Instruction/ maintenance manual of the product 10201600 Char-Broil
Go to page of 16
Product Guide Model 10201600 T ools needed for assembly: Pliers Adjustable wrenches FOR OUTDOOR USE ONL Y CA UTION: Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook. INST ALLER/ASSEMBLER: Leave this manual with consumer .
D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury .
1. Brush all interior surfaces including grills and grates with vegetable cooking oil. 2. Build a small fire on the fire grate, being sure not to lay coals against the walls. 3. Close door . (Position butterfly damper and smokestack damper approximately at one quarter open.
THE HEA T OF THE COALS seconds you can hold the palm of your hand 4 inches above the coals temperature range (Fº) visual cues HOT COALS 2 400 to 450 barely covered with gray ash; deep red glow MODERA.
GRILL MAINTENANCE Frequency of cleanup is determined by how much your smoker is used. Make sure coals are completely extinguished before cleaning inside of smoker . Inside surfaces may be cleaned with a strong solution of detergent and water applied with a scrub brush.
LIMITED W ARRANTY 6 SCOPE OF COVERAGE PERIOD OF COVERAGE TYPE OF F AILURE COVERAGE PERFORA TION, MANUF ACTURING, AND MA TERIAL DEFECTS ONL Y All Parts 90 days from date of purchase* This warranty only applies to units purchased from an authorized retailer .
Key Qty Description A 1 Axle B 1 Pull Handle C 3 Wire Fire Grate D 1 Firebox Door Latch E 2 Large Cast Iron Cooking Grate F 1 Small Cast Iron Cooking Grate G 1 Smoke Chamber Assembly H 1 Firebox Assem.
2 1 ASSEMBL Y 8 FIRST , GET A HELPER! This unit is heavy and requires a second person for lifting and moving. NEXT , pick a suitable location to work. Open the carton and slit the corners so that the carton lays flat. This will give you a protective surface during assembly .
3 4 9 Attach short legs to remaining leg sockets near firebox using 3/8-16x3/4” hex-head bolts . Do not fully tighten. T ighten bolt just enough to keep leg from sliding off of socket . With unit still in position from previous steps, insert long legs over leg sockets closest to the floor .
5 6 10 Insert hitch pin through the hole at one end of the axle. Slide a 7/16" flat washer onto the axle, then a wheel, then another 7/16" flat washer .
8 7 1 1 Insert a Hitch Pin into the hole at one end of an axle rod. Hold handle between handle brackets on smoke chamber door and slide rod through brackets and handle. Insert another Hitch Pin at opposite end of handle rod. Repeat these steps to assemble handle to firebox door .
10 9 12 Attach the smokestack to the left side of the smoke chamber by sliding smokestack into receiver tube. Secure smokestack in vertical position using one hexhead bolt. 3/8-16x1” Slide the pull handle into the bushings on the left side of the smoke chamber .
1 1 12 13 Attach front shelf to smoke chamber by sliding ends of shelf frame into bushing on front of smoke chamber . Front Shelf Place one fire grate in the bottom of the firebox and the two remaining fire grates in the bottom of the smoke chamber .
14 NOTES.
.
20 REGTEMP REV00.
An important point after buying a device Char-Broil 10201600 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil 10201600 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil 10201600 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil 10201600 you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil 10201600 will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil 10201600, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil 10201600.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil 10201600. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil 10201600 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
