Instruction/ maintenance manual of the product 1997 850 Volvo
Go to page of 259
1997 Volvo 850 850 Model VOLVO 850 1 9 9 7 VOLVO This manual deals with the operation and care of your Volvo. Welcome to the world-wide family of Volvo owners. We trust that you will enjoy many years of safe driving in your Volvo, an automobile designed with your safety and comfort in mind.
1997 Volvo 850 in reducing our environmental impact. Volvo's environmental activities are based on a holistic view, which means we consider the overall environmental impact of a product throughout its complete life cycle. In this context, design, production, product use, and recycling are all important considerations.
1997 Volvo 850 America, Inc. is involved, visit our Internet Environmental Home Page at: http://www.volvocars.com/environment.html Contents Important Before you operate your car for the first time, please familiarize yourself with the BREAK-IN information on page 4:2.
1997 Volvo 850 CAUTION: The 850 R turbo models have reduced ground clearance due to the design of the front spoiler. Please observe caution when e.g., driving onto garage hoists, through drifted snow or when other road debris is encountered, or when parking near curbs.
1997 Volvo 850 Audio systems pg. 10:1 Audio systems Audio systems This chapter describes the audio system in your car. pg. 10:2 SC-710 pg. 10:14 SC-811 pg.
1997 Volvo 850 2. Anti-theft LED 3. – Volume (turn) – Balance (pull and turn) 4. CD mode selector 5. Bass control 6. Treble control 7. Fader control 8. – Preset buttons – CD -Disc No. selector 9. Wave band selectors (FM) 10. Wave band selectors (AM) 11.
1997 Volvo 850 Anti-theft code The radio features anti-theft circuitry. If the set is removed from the vehicle or if the battery power is disconnected, a special code must be entered to enable operation of the set. Refer to the radio code card supplied with your vehicle or ask your retailer for the correct code .
1997 Volvo 850 Incorrect code If an incorrect code has been entered "EEEE" is displayed. Enter the correct code. After three unsuccessful coding attempts, the set will lock and remain locked for two hours.
1997 Volvo 850 Turn the button clockwise to switch on and to increase the volume. The volume control is electronic and has no end stop. C - Wave band selector The desired wave band is set by pressing one of the wave band selector buttons. The frequency and wave band is shown on the display.
1997 Volvo 850 A - Seek tuning Press the SEEK button to seek for higher frequencies. The radio seeks the next audible station and stops there. If you wish to continue the seek tuning, press the SEEK button again. B - Preset programming 1. Tune to the desired frequency.
1997 Volvo 850 A - Automatic programming (Auto seek) Please note that this function will not interfere with pre-stored stations on buttons 1-6. This function automatically seeks and stores up to 8 strong AM or FM stations. This is especially useful when travelling in areas where radio stations are unfamiliar.
1997 Volvo 850 indicates "equalized" treble. pg. 10:7 Radio SC-710 (cont.) A - Fader control Adjust front/rear speaker balance by sliding the control up or down. Up to direct more sound to the front speakers, down to direct more sound to the rear speakers.
1997 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_1001.htm (9 of 9)12/30/2006 10:13:49 AM.
1997 Volvo 850 pg. 10:8 Cassette deck A - Cassette slot The cassette is inserted with the open side to the right (side 1 or A of the cassette upwards). When the cassette is inserted, the radio is disengaged and the cassette will start to play automatically.
1997 Volvo 850 D - Dolby B button Press this button when you use tapes recorded with the Dolby B noise reduction system. The Dolby Symbol will be indicated in the display. pg. 10:9 Cassette deck (cont.) A - Cassette eject If the button is pressed, the tape will stop and the cassette will be ejected.
1997 Volvo 850 A - CD mode selector Press "CD" to actuate the CD mode. The disc/track last listened to will continue to play. If the CD- changer cartridge* is empty, "----" will be displayed.
1997 Volvo 850 pg. 10:11 CD - Remote (certain models) (cont.) A - Changing the selected track number Press CD (SEEK) button to select the next track. Press the CD (AUTO) button to select the previous track. The chosen disc number and track number will be displayed.
