.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 8 INSTALLATION DESCRIPTION PART NO. DOOR HANDLE HD-26900 DRIP PAN, stainless steel without drain 1001976 FEET, RUBBER , 2.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 9 START-UP 1. Before operating the unit, become familiar with the operation of the controls. Read this manual carefully and retain it for future reference.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 10 ROTISSERIE CONTROL IDENTIFICATION Cook Cycle Indicator Bar Preheat Indicator Bar Cook Time Indi.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 11 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 11 ITEM CHICKEN, HALVES OR PIECES CHICK.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 12 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 12 1. The COOK and the TIME underscore lights will alternately illuminate.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 13 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 13 HOLD ONLY INSTRUCTIONS 1. The on/off indicator light will illuminate.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 14 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 14 AUTOMATIC HOLDING TIME WILL ACTIVATE. THE ROTISSERIE WILL CONTINUE TO PREHEAT UNTIL THE COOK TEMPERATURE IS REACHED.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 15 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 15 The Alto-Shaam rotisserie provides the operator with the ability to set as many as seven cooking programs.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 16 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 16 WARNING THE CONVECTION FAN CONTINUES TO ROTATE DURING THE COOL DOWN PROCESS.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 17 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 17 STANDARD SPITS Each of the seven rotisserie spits includes two welded prongs on the square end and one welded, ridged prong on the tapered end.
OPERATING INSTRUCTIONS AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 18 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 18 STANDARD SPIT Insert whole chickens with the legs toward the square end of the spit.
CARE AND CLEANING AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 19 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 19 PROTECTING STAINLESS STEEL SURFACES It is important to guard against corrosion in the care of stainless steel surfaces.
CARE AND CLEANING AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 20 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 20 To ensure optimum performance from the ventless hood, it is important to establish and maintain a regular cleaning and maintenance schedule.
CARE AND CLEANING AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 21 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 21 CAUTION METAL PARTS OF THIS EQUIPMENT BECOME EXTREMELY HOT WHEN IN OPERATION.
CARE AND CLEANING AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 22 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 22 It is important to prolong the life of the oven gasket by cleaning this item on a daily basis.
CARE AND CLEANING AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 23 AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 23 SERVICE DANGER DISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 24 Error Code Description Possible Cause E-10 Cavity air sensor shorted Cavity air sensor reading < 5°F. Verify sensor integrity. See sensor test instructions below.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 25 Part numbers and drawings are subject to change without notice. SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 25 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 26 Part numbers and drawings are subject to change without notice. SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 26 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 27 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 27 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 28 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 28 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 29 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 29 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 30 Part numbers and drawings are subject to change without notice. MODEL > CURVED DOOR FLAT DOOR ITEM DESCRIPTION PART NO. QTY PART NO. QTY 1 SPOT ASSEMBLY, TOP PANEL 5009718 1 5009718 1 2 INSULATION, 1" X 4' X 25' #6, RT2300 ( 4.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 31 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 32 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 32 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 33 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 33 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 34 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 34 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 35 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 35 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 36 Part numbers and drawings are subject to change without notice. SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 36 Part numbers and drawings are subject to change without notice.
SERVICE AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 37 Part numbers and drawings are subject to change without notice. AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 37 Part numbers and drawings are subject to change without notice.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 38.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 39.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 40.
AR-7EVH Electric Rotisserie with Ventless Hood Operation & Care Manual • 41.
TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee.
An important point after buying a device Alto-Shaam AR-7EVH (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Alto-Shaam AR-7EVH yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Alto-Shaam AR-7EVH - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Alto-Shaam AR-7EVH you will learn all the available features of the product, as well as information on its operation. The information that you get Alto-Shaam AR-7EVH will certainly help you make a decision on the purchase.
If you already are a holder of Alto-Shaam AR-7EVH, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Alto-Shaam AR-7EVH.
However, one of the most important roles played by the user manual is to help in solving problems with Alto-Shaam AR-7EVH. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Alto-Shaam AR-7EVH along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
