Instruction/ maintenance manual of the product WFPE-30F Wells
Go to page of 24
PRINTED IN UNITED ST A TES OF AMERICA WELLS BLOOMFIELD, LLC 2 ERIK CIRCLE, P . O. Box 280 V erdi, NV 89439 www .wellsbloomfield.com telephone: 775-689-5703 fax: 775-689-5976 IMPORTANT: DO NOT DI SCARD.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer Unless otherwise specified, all commercial cooking equipment manufactured by WELLS BLOOMFIELD, LLC is warranted against defects in ma terials .
W A R R A N T Y x i SPECIFICATIONS 1 FEATURES & OPERATING CONTROLS 2 AGENCY LISTING INFORMATION 4 PRECAUTIONS & GENERAL INFORMATION 5 I N S T A L L A T I O N 6 PREPARATION PRIOR TO OPER ATION .
FEATURES & OPERATING CONTROLS 2 1 POWER SWITCH (FRYER-OFF-FILTER) FRYER position energizes the FRYER and POWE R LIGHT; de-energizes FILTER PUM P . HEATING ELEMENTS energized and regulate to setting on CO NTROL T HERMOSTAT (8). OFF position de-energi zed FRYER and FILTER PUMP.
FEATURES & OPERATING CONTROLS (continued) 3 7 HI-LIMIT THERMOSTAT Provides over-temperature protection by de-e ne r gizing HEATING ELEMENTS should oil temperature exceed factory pre -set limits. 8 TEMPERAT URE C ONTROL THERMOSTAT Controls oil temperature.
AGENCY LISTING INFORMATION FEATURES & OPERATING CONTROLS (continued) 4 This appliance conforms to NSF Standard 4 for sanitation only if installed in accordance with the supplie d Installation Instructions and maintained according to the in structions in this manual.
This appliance is intended for use in commercial establishments only. This appliance is intended to prepare food for human consumpti on. No other use is recommended or autho rized by the manufacturer or its agents. DO NOT open any panel that require s the use of tools for access.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer INSTALLATION NOTE: DO NOT discard the carton or other packing materials until you have inspected the appliance for hidden damage and tested it for proper operation. Refer to SHIPPING DAMAGE CLAIM PROCEDURE on the inside front cover of this manual.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer ELECTRICAL INSTALLATION Refer to the nameplate on the front of the fryer and to the specifications listed on page 1 of this manual. Verify that electric service voltage, phase and amperage cap acity meet or exceed these specifications.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer PREPARATION PRIOR TO OPERATION 8 PRE-CLEANING PROCEDURE Slide the LID AND YOLK back. Press POWER SWITCH OFF . Close DRAIN VALVE (lever horizontal) . Fill FRYPOT with 4 gallons of cold water. Press POWER SWITCH to FRYER .
PREPARATION PRIOR TO OPERATION (continued) 9 PREPARE FILTER RESERVOIR Install SUCTION TUBE O-RINGS, FILTER PAPER and FILTER PAPER HOLDER in to RESERVOIR. Install assembled FILTER RESERVO IR in place a bottom of FRYER. Install DRIP PAN (item 17) into mounting bracket behind fryer door.
PREPARATION PRIOR TO OPERATION (continued) 10 Fill the FRYPOT to the COLD (MAX) line on OIL LEVEL INDICATOR with room temperature commercia l-quality LIQUID SHORTENING. This requires 30lbs. of oil. Check operation of FRYER and all CO NTROLS. Load product, and determine maximum load.
OPERATION 11 PRE-HEATING FRYER Make sure FRYPOT is filled with 30 LB. of cooking o il. Open door and set THERM OSTAT (item 10) to de sired cooking temperature. CLOSE THE DOOR. Set POWER SWITCH (item 1) to FRYER . POWER LIGHT (item 2) and HEAT LIGHT (item 3) will glow.