1997 Volvo 850 A - Random choice Press "RND" to actuate the random mode. From a disc chosen at random, 4 tracks will be played (also chosen at random). A new disc will then be played in the same way. "RND" will be displayed when this function is engaged.
1997 Volvo 850 Radio System: PLL (Phase Lock Loop) system with tuned RF (Radio Frequency) front end and automatic wide band gain control. Electronic suppression circuitry (noise killer). Frequency range: FM 87.9 - 107.9 MHz AM 530 - 1710 kHz Sensitivity: FM 1.
1997 Volvo 850 Occupant safety, Reporting safety defects pg. 1:1 Occupant safety Occupant safety Despite our strongest recommendations, and your best intentions, not wearing a seat belt is like believing "It'll never happen to me!".
1997 Volvo 850 seat belt. The rear seats are provided with self-retracting inertia reel belts. The front seats are provided with single roller belts with tensioners. To buckle: Pull the belt out far enough to insert the latch plate into the receptacle (buckle for rear seats) until a distinct snapping sound is heard.
1997 Volvo 850 WARNING! Any device used to induce slack into the shoulder belt portion of the three-point belt system will have a detrimental effect on the amount of protection available to you in the event of a collision. The seat back should not be tilted too far back.
1997 Volvo 850 WARNING! Never use a seat belt for more than one occupant. Never wear the shoulder portion of the belt under the arm, behind the back or otherwise out of position.
1997 Volvo 850 pg. 10:14 Premium Sound system SC-811 (certain models), general description The following pages describe the use of your SC-811 Cassette Radio and CD remote control 1. – On/off (turn) – Volume (turn) – Pause/Mute (push) – Balance (pull) 2.
1997 Volvo 850 16. TP -Next song CD -Next track UP 17. TP -Fast forward CD -Music search UP 18. TP -Rewind CD -Music search DOWN 19. TP -Previous song REPEAT CD -Previous track DOWN 20. Tape mode selector TP = Applicable only in tape mode CD = Applicable only when in CD mode and connected to a CD changer pg.
1997 Volvo 850 switched on. Enter the 4-digit code using the preset buttons. If the correct code is entered, "on" is displayed and the set is ready to use. If you enter an incorrect code you must enter the correct code again from the beginning.
1997 Volvo 850 A - On/off switch and volume control Turn the button clockwise to switch on and to increase the volume. B - Waveband selector The desired waveband is set by pressing one of the waveband selector buttons. The frequency and waveband is shown on the display.
1997 Volvo 850 A - Seek tuning Push the tuning knob to seek for higher frequencies. The radio seeks the next audible station and stops there. If you wish to continue the seek tuning, press the tuning knob again. B - Preset programming 1. Tune to the desired frequency.
1997 Volvo 850 pg. 10:18 Radio SC-811 (cont.) A - Automatic programming (Auto seek) Please note that this function will not interfere with pre-stored stations on buttons 1-6. This function automatically seeks and stores up to 8 strong AM or FM stations.
1997 Volvo 850 Adjust the treble by sliding the control up or down (up to increase, down to decrease). A "detent" indicates "equalized" treble. pg. 10:19 Radio SC-811 (cont.) A - Fader control Adjust front/rear speaker balance by sliding the control up or down.
1997 Volvo 850 clockwise. Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_1014.htm (8 of 8)12/30/2006 10:13:53 AM.
1997 Volvo 850 pg. 10:20 Cassette deck A - Cassette slot The cassette is inserted with the open side to the right (side 1 or A of the cassette upwards). When the cassette is inserted, the radio is disengaged and the cassette will start to play automatically.
1997 Volvo 850 D - Dolby B button Press this button when you use tapes recorded with the Dolby B noise reduction system. The Dolby Symbol will be indicated in the display. pg. 10:21 Cassette deck (cont.) A - "nxt" (next) selector Press the "nxt" button and the tape will automatically advance to the next song.
1997 Volvo 850 If you press the "power-volume" knob the tape is stopped, the unit is silent and "PAUSE" is displayed. To restart the tape press the knob again. pg. 10:22 Cassette deck (cont.) A - Cassette eject If the button is pressed the tape will stop and the cassette will be ejected.
