Instruction/ maintenance manual of the product HBZ2601-CA Zenoah
Go to page of 52
W ARNING OWNER / OPERA T OR MANUAL MODE D’EMPLOI MANUAL DE INSTRUCCIONES BLOWERS SOUFFLEURS AT OMIZADOR 848-L0G-93A2 (801) HBZ2601 HBZ2601-CA The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
2 SAFETY FIRST Instructions contained in warnings within this manual and warning seals marked with a symbol on the blower concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail.
3 SECURITE Les instructions contenues dans les mises en garde de ce mode d’emploi portant le symbole concernent les points critiques qui doivent être pris en considération pour éviter les blessures graves, c’est pourquoi ces précautions doivent être rigoureusement suivies.
4 1. Parts location English English ■ MODEL HBZ2601/HBZ2601-CA Dimensions (L x W x H) mm (in) ···············································································327x269x360 (12.
5 1. Emplacement des pieces 1. Situación de las piezas Français Español (1) Commutateur d'arret (2) Gâchette de la commande de vitesse (3) Grille d'admission d'air (4) Bouchon de bo.
3. W arning labels on the machine 6 English For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to make a mistake.
Para un uso y mantenimiento seguro, se han estampado símbolos en relieve en la máquina. Observe siempre estas indicaciones y tenga cuidado de no cometer un error.
8 1. Read this Blower Owner/Operator Manual carefully. Be sure you understand how to operate this unit properly before you use it. Failure to do so could result in serious injury. 2. Be sure to keep this manual handy so that you may refer to it later whenever any questions arise.
9 1. Lea detenidamente el “Manual del propietario/operador” de este soplador. Asegúrese de comprender la forma de uso correcta de este aparato antes de usarlo. De lo contrario, podrá sufrir graves lesiones. 2. Asegúrese de guardar este manual en un lugar cercano y accesible, de modo que pueda consultarlo cada vez que tenga una duda.
10 vibration are mentioned as factors. In order to reduce the risk of whitefinger disease, the following precautions are strongly recommended; a) Keep your body warm. Never use blower during rains. b) Wear thick anti-vibration gloves. c) Take more than 5 minutes of break in warm place frequently.
symptômes sont une sensation de picotement et de brûlure suivis de la décoloration des doigts et de leur engourdissement. Cette maladie est mal connue, mais il semblerait qu’elle soit provoquée entre autres par le froid, les maladies du tabac ou l’état physique ou encore une exposition prolongée aux vibrations.
12 4. Check your equipment before operation, especially the muffler, air intakes and air filters. ■ WORKING PLAN • When planning your work schedule, allow plenty of time to rest.
13 3. Travaillez au régime le plus bas possible de votre soufflante à amplificateur de puissance. 4. Vérifiez votre appareil avant de l’utiliser, notamment le silencieux, les arrivées d’air et les filtres à air. ■ PLAN DE TRAVAIL • Lorsque vous tracez votre plan de travail, prévoyez suffisamment de pauses.
14 the engine is running. Contact with rotating blower fan may result in a serious personal injury. (1) Screw (2) Air inlet screen ■ USING THE PRODUCT 1. Check the work area that the blower will be used in and remove or cover all valuables that may be damaged by the air blast or thrown debris.
15 •N e jamais retirer de débris de l’écran d’entrée d’air pendant que le moteur tourne. Tout contact avec le l’hélice tournante du souffleur peut causer de graves blessures. (1) Vis (2) Grille d'admmission d'air ■ UTILISATION DU PRODUIT 1.
16 UP! Dispose of debris in trash receptacles. ■ MAINTENANCE 1. In order to maintain your product in proper working order, perform the maintenance and checking operations described in the manual at regular intervals. 2. Always be sure to turn off the engine and disconnect the spark plug before performing any maintenance or checking procedures.
17 brûler sérieusement. 6. NETTOYEZ la soufflante et les accessoires après usage. Mettez les débris à la poubelle. ■ ENTRETIEN 1. Effectuez régulièrement les interventions d’entretien et les vérifications indiquées dans le manuel afin de garder votre produit en bon état de marche.
18 5. For safe operation English ■ TRANSPORTATION • Drain the fuel from the fuel tank before transporting or storing the blower. • Secure the unit carefully to prevent movement when it is transported. •A unit that receives a strong shock during transport and unloading may malfunction.