MAINTENANCE - FILTER OPERATION 12 FILTER PAPER INSTALLATIO N 1. Open FRYER DOOR and re move FILTER RESERVOIR. 2. Remove FILTER PAPER HO LDER, used FILTER PAPER and FILTER SCREEN. Discard used f ilter paper and make sure filter reservoir, filter screen and filter paper holder a re clean and dry.
MAINTENANCE - FILTER OPERATION (continued) 13 FILTERING OIL NOTE: Oil should be at least 300ºF (149ºC) DO NOT attempt to filter cold oil. DO NOT attempt to pump oil when less than 300ºF. Cold oil will not pass through the filter paper. Filtering cold oil will re su lt in the premature failure of the filter pump.
MAINTENANCE - FILTER OPERATION (continued) 14 (CONTINUED FR OM PAGE 13) 6. Brush down sides and bottom of frypot using p r ovided hi-temperature brush. Loosen crumb s and other debris to flush them into filter reservoir. 7. Rotate DRAIN VALVE LEVER (item 11) to the horizontal position when filtering is complete, 8.
MAINTENANCE - DISCARDING USED OIL 15 1. Press POWER SWITCH to OFF. Allow oil to cool to 120ºF (49ºC) or less before attempting to drain oil from fryer. 2. With a suitable METAL container un der DRAIN VALVE, slowly rotate DRAIN VALVE LEVER to the vertical position.
OPTIONAL OIL WAND WASH OUT FRYPOT or DISCARD OIL 1. If discarding oil, be sure a suitable hot o il disposal container is available. Otherwise, prepare filter reservoir pa n for filtering (see page 12). 2. Turn DRAIN VALVE HANDLE vertical to open the drain and fill filter reservoir.
OPTIONAL OIL WAND RETURN FRYER TO NORMAL OPERATION 1. After washing down frypot, turn DRAIN VALVE HANDLE horizontal to close the frypot drain. IMPORTANT: Drain handle must be fully closed in order to activate HEATER SAFETY SWITCH. Drain handle must be horizontal before for frye r heating element can be energized.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer MAINTENANCE - CLEANING INSTRUCTIONS 18 122 306626 OpM anual for HDG-Series Griddles 122 306626 OpM anual for HDG-Series Griddles DANGER: BURN HAZARD Contact with hot oil will cause severe burns.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer MAINTENANCE - CLEANING IN STRUCTIONS (continued) 19 PREPARATION Drain oil from fryer before cleaning FREQUENCY Monthly, or as needed TOOLS Low-foaming commercial fryer clea nser Metal disposal container FRYPOT CLEANING - HOT BOILOUT PR OCEDURE Slide the LID AND YOLK back.
362 301626 OpM anual for WFPE-30F Electric Pressure Fryer TROUBLESHOOTING 20 SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Fryer will not heat Unit disconnected from electric power Reconnect to power Check/.
DESCRIPTION PART NO. BRUSH, CLEANING HEATING ELEMENT 21647 FILTER PAPER, 30-SERIES FRYER (pk100) 21711 FLAVOR-SAVER OIL FILTER POWDER (pk45) 22410 WAOC-1 MOBILE OIL DISPOSAL CADDY 22470 PADDLE, STIRRI.
Genuine Parts Protect - YOU - All - W ays SER VICE TRAINING - QUALITY SER VICE SER VICE TRAINING - QUALITY SER VICE CUSTOMER SA TISF ACTION CUSTOMER SA TISF ACTION Commercial Food Equipment Service As.
An important point after buying a device Wells WFPE-30F (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Wells WFPE-30F yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Wells WFPE-30F - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Wells WFPE-30F you will learn all the available features of the product, as well as information on its operation. The information that you get Wells WFPE-30F will certainly help you make a decision on the purchase.
If you already are a holder of Wells WFPE-30F, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Wells WFPE-30F.
However, one of the most important roles played by the user manual is to help in solving problems with Wells WFPE-30F. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Wells WFPE-30F along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
