Instruction/ maintenance manual of the product 463250108 Char-Broil
Go to page of 28
THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your grill online at www.
2 • 463250108 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CA UTION For residential use only.
T ABLE OF CONTENTS F o r Y o u r S a f e t y ......................................2 G r i l l S e r v i c e C e n t e r ...................................2 P r o d u c t R e c o r d I n f o r m a t i o n ............................2 Installation Safety Precautions .
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve.
WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2.
6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection.
WARNING For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly .
Burner Flame Check • Remove cooking grates and troughs. Light burners, rotate knobs from to . Y ou should see a smaller flame in position than seen on . Perform burner flame check on sideburner , also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the T roubleshooting Section .
CA UTION Storing Your Grill • Clean cooking grates. • Store in dry location. • When LP cylinder is connected to grill, store outdoors in a well- ventilated space and out of reach of children. • Cover grill if stored outdoors. Choose from a variety of grill covers offered by manufacturer .
10 • 463250108 Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry .
463250108 • 1 1 CARE AND CLEANING OF YOUR ST AINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions.
P ARTS LIST – Model No. 463250108 12 • 463250108 Key Qty Description Part # A 1 Bottom Shelf . . . . . . . . . . . . . . . . . . . . . 80016149 B 2 Caster Assy W/Lock . . . . . . . . . . . . . . . 80000268 C 2 Caster Assy . . . . . . . . . . . . .
463250108 • 13 P ARTS DIAGRAM – Model No. 463250108 JJ J E ZZ G Y EEE Z VV UU WW T DDD GG FF PP RR U TT LL NN I II YY D FFF CCC BB CC K X A B C F L M O P Q R S FF FF DD DD SS SS AA HH KK KK KK MM .
Right and Left Shelf Assembly 1 A Towel Bar Right Side Shelf 1/4” Flat Washer C Tabs into Cut-outs And Holes over Bulges D B 1/4-20x3/4” Screw 1/4” Flat Washer 1/4” Lock Washer 1/4-20x1-1/2”.
Sideburner Assembly 2 Correct Alignment A Burner Tube Sideburner Valve C D #10-24x3/8” Screw #10 Lock Washer 5mm silicon washer #10-24x3/8” Screw #10 Lock Washer 5mm Silicon Washer Insert the side burner into the cut-out shown C , place the side burner on support bracket, align and insert these stud into installation holes of bracket.
Sideburner Control Knob Assembly A Control Knob Sideburner Bezel Fasia Sideburner Shelf Valve Stem Position sideburner valve bracket beneath sideburner shelf fascia so that valve stem comes through larger center hole in fascia shown A . Attach sideburner bezel to fascia using two #8-32x3/8” screws shown A .
Sideburner Wind Diverter, Sideburner Cap and Clip, Sideburner Grate 4 463269806 • 17 Locked Position B Eletctode Burner Cap Sideburner Cooking Grate A Diverter Clip 34 Place sideburner wind diverter over sideburner aligning cut- out in diverter to fit around electrode shown A .
ox Trough Install 5 bl ed Rack Trough A Trough B First, place T rough Middle onto Firebox shown A . 18 • 463250108 Trough Middle Front Rear Rear F ront Second, Place T rough A and T rough B onto Firebox. Make sure this is put in the right direction as show in B.
Cooking Grate and Warming Rack 6 bl ed Rack 463250108 • 19 Place cooking grates onto the firebox as shown. Place the Warming Rack onto the the firebox.
7 Condiment Basket Assembly Open the door and place the Condiment Basket on the left door inside, make sure the insert the pivots of the Condiment Backet into the bracket which riveted together the door inside shown as below.
Battery Cap Battery Positive(+) side up towards Cap + - 8 Electronic Ignition 463250108 • 21 Unscrew electronic ignition button left side panel of cart.
LP Tank . Tank Screw at rear of cart CA UTION LP Tank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire. 9 Always keep LP tank in upright position during use, transport, and storage.
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection.
Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback.
463250108 • 25 Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when control knob turned to ; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when control knob turned to ; noise can be heard from spark module.
LIMITED W ARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
Mail to: / Envíelo a: Consumer W arranty Service P . O. Box 1240 Columbus, GA 31902-1240 Thank you for completing this questionnaire. Y our answers will help us and other companies reach you with of fers that may interest you. If you prefer not to receive these offers, please check here .
ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-888-430-7870 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual.
An important point after buying a device Char-Broil 463250108 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil 463250108 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil 463250108 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil 463250108 you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil 463250108 will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil 463250108, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil 463250108.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil 463250108. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil 463250108 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
