Instruction/ maintenance manual of the product 6300 Cal Spas
Go to page of 52
L TR20081000, Rev . B 1/28/08.
Copyright 2007-2008 Lloyds Material Supply , Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Spas ® , Adjustable Therapy System™, A TS™, Bio-Clean™, Cal Zone Quest 2000™, Cal Premium™, Cal Select™, Cal Stone™ Ultimate Fitness Spa Series™, and XL Heat Exchanger™ are registered trademarks.
2008 Portable Spa Owner ’s Manual Page 1 L TR20081000, Rev . B Read This First! Read This First! Important Safety Instructions When installing and using this electrical equipment, always follow basic safety precautions. Following these instructions will help make your rst spa session a pleasurable one.
Page 2 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Read This First! jets, which will relax even the tightest muscles. In addition to the water pressure, you can add air into the spa water with air venturi handles located seat-side that increase the intensity of your massage.
2008 Portable Spa Owner ’s Manual Page 3 L TR20081000, Rev . B Preparing for Y our New Portable Spa Preparing for Y our New Portable Spa Most cities and counties require permits for exterior construction and electrical circuits.
Page 4 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Preparing for Y our New Portable Spa 120 V olt Electrical Installation Always follow applicable local, state and federal codes and guidelines. Use only a dedicated electrical line with a 20 amp breaker .
2008 Portable Spa Owner ’s Manual Page 5 L TR20081000, Rev . B Preparing for Y our New Portable Spa Spa Model GFCI Required Wires Required All 240V spas (except 6300 control boxes requiring high amp.
Page 6 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Preparing for Y our New Portable Spa GFCI Wiring Diagram.
2008 Portable Spa Owner ’s Manual Page 7 L TR20081000, Rev . B Preparing for Y our New Portable Spa Gas Heater Hook up Ultimate Fitness Series spa owners may buy and install a separate gas heater and pump for use with their spa. This option may be purchased separately from your local distributor .
Page 8 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Preparing for Y our New Portable Spa.
2008 Portable Spa Owner ’s Manual Page 9 L TR20081000, Rev . B Preparing for Y our New Portable Spa Filling and Powering Up Y our Portable Spa Never ll your spa with soft water .
Page 10 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Operating Y our Spa Operating Y our Spa 5100, 6200 and 6300 Electronic Control Operation Initial Start up When rst powered up, it will automatically revert to Priming mode. A Pr on the topside display will indicate this.
2008 Portable Spa Owner ’s Manual Page 1 1 L TR20081000, Rev . B Operating Y our Spa Light Press the Light button to turn on the light. Press it once again to turn the light off. All optional lighting such as the control panel light and cabinet perimeter lighting is controlled by the Light button and will turn on and off with the spa light.
Page 12 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Operating Y our Spa HL A difference in readings between temperature sensors has been detected indicating a possible water ow problem. Make sure spa is lled to proper level and that pumps are primed (water is owing).
2008 Portable Spa Owner ’s Manual Page 13 L TR20081000, Rev . B Operating Y our Spa When rst powered up, the 9800 electronic system will perform a self-diagnostic check and then it will automatically heat to and maintain a temperature of 100°F (37.
Page 14 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Operating Y our Spa Jets 2 Press the “JETS 2” button once to turn pump 2 on or of f and to shift between low and high speeds if it is a two- speed pump. If left running, the pump will turn of f after 15 minutes.
2008 Portable Spa Owner ’s Manual Page 15 L TR20081000, Rev . B Operating Y our Spa Periodic Reminder Messages Press the “Mode” button to reset a displayed reminder . Message Frequency Action Required rPH Every 7 days T est and adjust chemical levels per manufacturer ’s instructions.
Page 16 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Operating Y our Spa Message Meaning Action Required LF Persistent low ow problems. (Displays on the fth occurrence of the HFL message within 24 hours.) Heater is shut down, but other spa functions continue to run normally .
2008 Portable Spa Owner ’s Manual Page 17 L TR20081000, Rev . B Operating Y our Spa Auxiliary Control Operation The auxiliary control option is available with the 9800 controls only . It is a small panel with four buttons that control certain spa functions, such as primary or additional jets, TV , or lights.