1997 Volvo 850 When the unit re-enters Radio mode, the cassette will not be ejected. C - To re-enter Tape mode If the Tape function has been disconnected and the cassette has not been ejected, the Tape mode can re- entered by pressing the "tape" button.
1997 Volvo 850 B - Disc number selector Depress one of the preset buttons (1-6) to select the disc number desired. The selected disc number and track number will be displayed. C - Music search Press the "rew" or "ff" button to search within a track.
1997 Volvo 850 Press "nxt" for forward selection or "rpt" for backward selection. The chosen disc number and track number will be displayed. C - Playing-time display When this button is pressed the playing time for the current track is displayed for 5 seconds.
1997 Volvo 850 C - To re-enter Radio mode There are two ways to re-enter Radio mode: ● Push one of the waveband selector buttons ● Push the autostore button D - To re-enter Tape mode If a cassette is already inserted, the tape deck will re-engage if the "tape" button is pressed.
1997 Volvo 850 4-track, 2 channel stereo Full logic electronic control Tape speed: 4.76 cm/sec. Channel separation: 53dB Frequency range: 30-15000 hz S/N: 56 dB without Dolby B S/N: 55 dB with Dolby B Wow and Flutter: less than 0.06 % "Dolby" and the double D symbol are the trademarks of Dolby Laboratories Licensing Corporation.
1997 Volvo 850 pg. 10:27 Premium Sound System SC-815 (certain models), general description 1. On/off (push) 2. ● Volume (turn) ● Pause/Mute (push) ● Balance (pull) 3. CD mode selector/Active sound control (single) 4. CD changer selector 5. ● Tape mode selector ● Tape direction selector PROG 6.
1997 Volvo 850 13. Not in use 14. Auto seek memory 15. Scan 16. ● Seek tuning up/down ● TP -Next/Previous song ● CD -Next UP/Previous DOWN track 17. ● Manual tuning ● TP -fast forward/Rewind ● CD -Music search UP/DOWN 18. CD eject (single) 19.
1997 Volvo 850 Anti-theft code The radio features anti-theft circuitry. If the set is removed from the vehicle or if the battery power is disconnected, a special code must be entered to enable operation of the set. Refer to the radio code card supplied with your vehicle or ask your retailer for the correct code.
1997 Volvo 850 Incorrect code If an incorrect code has been entered "EEEE" is displayed. Enter the correct code. After three unsuccessful coding attempts the set will lock and remain locked for two hours.
1997 Volvo 850 Turn the button clockwise to increase the volume. The volume control is electronic and has no end stop. C - Waveband selector The desired waveband is set by pressing one of the waveband selector bands. The frequency and waveband is shown on the display.
1997 Volvo 850 A - Seek tuning up/down Press the left side tune button to tune to lower frequencies and the right side to tune to higher frequencies. The radio seeks the next audible station and stops there. If you wish to continue the seek tuning, press the tune button again.
1997 Volvo 850 A - Automatic file:///K|/ownersdocs/1997/1997_850/97850_1027.htm (7 of 7)12/30/2006 10:13:55 AM.
1997 Volvo 850 pg. 10:33 Cassette deck A - Cassette slot The cassette is inserted with the open side to the right (side 1 or A of the cassette upwards). When the cassette is inserted, the radio is disengaged and the cassette will start to play automatically.
1997 Volvo 850 flash rapidly during fast winding. Fast winding can be stopped by pressing the button again. D - Dolby B NR button Press this button when you use tapes recorded with the Dolby B noise reduction system. The Dolby symbol will be indicated in the display.
1997 Volvo 850 C - Pause If you press the "volume" knob the tape is stopped, the unit is silent and "PAUSE" is displayed. To restart the tape press the knob again. D - Scan Press this button to listen to the first five seconds of each song.
1997 Volvo 850 There are three alternative ways to re-enter Radio mode: ● Push one of the waveband selector buttons ● Push the Auto seek button ● Push one of the preset buttons When the unit re-enters Radio mode, the cassette will not be ejected.
