Instruction/ maintenance manual of the product 463250308 Char-Broil
Go to page of 32
THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your grill online at www .
1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CA UTION For residential use only .
463250308 • 3 T ABLE OF CONTENTS For Y our Safety ...................................................2 Grill Service Center ............................................2 Product Record Information...............................2 Installation Safety Precautions.
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve.
WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2.
6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection.
WARNING For Safe Use of Y our Grill and to A void Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly .
Burner Flame Check •Remove cooking grates and troughs. Light burners, rotate knobs from to . Y ou should see a bigger flame in position than seen on . Perform burner flame check on side burner , also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the T roubleshooting Section .
463250308 • 9 Electrode Burner Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. T urn gas off at control knobs and LP cylinder . 2. Remove cooking grates and flame tamers.
Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry .
463250308 • 1 1.
CARE AND CLEANING OF YOUR ST AINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions.
P ARTS LIST – Model No. 463250308 NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However , the method of assembly remains the same. Key Qty Description Part # A 1 Bottom Shelf.
P ARTS DIAGRAM – Model No. 463250308 JJ E PP CC D CCC BB YY A B C L O P Q MMM AA HH QQ DD FFF BBB J I NNN GG FF FF RR AAA WW III OOO QQQ H G Y UU N XX OO MM NN FF U EE K F M R S LL HHH GGG W V T FF .
B 1/4” Lock Washer 1/4-20x3/4” Screw 1/4” Flat W asher ASSEMBL Y – Model 463250308 Right Shelf Handle and Drawer handle Assembly 1 Draw the Drawer out of the right side shelf , make sure using your two hands and push the lock in right directions shown A B and C .
A T abs into Cut-outs And Holes into bulges C 1/4” Lock Washer 1/4-20x1/2” Screw 1/4” Flat Washer 1/4-20x1-1/2” Screw 1/4” Lock Washer 1/4-20x1/2” Screw 1/4” Flat Washer Right and Left S.
T ank Gauge Assembly 3 First, secure t emperature probe the clamp on the left side panel show A . Make the gauge wire go through the hole on the left side shelf and insert to the tank gauge show B and C .
Side Burner Assembly 4 Correct Alignment A Burner T ube side burner V alve D #10-24x3/8” Screw #10 Lock Washer 5mm Silicon washer #10-24x3/8” Screw #10 Lock Washer 5mm Silicon Washer Insert back o.
side burner Control Knob Assembly A Control Knob side burner Bezel Fasia side burner Shelf V alve Stem #8 Lock Washer #8-32x3/8” Screw Position side burner valve bracket beneath side burner shelf fascia so that valve stem comes through larger center hole in fascia shown A .
Side burner Wind Diverter , Side burner Cap and Clip, side burner Grate, Griddle 6 463269806 • 17 Locked Position B Electrode Burner Cap Side burner Cooking Grate A Diverter Clip Place side burner wind diverter over side burner aligning cut- out Place burner cap onto side burner and attach side burner cap clip shown B .
Fireb ox bl ed Rack T rough Install 7 First, place T rough Middle onto Firebox show A. Second, place two T rough Assy onto Firebox. Make sure this is put in the right direction as show in B.
ox bl ed Rack Cooking Grate Swing away Cooking Grate and Swing away 8 Place cooking grates onto the firebox as shown. Place the S wing away onto the the firebox.
LP T ank . T ank Screw at bottom of slide bracket CA UTION LP T ank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire. 12 Always keep LP tank in upright position during use, transport, and storage.
Battery Cap Battery Positive(+) side up towards Cap + - 13 Electronic Ignition Unscrew electronic ignition cap on left side panel. Insert AA battery into ignitor , negative (—) end first .
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection.
Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)).
T roubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when control knob turned to ; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when control knob turned to ; noise can be heard from spark module.
LIMITED W ARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
Mail to: / Envíelo a: Consumer W arranty Service P . O. Box 1240 Columbus, GA 31902-1240 Thank you for completing this questionnaire. Y our answers will help us and other companies reach you with of fers that may interest you. If you prefer not to receive these offers, please check here .
This Page Intentionally Blank 30 • 463250308.
This Page Intentionally Blank 463250308 • 31.
ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-888-430-7870 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual.
An important point after buying a device Char-Broil 463250308 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil 463250308 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil 463250308 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil 463250308 you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil 463250308 will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil 463250308, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil 463250308.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil 463250308. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil 463250308 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