19 5. Consignes de securite 5. Instrucciones de seguridad Français Español ■ TRANSPORT • Vidanger le carburant avant de transporter ou stocker la soufflante.
■ FUEL • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m (10ft) away from the fueling point before starting the engine.
■ COMBUSTIBLE • La gasolina es muy inflamable. Evite fumar o producir cualquier llama o chispa cerca del combustible. Asegúrese de detener el motor y dejar que se enfríe antes de repostar la unidad.
22 7. Fuel English ■ HOW TO MIX FUEL Pay attention to agitation. 1. Measure out the quantities of gasoline and oil to be mixed. 2. Put some of the gasoline into a clean, approved fuel container. 3. Pour in all of the oil and agitate well. 4. Pour In the rest of gasoline and agitate again for at least one minute.
23 participer ainsi à la protection de l’environnement et de votre santé. • De l’essence ou de l’huile de basse qualité risque d’endommager les joints, les conduites d’essence ou le réservoir d’essence du moteur. ■ COMMENT OBTENIR UN BON MELANGE Faire attention à ne pas trop remuer le carburant.
24 7. Fuel English FOR YOUR ENGINE LIFE, AVOID; 1. FUEL WITH NO OIL(RAW GASOLINE) – It will cause severe damage to the internal engine parts very quickly. 2. GASOHOL – It can cause deterioration of rubber and/or plastic parts and disruption of engine lubrication.
25 A EVITER POUR PROLONGER LA DUREE DE VIE DU MOTEUR : 1. ESSENCE SANS HUILE (ESSENCE PURE) – L’essence pure est capable d’endommager très rapidement les pièces du moteur. 2. ESSENCE-ALCOOL – Ce mélange risque de très rapidement détruire les pièces en caoutchouc et/ou en plastique et d’empêcher la lubrification du moteur.
26 8. Operation English ■ STARTING ENGINE 1. Rest the unit on a flat, firm place. 2. Pump the primer until fuel flows out in the clear tube. (1) Primer 3. Move the choke lever upward to close the choke. (1) Choke lever (2) Close (3) Open 4. Holding the blower handle, pull the starter rope with your right hand.
27 8. Fonctionnement 8. Uso Français Español ■ DEMARRAGE DU MOTEUR 1. Placer l’appareil sur un endroit plat et solide. 2. Pomper l’amorceur jusqu’à ce que le j carburant s’écoule dans le tuyau clair. (1) Amorceur 3. Déplacer le levier du starter vers le haut pour fermer le starter.
28 8. Operation English ■ STOPPING ENGINE Move the throttle trigger to the idling position and press the stop switch (red button) until the engine comes to a complete stop. (1) Stop switch Except for an emergency, avoid stopping the engine while pulling the throttle trigger.
29 8. Fonctionnement 8. Uso Français Español ■ ARRET DU MOTEUR Déplacer le gâchette de la commande de vitesse sur la position de ralenti et appuyer sur le commutateur d’arrêt (touche rouge) jusqu’à ce que le moteur s’arrête complètement.
30 every every every 25 50 100 system/compornent procedure before hours hours hours note use after after after fuel leaks, fuel spillage wipe out ✔ fuel tank, air filter, fuel filter inspect/clean ✔✔ replace, if necessary see ■ ADJUSTING replace carburetor idle adjusting screw ✔ IDLING SPEED (p.
31 Toutes les Toutes les Toutes les 25 50 100 Système/Composant Procédure Avant heures heures heures Remarque utilisation suivantes suivantes suivantes fuites ou éclaboussures de carburant essuyer .
32 9. Maintenance English Make sure that the engine has stopped and is cool before performing any service to the blower. Contact with rotating blower fan or hot muffler may result in a personal injury. ■ AIR CLEANER • Check the air cleaner every 25 hours of use or more frequently if used under dusty conditions.
33 9. Entretien 9. Mantenimiento Français Español Vérifier que le moteur est arrêté et refroidi avant d’effectuer toute réparation de la soufflerie. Un contact avec le ventilateur de la soufflerie rotative ou avec le tuyau d’échappement risque de provoquer des blessures corporelles.
34 9. Maintenance English •P lug manufacturers recommend replacing the plug twice a year to avoid unexpected plug failure in a job. REPLACEMENT PLUG IS A NGK CMR7H. • Note that using any spark plugs other than those designated may result in the engine failing to operate properly or in the engine becoming overheated and damaged.