1997 Volvo 850 pg. 10:36 CD - Single A - CD slot With the audio system on, insert a disc into the slot with the label side up. When the CD is inserted, the radio is disengaged and the CD will start to play automatically. The CD can be inserted or ejected even when the unit is switched off.
1997 Volvo 850 engaged. The radio, tape or CD changer will engage automatically (depending on which mode was activated before the CD was played). NOTE: If the CD eject button is pressed and the disc is not removed within 12 seconds, the disc will not be drawn into the CD player again.
1997 Volvo 850 When the "CD" button is pressed the playing time for the current track is displayed for 5 seconds. D - Scan Press this button to listen to the first ten seconds of each track. Press it again to stop ds yins. pns.10:38 C(D - yincle(ecot.
1997 Volvo 850 There are two ways to re-enter Radio mode: ● Push one of the waveband selector buttons ● Push the "AUTO" button" D - To re-enter Tape mode If a cassette is already inserted, the tape deck will re-engage if the "TAPE" button is pressed.
1997 Volvo 850 A - CD changer mode selector Press "CHGR" to actuate the CD changer mode. The disc/track last listened to will continue to play.
1997 Volvo 850 Press the " " or " " button to search within a track. While the button is depressed the playing time for this track will be displayed. pg. 10:40 CD - Remote (certain models) (cont.) A - Changing the selected track number Press " " for forward selection or " " for backward selection.
1997 Volvo 850 A - Random choice Press "RND" to actuate the random mode. From a disc chosen at random, 4 tracks will be played (also chosen at random). A new disc will then be played in the same way. "RND" will be displayed when this function is engaged.
1997 Volvo 850 If a cassette is already inserted, the tape deck will re-engage if the "TAPE" button is pressed. E - To re-enter CD mode If the CD function has been disconnected and the CD has not been ejected, the CD mode can be re- entered by pressing the "CD" button.
1997 Volvo 850 Cassette deck 4-track, 2-channel stereo Full logic electronic tape transport Tape speed: 4.76 cm/sec. Channel separation 53 dB Frequency range 30-15000 hz S/N 56 dB without Dolby B NR S/N 66 dB with Dolby B NR Wow and Flutter less than 0.
1997 Volvo 850 pg. 1:4 Volvo SRS As an enhancement to the three-point seat belt system, your Volvo is equipped with a Supplemental Restraint System (SRS). The Volvo SRS consists of an airbag (2) and knee bolster (5) on both the driver's and passenger's sides and seat belt tensioners in both front door pillars (4).
1997 Volvo 850 The airbag system includes gas generators (1) surrounded by the airbags (2) and front seat belt tensioners for both of the front seats (4). To deploy the system, the sensor (3) activates the gas generators causing the airbags to be inflated with nitrogen gas.
1997 Volvo 850 A self-diagnostic system incorporated in the sensor monitors the SRS. This system does not, however, monitor the SIPS airbags. If a fault is detected, the "SRS" warning light will illuminate. The light is included in the warning/indicator light cluster in the instrument panel.
1997 Volvo 850 The above is a sample of the decal which can be found on the driver's door pillar. There is no maintenance to perform on the SRS yourself.
1997 Volvo 850 SRS texts on inside of both sun visors SRS texts on outside of both sun visors SRS text at far right of instrument panel WARNING! Do not use child safety seats or child boosters cushions/backrests in the front passenger's seat.
1997 Volvo 850 WARNING! ● Occupants in the front passenger's seat must never sit on the edge of the seat, sit leaning toward the instrument panel or otherwise sit out of position. The occupant's back must be as upright as comfort allows and be against the seat back with the seat belt properly fastened.
1997 Volvo 850 When are the airbags NOT deployed? Not all frontal collisions activate the SRS system. If the collision involves a non-rigid object (e.g., a snow drift or bush), or a rigid, fixed object at a low speed, the SRS system will not necessarily deploy.
1997 Volvo 850 SIPS airbag decal * SIPS airbag (front seats only) As an enhancement to the structural Side Impact Protection System built into your car, your car is also equipped with Side Impact Protection System (SIPS) airbags.
