Instruction/ maintenance manual of the product FAS-10BB Desa
Go to page of 26
Save this manual for future reference. BLUE FLAME VENT -FREE N A TURAL GAS HEA TER OWNER’S OPERA TION AND INST ALLA TION MANUAL F A-10BA, F AS-10BB, and F A-60BA 10,000 and 6,000 Btu/Hr Thermostat a.
2 105564 NA TURAL GAS HEA TER SAFETY INFORMA TION WARNINGS IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, oper- ate, or service this heater. Im- proper use of this heater can cause serious injury or death from burns, fire, explosion, and car- bon monoxide poisoning.
3 105564 OWNER’S MANUAL PRODUCT IDENTIFICA TION Figure 1 - Vent-Free Natural Gas Heater (Model FA-10BA Shown) Control Knob Heater Cabinet Grill Guard Glass Panel Front Panel LOCAL CODES Install and use heater with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code ANS Z223.
4 105564 NA TURAL GAS HEA TER FRESH AIR FOR COMBUSTION AND VENTILA TION WARNING: This heater shall not be installed in a confined space or unusually tight construction unless provisions are provided for adequate combustion and ven- tilation air.
5 105564 OWNER’S MANUAL WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space or if the building is of unusually tight construction, provide adequate combustion and ventilation air by one of the methods described in the National Fuel Gas Code, ANS Z223.
6 105564 NA TURAL GAS HEA TER FRESH AIR FOR COMBUSTION AND VENTILA TION Continued Figure 2 - Ventilation Air from Inside Building Figure 3 - Ventilation Air from Outdoors Ventilation Air From Outdoors Provide extra fresh air by using ventilation grills or ducts.
7 105564 OWNER’S MANUAL For convenience and efficiency, install heater • where there is easy access for operation, inspection, and service • in coldest part of room Figure 4 - Mounting Clearance.
8 105564 NA TURAL GAS HEA TER INST ALLA TION Continued Attaching Mounting Bracket To Wall Note: Wall anchors, mounting screws, and spacers are in hardware package. The hard- ware package is provided with heater. Attaching To Wall Stud Method For attaching mounting bracket to wall studs 1.
9 105564 OWNER’S MANUAL Tee Joint Reducer Bushing to 1/8" NPT 1/8" NPT Plug Tap Figure 13 - Gas Connection * An CSA/AGA design-certified equipment shutoff valve with 1/8" NPT tap is an acceptable alternative to test gauge connection. Purchase the optional CSA/AGA design- certified equipment shutoff valve from your dealer.
10 105564 NA TURAL GAS HEA TER Gas Meter Control Valve Location Equipment Shutoff Valve CHECKING GAS CONNECTIONS WARNING: Test all gas pip- ing and connections for leaks after installation or servicing. Correct all leaks at once. WARNING: Never use an open flame to check for a leak.
11 105564 OWNER’S MANUAL TO TURN OFF GAS TO APPLIANCE 1. Remove fr ont panel (see Figure 7, page 8). 2. Follow steps 1 thr ough 5 under Light- ing Instructions . 3. With contr ol knob pr essed in, str ike match. Hold match to pilot until pi- lot lights.
12 105564 NA TURAL GAS HEA TER THERMOSTAT MODEL FBS-10BB FOR YOUR SAFETY READ BEFORE LIGHTING A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follo w these instructions exactly . B . BEFORE LIGHTING smell all around the appliance ar ea for gas.
13 105564 OWNER’S MANUAL BURNER FLAME PATTERN Figure 22 shows a correct burner flame pattern. Figure 23 shows an incorrect burner flame pattern. The incorrect burner flame pattern shows yellow tipping of the flame. It also shows the flame higher than 1/2 the glass panel height.
14 105564 NA TURAL GAS HEA TER Note: All troubleshooting items are listed in order of operation. TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. POSSIBLE CAUSE 1.
15 105564 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smo.
16 105564 NA TURAL GAS HEA TER TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone.
17 105564 OWNER’S MANUAL FA-10BA FA-60BA FAS-10BB Btu (Variable) 6,000/10,000 6,000 10,000 Type Gas Natural Only Natural Only Natural Only Ignition Piezo Piezo Piezo Pressure Regulator Setting 3" W.C. 3" W.C. 3" W.C. Inlet Gas Pressure (inches of water) Maximum 10.
18 105564 NA TURAL GAS HEA TER Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealer from whom you purchased this product.
19 105564 OWNER’S MANUAL Baltimore Electric 1348 Dixwell Avenue Hamden, CT 06514-0322 1-800-397-7553 203-248-7553 Parts Department Portable Heater Parts 342 N. County Rd. 400 East Valparaiso, IN 46383-9704 All States 219-462-7441 1-800-362-6951 sales@portableheaterparts.
20 105564 NA TURAL GAS HEA TER FA-10BA 28-2 28-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 32 2 3 19 17 8 9 22 32 31 26 30 27 23 18 28 29 10 21 20 18 30 25 24 22 17 16 13 1 14 15 7 11 12 33 4 5 .
21 105564 OWNER’S MANUAL P ARTS LIST FA-10BA This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
22 105564 NA TURAL GAS HEA TER FA-60BA 25-2 25-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 29 2 3 19 17 8 9 29 28 23 27 24 20 18 25 26 10 18 9 27 22 21 19 17 16 13 1 14 15 7 11 12 30 4 5 7 6 7 7.
23 105564 OWNER’S MANUAL P ARTS LIST FA-60BA This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
24 105564 NA TURAL GAS HEA TER FAS-10BB 27-2 27-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 14 2 3 20 19 14 12 25 8 11 11 13 10 26 22 20 27 28 13 10 24 23 21 19 21 15 1 16 17 7 18 4 5 7 6 7 7 9.
25 105564 OWNER’S MANUAL P ARTS LIST FAS-10BB This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual. KEY PART NO. NO. FAS-10BA DESCRIPTION QTY.
KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
An important point after buying a device Desa FAS-10BB (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa FAS-10BB yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa FAS-10BB - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa FAS-10BB you will learn all the available features of the product, as well as information on its operation. The information that you get Desa FAS-10BB will certainly help you make a decision on the purchase.
If you already are a holder of Desa FAS-10BB, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa FAS-10BB.
However, one of the most important roles played by the user manual is to help in solving problems with Desa FAS-10BB. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa FAS-10BB along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
