Instruction/ maintenance manual of the product 630025.331 Dometic
Go to page of 10
1 INST ALLA TION & OPERA TING INSTRUCTIONS USA SERVICE OFFICE Dometic Corporation 509 South Poplar Street LaGrange, IN 46761 260-463-4858 CANADA Dometic Distribution 866 Langs Drive Cambridge, Ontario CANADA N3H 2N7 519-653-4390 For Service Center Assistance Call: 800-544-4881 Important: These Instructions must stay with unit.
2 SAFETY INSTRUCTIONS This manual has safety information and instruc- tions to help users eliminate or reduce the risk of accidents and injuries. RECOGNIZE SAFETY INFORMA TION This is the safety-alert symbol. When you see this symbol in this manual, be alert to the potential for personal injury .
3 Model Nominal Electrical Compressor Compressor Fan Motor Fan Motor SC FM -H ig h To tal Refrigerant Minimum AC Circuit Installed Minimum No. Capacity Rating Rated Load Locked Rated Load Locked Sp ee d Static R-22 (Oz.
4 b. For two unit installations: Install one Air Condi- tioner 1/3 and one Air Conditioner 2/3’s from front of RV and centered from side to side. It is preferred that the air conditioner be installed on a relatively flat and level roof section measured with the RV parked on a level surface.
5 C. Roof Preparation 1. Opening Requirements - Before preparing the ceil- ing opening, read all of the following instructions before beginning the installation. If a roof vent opening will not be used a 14-1/4" x 14- 1/4" (±1/8") opening must be cut through the roof and ceiling of the RV.
6 D. Wiring Requirements 1. 120 VAC Supply Line Route a copper 12 AWG, with ground, 120 VAC supply line from the time delay fuse or circuit breaker box to the roof opening. a. This supply line must be located in the front portion of the 14-1/4" x 14-1/4" (±1/8") opening.
7 7. Install ceiling template by sliding lower duct over upper duct. See FIG. 11. If bolts are left loose there may not be an ad- equate roof seal or if over tightened, damage may occur to the air conditioner base or ceil- ing template. Tighten to torque specifications listed in this manual.
8 H. Air Distribution Box Installation 1. Remove the two return air grills and filters. 2. Slide the front end of the air box over the shafts of the thermostat and selector switch. See FIG .13. FIG. 13 Slide Air Box over Controls 3. Install four screws through legs in air box into the pre-punched holes in the ceiling template.
9 630025.331 Installation Instructions 4. Under certain conditions, frost may form on the evaporator coil. If this should occur, inspect the filter and clean if dirty. Make sure air louvers are not obstructed. Air conditioners have a greater ten- dency to frost when the outside temperature is relatively low.
10 UNIT WIRING DIAGRAM AIR BOX WIRING DIAGRAM 3106220.001 ONLY CONDUCTORS USE COPPER USE COPPER 60 HZ 1 PH 60 HZ 1 PH 115 VAC 115 VAC FIELD WIRING FIELD WIRING FACT ORY WIRING FACT ORY WIRING LINE SPL.
An important point after buying a device Dometic 630025.331 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Dometic 630025.331 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Dometic 630025.331 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Dometic 630025.331 you will learn all the available features of the product, as well as information on its operation. The information that you get Dometic 630025.331 will certainly help you make a decision on the purchase.
If you already are a holder of Dometic 630025.331, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Dometic 630025.331.
However, one of the most important roles played by the user manual is to help in solving problems with Dometic 630025.331. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Dometic 630025.331 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