1997 Volvo 850 position with the seat belt properly fastened. NOTE: SIPS airbag deployment (one airbag) occurs only on the side of the vehicle affected by the impact. * A SIPS airbag warning decal is located at the end of the instrument panel on the driver's side of the car.
1997 Volvo 850 pg. 10:43 Audio systems, general information CD remote changer The CD changer, which is available separately, is loaded with a cartridge containing 6 discs. Extra cartridges are available at your Volvo retailer. Insert the discs into the cartridge, label (A) up.
1997 Volvo 850 ● Condensation may occur on discs/optical components of the changer in cold winter weather. The disc can be dried with a clean, lint-free cloth. Optical components in the CD changer may, however, take up to one hour to dry off. ● Never attempt to play a disc which is damaged in any way.
1997 Volvo 850 Weak reception (fading) Because of the limited range of the FM senders and the fact that these waves are very reflective, this problem usually occurs with FM reception. If the sender is blocked by buildings or mountains, static can result.
1997 Volvo 850 signals reflect against solid objects such as buildings. Because these waves are very reflective, static can result. This static is the result of the reflected signal and the direct signal reaching your antenna at slightly different times causing a cancellation of all signals.
1997 Volvo 850 FM - reasons for distortion FM is affected by the electrical systems of nearby vehicles, especially those without suppression. The distortion increases if the station is weak or poorly set. The FM reception is not as sensitive to electrical disturbances as AM.
1997 Volvo 850 pg. 10:46 Audio systems, general information (cont.) FM stereo reception Stereo reception places very high demands on the signal quality which means the type of distortions previously mentioned become even more obvious.
1997 Volvo 850 damaged. When cleaning the window be careful that the wires are not scratched by rings, etc. If they are damaged, radio reception will be impaired. Cassettes ● Store cassettes in their cases. ● Do not touch the tape surface with your fingers.
1997 Volvo 850 Carbon monoxide Carbon monoxide is a poisonous, colorless and odorless gas which is present in all exhaust gases. If you ever smell exhaust fumes from inside the vehicle, make sure the passenger compartment is ventilated and immediately return the vehicle to youth retailer for correction.
1997 Volvo 850 Tire pressure, see label located on inside of the fuel filler flap. Bulbs Power Socket US Bulb No. 1 70 W P 20d HB3/9005 2 60 W P 22d HB4/9006 3 24/5 W BAY 15 d 1157NA 4 21 W BA 15 s 11.
1997 Volvo 850 pg. 1:9 Child safety Child Restraint Anchorages Volvo cars are fitted with Child Restraint Top Tether Anchorages in the rear seat. Sedans: There are three pre-drilled anchorage points under the rear window shelf which are not visible from the passenger compartment.
1997 Volvo 850 Wagon WARNING! Child Restraint Anchorages are designed to withstand only those loads imposed by correctly fitted Child Restraints. Under no circumstances are they to be used for adult seat belts or harnesses.
1997 Volvo 850 with the vehicle's three-point seat belt. The booster cushion is approved for children weighing between 22.7 and 36 kg (50 and 80 lbs) and between 117 and 137 cm (46 and 54 in ) in height. It is not intended for children under 3 years of age.
1997 Volvo 850 pg. 1:11 Child safety (cont.) Auxiliary seat - A-Fold up, B-Fold down Auxiliary seat (optional) If all the seats are occupied, a rear-facing auxiliary seat in the cargo area of the wagon models can be used. This seat is designed for two children, each weighing between 23 - 40 kg (50 - 88 lbs.
1997 Volvo 850 To make child restraint installation easier, each seat belt buckle (except for the driver's belt) is equipped with a locking mechanism to help keep the lap section of the seat belt taut. When attaching the seat belt to a child restraint: ● Make sure the red lock button is moved to the right (see illustration A).
1997 Volvo 850 The child could also be injured by striking the interior, or by being ejected from the vehicle during a sudden maneuver or impact. The same can also happen if the infant or child rides unrestrained on the seat.
