Instruction/ maintenance manual of the product 10201598 Char-Broil
Go to page of 16
Product Guide Model 10201598 Estimated Assembly Time: 1 Hour T ools needed for assembly: Phillips Screwdriver Flat Head Screwdriver T wo adjustable wrenches Hammer FOR OUTDOOR USE ONL Y CA UTION: Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook.
D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury .
Page 3 1. Brush all interior surfaces including grills and grates with vegetable cooking oil. 2. Build a small fire on the fire grate, being sure not to lay coals against the walls. 3. Close door . (Position butterfly damper and smokestack damper approximately at one quarter open.
Page 4 THE HEA T OF THE COALS seconds you can hold the palm of your hand 4 inches above the coals temperature range (Fº) visual cues HOT COALS 2 400 to 450 barely covered with gray ash; deep red glow.
Page 5 GRILL MAINTENANCE Frequency of cleanup is determined by how much your smoker is used. Make sure coals are completely extinguished before cleaning inside of smoker . Inside surfaces may be cleaned with a strong solution of detergent and water applied with a scrub brush.
This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer -purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*.
P ARTS LIST Page 7 Key Qty Description 1 1 Smoker Chamber Lid Assembly 2 1 T emperature Gauge with Wingnut 3 1 Smoke Stack Assembly 4 1 Logo Plate Kit 5 2 Handle Assembly 6 2 Hinge Kit 7 2 Smoker Cham.
2 1 ASSEMBL Y Page 8 2 1 FIRST , GET A HELPER! This unit is heavy and requires a second person for lifting and moving. NEXT , pick a suitable location to work. Open the carton and slit the corners so that the carton lays flat. This will give you a protective surface during assembly .
3 4 Axle Wheel Hitch Pin Firebox Lid Firebox Bottom Figure A Figure B Axle Hitch Pin Hitch Pin Wheel Legs with holes • Slide axle into holes at ends of legs (legs without end caps). • Attach wheels onto axle rod using hitch pins. Hitch pins insert through hole in axle as shown in box A.
Page 10 5 • Place unit in upright position. • Attach small hinge half to smoker chamber using two #10-24 X 1/2” screws and two #10-24 flange nuts for each hinge half.
Page 1 1 7 • Insert two #10-24 X 3-1/2” screws into handle and place spacers and fiber washer onto screws on other side of handle. • Place the handle assembly into the holes on the front of the smoker chamber door and secure with two #10-24 flange nuts.
10 Page 12 9 • Attach shelf support to side of smoker chamber with one #10-24 X 1/2” machine screw where screw is going through inside of chamber through hole of support and secured with one #10-24 flange nut. • Lay side shelf on top of other end of shelf support so that it fits inside holding bracket.
12 11 Page 13 The assembly is completed. • Place two Smoker Chamber Cooking Grates into the smoker chamber . • Place the Firebox Cook Grate into the Firebox. Smoker Chamber Firebox Firebox Cook Grate Smoker Chamber Cook Grates • Hang the grease clip under the smoker chamber on right side.
HARD WARE LIST Y ou may have spare hardware after assembly is complete. Page 14 Hinge Pin Qty . 2 Qty . 4 Hair Pin Clip Logo Clip Qty . 2 Fiber W asher Qty . 4 1/4-20 Flange Nut Qty . 14 #10-24 Flange Nut Qty . 25 Hardware not shown actual size. #6-32 X 3/8” Machine Screw Qty .
.
REGTEMP REV02 W arranty Registration Department P .O. Box 1240 Columbus, GA 31902-1240.
An important point after buying a device Char-Broil 10201598 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Char-Broil 10201598 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Char-Broil 10201598 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Char-Broil 10201598 you will learn all the available features of the product, as well as information on its operation. The information that you get Char-Broil 10201598 will certainly help you make a decision on the purchase.
If you already are a holder of Char-Broil 10201598, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Char-Broil 10201598.
However, one of the most important roles played by the user manual is to help in solving problems with Char-Broil 10201598. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Char-Broil 10201598 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