35 9. Entretien 9. Mantenimiento Français Español • Les fabricants de bougies recommandent de remplacer la bougie deux fois l’an afin d’éviter une panne de bougie inattendue.
36 9. Maintenance English ■ AIR INLET SCREEN • Blowing air is taken in from the air inlet screen. When air flow has dropped down during operation, stop the engine and inspect the air inlet screen for blocking by obstacles. • Note that failure to remove any such obstacles may result in the engine becoming overheated and damaged.
37 9. Entretien 9. Mantenimiento Français Español ■ GRILLE D’ADMISSION D’AIR • L’air soufflé est tiré à partir de l’écran d’admission d’air. Si le flux d’air diminue pendant le fonctionnement, arrêter le moteur et inspecter l’écran de l’admission d’air pour y trouver d’éventuelles particules obstruantes.
38 Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw .
39 14. Parts list 14. Liste des pièces 14. Lista de piezas NOTE : 1. Use RedMax /ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. RedMax /ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company.
40 Fig.1 ENGINE GROUP HBZ2601/HBZ2601-CA 14. Parts List.
41 Fig.1 ENGINE GROUP HBZ2601/HBZ2601-CA Key# Part Number Description Q'ty 1 848-F3R-12A2 CYLINDER 1 2 848-F3R-12B0 GASKET 1 3 4820-12130 BOLT TORX, M5x22 2 4 848-F3R-14A0 INSULATOR 1 5 T1512-131.
42 14. Parts List Fig.2 BLOWER GROUP HBZ2601/HBZ2601-CA.
43 Fig.2 BLOWER GROUP HBZ2601/HBZ2601-CA Key# Part Number Description Q'ty 1 848-L0F-55A1 VOLUTE CASE 1 2 T4022-11301 VOLUTE COVER ASSY 1 3 1600-33130 • SCREW 3 4 T4970-52000 SCREW TORX 12 5 T4.
The California Air Resources Board and ZENOAH AMERICA, INC. are pleased to explain the emission control system warranty on your 2007 and later small off-road engine. In California, new small off-road engines must be designed, built and equipped to meet the state’s stringent anti-smog standards.
La Commission des ressources en air de Californie et ZENOAH AMERICA, INC. sont heureux d'expliquer la garantie du système de contrôle des émissions de votre petit moteur hors route de 2007 et ultérieur.
La Comisión de Recursos del Aire de California y ZENOAH AMERICA, INC. tienen el agrado de explicar la garantía del sistema de control de emisiones para motores “todo terreno” modelo 2007 y posteriores .
EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE UNIT, RedMax / ZENOAH AMERICA, INC., THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP.
Pièces en rapport avec les émissions de gaz d'échappement : RedMax / ZENOAH AMERICA, INC., par l'intermédiaire de n'importe quel revendeur RedMax, réparera gratuitement ou remplace.
PIEZAS REALACIONADAS CON LAS EMISIONES, POR DOS (2) AÑOS A CONTAR DE LA FECHA DE ENTREGA ORIGINAL DEL UNIDAD, RedMax / ZENOAH AMERICA, INC., A TRAVÉS DE CUALQUIER DISTRIBUIDOR RedMax, REPARARÁ O RE.
.
.
Printed in U.S.A. ZENOAH AMERICA, INC. 1100 Laval Blvd. Suite 110 Lawrenceville, Georgia 30043 IMPORT ANT EMISSIONS INFORMA TION THIS ENGINE MEETS U.S. EP A PH2 AND 2007 *1 CALIFORNIA EXH AND EVP EMISSION REGULA TIONS FOR SI SORE’s. COMPLIANCE PERIOD : CA TEGORY A ENGINE F AMIL Y : 7KZXS.
An important point after buying a device Zenoah HBZ2601-CA (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Zenoah HBZ2601-CA yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Zenoah HBZ2601-CA - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Zenoah HBZ2601-CA you will learn all the available features of the product, as well as information on its operation. The information that you get Zenoah HBZ2601-CA will certainly help you make a decision on the purchase.
If you already are a holder of Zenoah HBZ2601-CA, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Zenoah HBZ2601-CA.
However, one of the most important roles played by the user manual is to help in solving problems with Zenoah HBZ2601-CA. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Zenoah HBZ2601-CA along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