1997 Volvo 850 Seat belt maintenance Check periodically that the anchor bolts are secure and that the belts are in good condition. Use water and a mild detergent for cleaning. Check seat belt mechanism function as follows: Attach the seat belt and pull rapidly on the strap.
1997 Volvo 850 you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Volvo Cars of North America. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
1997 Volvo 850 Instruments and controls Instruments, switches and controls pg. 2:1 Instruments, switches and controls (cont.) IMPORTANT! (Automatic transmission only) Your car is equipped with a Shiftlock-Keylock system. SHIFTLOCK: When your car is parked, the gear selector is locked in the (P)ark position.
1997 Volvo 850 KEYLOCK This means that when you switch off the ignition, the gear selector must be in the (P)ark position before the starting (ignition) key can be removed from the ignition switch.
1997 Volvo 850 pg. 2:24 17 Electrically operated windows pg. 3:7 Side door mirrors pg. 2:17 18 Cigarette lighter pg. 3:10 19 Hood release pg. 2:8 20 Front fog lights (optional) pg. 2:8 21 Central locking button pg. 2:18 22 Adjustable steering wheel pg.
1997 Volvo 850 approximately 1.8 US gals. (8 liters) of fuel remaining. See "Refueling" for further information. 2 Boost pressure gauge (Certain turbo-charged models only) The boost pressure gauge is divided into sections. Black section: The engine acts as a normally aspirated engine.
1997 Volvo 850 9 Tachometer Reads thousands of engine rpm. The engine should not be operated in red range. The highest permitted constant engine speed is 6,300 rpm (turbo-charged models: 6,200 rpm, B 5252 S: 6,000 rpm).
1997 Volvo 850 16 Parking brake applied 17 ABS-system 18 Ambient temperature warning light* (certain models) (See pp. 2:11 or 2:14 for more information) 19 Transmission mode "W", or gear pos.
1997 Volvo 850 NOTE: If the fuel filler cap is not closed tightly or if the engine is running when the car is refueled, the Malfunction Indicator Lamp may indicate a fault.
1997 Volvo 850 If the TRACS (TRAction Control System) is manually disengaged with the switch on the dashboard, the warning light will come on. This will also come on to indicate a TRACS malfunction, and when the brakes overheat, although it goes out again at the normal temperature level.
1997 Volvo 850 Service reminder indicator This light will come on at 10,000 mile (16,000 km) intervals*, after 750 hours of driving or after 12 months, whichever occurs first. It is a reminder to the driver that the service interval has been exceeded.
1997 Volvo 850 pg. 2:6 Headlights, Parking lights, Turn signals Headlights and parking lights O All lights off * Parking lights on ** Headlights and parking lights are on if starting (ignition) switch is in positions I or II. If the headlight switch is in position all lights will go out when starting switch is switched off.
1997 Volvo 850 Turn signals 1 Lane change position : In maneuvers such as lane changing, the driver can flash the turn signals by moving the turn signal lever to the first stop and holding it there. The lever will return to the neutral position when released.
1997 Volvo 850 1 Intermittent wiper With switch in this position, the wipers will sweep approximately every seventh second. 2 "Single sweep" position.
1997 Volvo 850 WARNING: Never turn the key to position O while driving or when the car is being towed. I Intermediate position: Certain accessories, radio, etc. on, daytime running lights off. II Drive position: Key position when engine is running. III Starting position: Release the key when the engine starts.
1997 Volvo 850 A - Instrument illumination To increase the brightness: move the slide switch to the right. To decrease the brightness: move the slide switch to the left.
1997 Volvo 850 Automatic daytime running lights Automatic daytime running lights (will also function when the headlight switch is in position ) All lights off (daytime running light function disabled) D - Central locking Press the switch to lock/unlock the doors, trunk/tailgate and the fuel tank cover .
1997 Volvo 850 on. B - Electrically operated sun roof - option The sun roof can be operated in two ways; as a conventional sliding roof or the rear edge can be raised to provide increased ventilation. See page 3:9 for operating instructions. NOTE: In case of a sun roof malfunction, see page 3:9.
