Instruction/ maintenance manual of the product 4651330 Char-Broil
Go to page of 16
G1020010801 10-01-08(REV .01) © 2008 Char-Broil, LLC Printed in China • Columbus, GA 31902 • • Assembly Instructions © 2008 Pr oduct Guide Model 4651330 The following are trademarks registered by W .
Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Food Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WARNING CALIFORNIA PROPOSITION 65 1. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer , birth defects, and other reproductive harm.
USE AND CARE Regulator/V alve Cylinder Leak T est For Y our Safety Leak T est Do not use household cleaning agents. OFF - Leak test must be repeated each time LP cylinder is replaced or after storage. - Do not smoke during leak test. - Do not use an open flame to check for gas leaks.
WARNING For Safe Use of Y our Grill and to A void Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly .
CA UTION SPIDER ALERT! If you notice that your grill is getting hard to light or that the flame isn’t as strong as it should be, take the time to check and clean the burner . In some areas of the country , spiders or small insects have been known to create “flashback” problems.
This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of manufacture*.
Key Qty Description Part # A 1 Lid Handle . . . . . . . . . . . . . . . . . . . . . B 1 Lid . . . . . . . . . . . . . . . . . . . . . . . . . . . C 2 Hinge Brackets . . . . . . . .. . . . . . . . . . D 1 Cooking Grate . . . . . . . . . . . . . . . . .
HEA T RESIST ANT SHIELD (G) BOTTOM (H) 1/4-20 x 3/8” SCREW (M) LEG (K) Assembly - Position Heat Shield (G) as shown at right below and place into Bottom (H). - Insert narrow end of Burner (F) through large hole in side of Bottom (H) and rest burner bracket on Shield (G).
Assembly (Con’t.) - Assemble Side Handles (I) to Bottom (H) using two each #10-24 x 3/4” Screws (O), Fiber W ashers (L) and #10-24 Flange Nuts (N) per Handle (I). - Rest the notches on ends of Heat Distribution Plate (E) on Side Handles Screws (O) inside Bottom (H).
Assembly (Con’t.) - Before assembly , inspect Regulator (J) for damage, dirt or debris accumulation. Clean out if present. - With knob , insert Regulator/V alve (J) into end of Burner (F). - Once Regulator/V alve (J) has Burner (F), turn Regulator/V alve (J) to lock in position with knob pointing up.
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Prevention/Solution is turned on. T roubleshooting Possible Cause Problem Burner will not Light. Flames burns out on “LOW”. • Out of Propane • Regulator not fully tightened to cylinder .
13.
14.
NOTES 15.
Char-Broil© , LLC P .O. Box 1240 Columbus, GA 31902–1240 Printed in China.
An important point after buying a device Char-Broil 4651330 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil 4651330 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil 4651330 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil 4651330 you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil 4651330 will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil 4651330, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil 4651330.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil 4651330. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil 4651330 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