Page 18 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Operating Y our Spa Adjustable Jets Almost all of the jets in your spa are adjustable. Rotating the face of an adjustable jet to the left (counter- clockwise) will decrease the amount of water ow through the jet.
2008 Portable Spa Owner ’s Manual Page 19 L TR20081000, Rev . B Operating Y our Spa Adjustable Therapy System™ Pump On/Off This button allows the user to turn on and off the A TS™ seat pump. Press this button once to turn the pump on. Once on, the green LED light on the control panel will illuminate, indicating that the system is operational.
Page 20 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B W ater Quality Maintenance W ater Quality Maintenance Cal Spas Clear W ater Plan Great spa water is easily achieved when the right chemicals and / or systems are used and the Cal Spas Clear W ater Plan is implemented.
2008 Portable Spa Owner ’s Manual Page 21 L TR20081000, Rev . B W ater Quality Maintenance Bather Load “Bather Load” is the term used to describe the number of people using a spa, combined with the length of usage, and the frequency of usage. All these factors have a great effect on the spa water .
Page 22 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B W ater Quality Maintenance Chemical Descriptions The following descriptions and recommendations are intended for use with Cal Spas chemicals only . Many of these chemicals will be used with alternative sanitation systems as well.
2008 Portable Spa Owner ’s Manual Page 23 L TR20081000, Rev . B W ater Quality Maintenance For use with the chlorine Clear W ater Plan Chlorinating Granules Quick acting sanitizer / disinfectant for spa water . T est Strips – Chlorine Provides accurate spa water testing for bromine, pH, and total Alkalinity .
Page 24 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B W ater Quality Maintenance T raditional Chemical Start Up Prior to lling a spa for the rst time, or after a routine draining, you will want to follow this start-up plan to extend water life and performance.
2008 Portable Spa Owner ’s Manual Page 25 L TR20081000, Rev . B W ater Quality Maintenance Chlorine Clear W ater Plan This plan and its chemical dosages are intended for Cal Spas chemicals only . Most chemical manufacturers use different chemical formulas and strengths.
Page 26 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B W ater Quality Maintenance Place your extra clean lter cartridge back into the spa. V acuum debris from the bottom of your spa with the spa vacuum. Day T wo (Friday) T est spa water using chlorine test strips.
2008 Portable Spa Owner ’s Manual Page 27 L TR20081000, Rev . B W ater Quality Maintenance Use sodium bromide test strips (not bromine) and adjust sodium bromide level to 7.4 to 8.2 (equates to 1700 to 2500 ppm TDS level). Add 2 oz of Cal Spas “Oxidizer Shock” to help burn out impurities in ll water .
Page 28 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Cleaning and Maintenance Cleaning and Maintenance Removing and Reseating the Pillows Y ou can remove the pillows for cleaning and maintenance quickly and easily . This method works for all types of pillows.
2008 Portable Spa Owner ’s Manual Page 29 L TR20081000, Rev . B Cleaning and Maintenance Draining Y our Portable Spa Y our spa should be drained every four to six months, and relled with fresh tap water . The following is the recommended method for draining your spa.
Page 30 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Cleaning and Maintenance All-Purpose Cleaner (Spa Finish cleaning) Cal Spas™ All-Purpose Cleaner is an essential part of maintaining your spa’s nish. Through normal use, the spa’s nish can accumulate dirt, oil, and calcium causing a rough feel and unsightly scum lines.
2008 Portable Spa Owner ’s Manual Page 31 L TR20081000, Rev . B Cleaning and Maintenance based wax that is specically formulated to protect the spa’s nish from the chemicals and minerals associated with normal spa use. The most effective solution to minimize cleaning time is prevention.
Page 32 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Entertainment System Some spas may be equipped with audio/visual entertainment options. Several options are available and include marine grade CD players, DVD players, and an iPod ® docking station.
2008 Portable Spa Owner ’s Manual Page 33 L TR20081000, Rev . B Entertainment System Use the remote control to navigate the DVD menu using the fast forward and fast reverse buttons located at the lower part of the universal remote. T o remove the disc, press the OPEN button on the DVD player .