1997 Volvo 850 Tailgate wiper/washer (wagons) Tailgate window wiper/washer The tailgate window wiper/washer is operated by a switch at the end of the wiper level. 1. The wiper operates continuously. 2. Intermittent position: the wiper strokes approximately every 10 seconds.
1997 Volvo 850 pg. 2:11 Clock, Ambient temperature sensor (certain models) Resetting the clock The digital clock can be reset by pressing one of the two buttons (A and B) with a pointed object such as the tip of a pen. h = hours m = minutes Maintain the pressure on the buttons for more than four seconds to change the time more quickly.
1997 Volvo 850 pg. 2:12 Trip computer (certain models) Trip computer The trip computer offers six functions which are presented in a single display. The cursor indicates the selected function. The trip computer's clock is shown permanently in the left-hand field.
1997 Volvo 850 Trip computer controls Select one of the trip computer's six functions by using control B. The Reset button (C) is used to reset the following functions: ● Average speed ● Aver.
1997 Volvo 850 Continuous information on current fuel consumption, calculated once per second. When the car is not moving, the display shows "---". Average fuel consumption Ø mpg (Canada: L/100 km) Average fuel consumption since the function was last reset.
1997 Volvo 850 Driving distance on current fuel reserve mile 0 (Canada: km) Shows the distance which can be driven on the fuel remaining in the tank, calculated on the basis of the average fuel consumption and the amount of fuel remaining in the tank at the time of the reading.
1997 Volvo 850 pg. 2:15 Cruise control Cruise control The cruise control switches are located on the turn signal lever. To engage and set the desired speed: 1. Set switch (B) to ON. 2. Accelerate to the desired cruise speed. 3. Press the + or - area of the SET button (A) to set the desired speed.
1997 Volvo 850 This can be avoided by switching between transmission modes E or S while on the hill. Normally, the ( E )conomy mode should be used when the cruise control is engaged. Acceleration Momentary acceleration, such as for passing, does not interrupt cruise control operation.
1997 Volvo 850 Heated front seats The heated front seats can be switched on and off as required. When switched on, the system senses the ambient temperature and regulates the level of heat applied. When the optimum temperature is reached, the heating switches off automatically.
1997 Volvo 850 Cigarette lighter To operate, depress the knob fully. When the knob automatically releases, the cigarette lighter is ready for use. The starting (ignition) switch must be either in position I or II for the cigarette lighter to function.
1997 Volvo 850 Ash trays To open the front ash tray, press lightly on the panel. To open the rear ash tray, pull it straight out. To empty the front ash tray (see illustration, center column): (1) Grasp the removable gray insert on the sides and push it in.
1997 Volvo 850 WARNING! Never adjust the steering wheel while driving. Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_215.htm (6 of 6)12/30/2006 10:14:09 AM.
1997 Volvo 850.
1997 Volvo 850 Air vents (dash) A Closed B Open C Directing air flow horizontally D Directing air flow vertically Air mix (fresh air) The center panel vents have an air mix function which allows fresh air to enter the passenger compartment when the vents are open (position B).
1997 Volvo 850 Temperature dial Driver's side Set desired temperature Function selector Set desired function Temperature dial Passenger's side Set desired temperature Blower 0 = Blower (and A/C) off 4 = Highest blower speed Air in the passenger compartment recirculates - will not function in defrost setting.
1997 Volvo 850 Air through panel vents Defrost. Air to windshield and side windows. Air to floor, windshield and side windows. Air through floor vents. Bi-level. Air through floor and panel vents. NOTE: If your windows begin to fog or mist, check that the recirculation function is NOT engaged.
1997 Volvo 850 To demist/defrost the windows: Set the function selector to . When the windows have cleared, set the blower control to position 2 and the function selector to the desired position. Always keep the air intake grille at the base of the windshield under the rear edge of the hood free of snow.
1997 Volvo 850 Temperature dial Driver's side Set desired temperature Function selector Set desired function Temperature dial Passenger's side Set desired temperature Blower AUT=Blower speed automatically regulated. 0 = OFF Move the knob to the right to increase blower speed.
