Instruction/ maintenance manual of the product EVGL850N Desa
Go to page of 20
Save this manual for future reference. OWNER’S OPERA TION AND INST ALLA TION MANUAL B-VENT DECORA TIVE GAS FIREPLACE ® EVGL850N (NA TURAL) ELECTRONIC IGNITION This appliance may be installed in an aftermarket* manufactured (mobile) home, where not prohibited by state or local codes.
2 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® 29" (737mm) 5/8" (16mm) 15 3 / 8 " (391mm) 9" (229mm) 36" (914mm) 38 1 / 8 " (968mm) 21 3 / 4 " (552mm) 4 7 / .
3 107050 OWNER’S MANUAL Model EVGL850N is a radiant heat decora- tive gas appliance that use an electronic gas control valve with electronic ignition sys- tem. A 5” B-Type venting system and a listed type vent cap are not supplied but are required for proper operation.
4 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® CLEARANCES Minimum clearances to combustibles are: • Back and Sides of Outer Surround: ................ 1/2" min. • Drywall to Sides of Front Face (Nailing Flanges): .. 0" min. • "B" V ent Surfaces: .
5 107050 OWNER’S MANUAL MANTEL CLEARANCES AND WALL DETAILS A combustible mantel shelf maybe installed a maximum 9" (229mm) from the wall and must have a minimum distance of 18" (457mm) above the fireplace opening.
6 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® VENTING INST ALLA TION A B-type venting system must be connected to the appliance for venting to the outside of the building. The following section is provided as a guide to a standard B-type vent installation.
7 107050 OWNER’S MANUAL CHECKING FOR PROPER VENTING After completing and checking the electrical, gas and vent connections, follow the lighting instructions and allow the main burner to run for approximately 5 minutes.
8 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® INST ALLA TION OPTIONAL REMOTE CONTROL INSTALLATION (Model WRC) Note: If using optional wireless hand-held remote control, the wall switch must be in the ON position to be operational. The re- mote control then becomes the switching mechanism for fireplace operation.
9 107050 OWNER’S MANUAL INST ALLA TION Continued Continued WARNING: All gas piping and connections must be tested for leaks after the installation is completed. After ensuring that the gas valve is on, apply a soap and water solution to all connections and joints.
10 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® 4 3 2 1 INST ALLA TION Continued GAS BURNER SUPPLY HOOK-UP 1. Disconnect the burner form the burner mounting flange by removing two screws (see Figure 18). 2. Disconnect the pilot from the burner by removing three screws holding the pi- lot mounting bracket (see Figure 18).
11 107050 OWNER’S MANUAL COMBUSTION AIR KIT MODEL AKGL (OPTIONAL) The outside air kit may be installed on the right side of the fireplace only. The vent can be installed through the outside wall or a ventilated crawl space.
12 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® TO TURN OFF GAS TO APPLIANCE 1. T urn off the wall switch. 2. T urn off all electric po wer to the ap- pliance if service is to be perf ormed. 3. Remove the glass door . 4. Open control access panel.
13 107050 OWNER’S MANUAL OPERA TING GUIDELINES AND MAINTENANCE INSTRUCTIONS WARNING: The logs can be hot. Handle only when cool. PILOT ASSEMBL Y ADJUSTMENT Turn the adjustment screw marked pilot clockwise to decrease or counterclockwise to increase the flame to proper size (see Figure 29).
14 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® TECHNICAL SER VICE You may have further questions about in- stallation, operation, or troubleshooting. If so, contact DESA International’s Techni- cal Service Department at 1-800-323-5190. You can also visit DESA International’s technical services web site at www.
15 107050 OWNER’S MANUAL TROUBLESHOOTING The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control va.
16 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone.
17 107050 OWNER’S MANUAL ACCESSORIES RECEIVER AND HAND-HELD REMOTE CONTROL KIT 00710 (WRC) For all models. Allows the gas log heater to be turned on and off by using a hand-held remote control.
18 107050 VENTED TYPE DECORA TIVE APPLIANCE EVGL850N ® REPLACEMENT PA R T S Continued HEAT LIMIT SWITCH 14519 (105911-01) Should the limit switch need replacing, have a qualified technician replace it (see Wiring Diagram , page 14). The limit switch is located under the top door track on the right hand side.
19 107050 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________.
LIMITED WARRANTY B-VENT FIREPLACE DESA International warrants this product to be free from defects in materials and components for four (4) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions.
An important point after buying a device Desa EVGL850N (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Desa EVGL850N yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Desa EVGL850N - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Desa EVGL850N you will learn all the available features of the product, as well as information on its operation. The information that you get Desa EVGL850N will certainly help you make a decision on the purchase.
If you already are a holder of Desa EVGL850N, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Desa EVGL850N.
However, one of the most important roles played by the user manual is to help in solving problems with Desa EVGL850N. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Desa EVGL850N along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