Page 34 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Entertainment System Programming the Universal Remote Control The Cal Spas universal remote has been pre- programmed to function with the entertainment system the spa has been congured with.
2008 Portable Spa Owner ’s Manual Page 35 L TR20081000, Rev . B Appendix Appendix Replacement Parts Jet T ype Description Standard Gray Face Stainless Steel Face CXL W 6.
Page 36 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Appendix MJL W 6.5”, POWER STORM JET , DIRECTIONAL PLU21703422 PLU21703625 MJW 5.5”, POWER STORM JET , DIRECTIONAL PLU21703423 PLU21703600 MNW 2.
2008 Portable Spa Owner ’s Manual Page 37 L TR20081000, Rev . B Appendix SXW 5.5”, POWER STORM JET , SWIRLEY PLU21703424 PLU21703623 TW 4.75”, POWER SWIM JET TORNADO PLU21703428 PLU21703629 W WH.
Page 38 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Appendix V alves PLU21300052 DIVERTER V AL VE 1” (2 W A Y) SIL VER, TEARDROP HANDLE (2 TONE) PLU21300062 DIVERTER V AL VE 2” (2 W .
2008 Portable Spa Owner ’s Manual Page 39 L TR20081000, Rev . B Appendix Filters FIL1 1 100190 FIL TER CARTRIDGE, 50 SQ FT . ANTI-BACTERIAL RED FIL1 1 100191 FIL TER CARTRIDGE, 75 SQ FT . ANTI-BACTERIAL WHITE FIL1 1 100193 FIL TER CARTRIDGE, 35 SQ FT .
Page 40 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Appendix Covers Standard Rust 5 to 3 Part No. Description Series ACC01200420 SP A COVER STD Aqua Series ACC01200407 SP A COVER STD A v.
2008 Portable Spa Owner ’s Manual Page 41 L TR20081000, Rev . B Appendix Deluxe Rust 5 to 3 Part No. Description Series ACU02200210 SP A COVER UL C - B ACU02200220 SP A COVER UL C - K ACU02200364 SP.
Page 42 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Appendix Deluxe Slate 5 to 3 Part No. Description Series ACU02200216 SP A COVER UL C - B ACU02200225 SP A COVER UL C - K ACU02200368 S.
2008 Portable Spa Owner ’s Manual Page 43 L TR20081000, Rev . B Appendix Keeping Fit with your Spa IMPORT ANT : Always consult your physician before starting any exercise activity or program. The Ultimate Fitness series spas feature rubber exercise bands.
Page 44 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B Appendix Connecting the Exercise Equipment The drawings below show different ways the exercise kit can be connected depending on the exercises you wish to do.
2008 Portable Spa Owner ’s Manual Page 45 L TR20081000, Rev . B Appendix Cal Spas™ Chemicals.
2008 W arranty U.S. and Canada Portable Spas This limited warranty is effective for portable spas manufactured after January 14, 2008 Manufacturer W arranty All Cal Spas hot tubs are manufactured with the highest quality appliances and are warranted to be free from defects in material and workmanship at the time of delivery .
2008 Portable Spa Owner ’s Manual Page 47 L TR20081000, Rev . B Appendix See your Cal Spas™ dealer for a copy of the applicable warranty , details, and any questions you may have regarding the warranty coverage on your spa.
Page 48 2008 Portable Spa Owner ’s Manual L TR20081000, Rev . B.
2008 Portable Spa Owner ’s Manual Page 49 L TR20081000, Rev . B.
Locating the product serial number The serial number of your spa is located on a metal plate attached to the lower right front panel of the spa.Y ou will need this number to properly register your spa and activate coverage. Write this information in the space provided below .
An important point after buying a device Cal Spas 6300 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Cal Spas 6300 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Cal Spas 6300 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Cal Spas 6300 you will learn all the available features of the product, as well as information on its operation. The information that you get Cal Spas 6300 will certainly help you make a decision on the purchase.
If you already are a holder of Cal Spas 6300, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Cal Spas 6300.
However, one of the most important roles played by the user manual is to help in solving problems with Cal Spas 6300. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Cal Spas 6300 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