1997 Volvo 850 AUT Air distribution automatically regulated Air through panel vents Defrost. Air to windshield and side windows. Recirculation will not function regardless of button position. Air to floor, windshield and side windows. Air through floor vents.
1997 Volvo 850 Set the function selector to and move the blower control to the position AUT (as far to the left as possible). The A/C system will be on at this time regardless of the A/C button's position and the blower will run at its maximum speed.
1997 Volvo 850 than the automatic setting to defrost the windows. Set the mode selector to "Defrost" or "Defrost/ floor" and the fan speed to midrange. Also shut the middle air vents. Faults in the ECC system The REC and AC OFF lights will flash for approximately 20 seconds if a fault is detected in the ECC system.
1997 Volvo 850 blocks a window. Should this occur, remove the object and wait 20 seconds for the circuit breaker to reset. The power windows should then function.
1997 Volvo 850 Body and interior pg. 3:1 Body and interior Body and interior The seats, sun roof, mirrors, etc. are described on the following pages. pg. 3:2 Keys pg. 3:3 Doors and locks pg. 3:4 Remote keyless entry system pg. 3:5 Alarm pg. 3:6-7 Front seats pg.
1997 Volvo 850 pg. 3:2 Keys Master key This key operates all locks The key number codes are stamped on a separate tag supplied with the keys. This tag should be separated from the key ring and kept in a safe place.
1997 Volvo 850 Doors and locks Your car is equipped with a two door operated central locking system. The key, used on either of the front doors, will lock/unlock all doors, trunk/tailgate and on certain models also the fuel tank cover. Turn the key once to unlock only the door in which the key is inserted.
1997 Volvo 850 To avoid battery drain The courtesy lights and the warning lights in the rear of the doors come on when a door is opened. To avoid battery drain when the doors are opened for prolonged periods, these lights can be switched off by pressing the lock mechanism (A) located in the rear facing side of the driver's door.
1997 Volvo 850 frequency which will allow "keyless" entry into the passenger compartment or the trunk. You will be supplied with two coded key ring transmitters, which will enable you to lock/unlock all doors and the trunk/tailgate from a distance of 10-15 feet (3-5 meters).
1997 Volvo 850 pg. 3:5 Alarm Alarm (certain models) To lock : Press the lock button once to lock all doors, trunk/tailgate, fuel tank cover and arm the security system. Lamps will flash to acknowledge that the vehicle is locked and the security system is armed.
1997 Volvo 850 Batteries The remote transmitter is powered by 2 three-volt batteries, type CR 1220. If three short signals are audible from the transmitter each time you lock/unlock the car, this indicates that the batteries are weak. Replacement : Remove the battery cover on the back of the transmitter with a coin.
1997 Volvo 850 pg. 3:6 Front seats 1 Height adjustment (manual) The front section of both front seats can be adjusted to eight different height settings and the rear section of both seats can be adjusted to nine different height settings.
1997 Volvo 850 Firm: turn clockwise Soft: turn counter-clockwise. * Driver's seat only on certain models Electrically operated seats with memory function (certain models) Power seat control panel.
1997 Volvo 850 Movement of the seat can be STOPPED at any time by pressing any button on the power seat control panel. Refer to the following page for information on programming the memory function. pg. 3:7 Electrically operated driver's seat, Rear/side-view mirrors Programming the memory Three seat positions can be programmed.
1997 Volvo 850 Rear-view mirror A Normal position B Night position, reduces glare from following headlights Electrically operated side-view mirrors The control switches are located in the center console, beside the parking brake.
1997 Volvo 850 WARNING! The mirrors should always be adjusted prior to driving. Objects seen in the wide-angle right side-view mirror are closer than they appear to be. pg. 3:8 Interior lights, Vanity mirror Front courtesy lights The front courtesy lighting consists of two reading lights for the front seat occupants.
1997 Volvo 850 Reading lights, rear seat There are two reading lights for the rear seat passengers. These are turned on/off by using the adjacent switches. Light is on if the front switch is in position . Light turns on if any door is opened. Vanity mirrors The light illuminates when the cover is opened.
1997 Volvo 850 pg. 3:9 Sun roof (option) Electrically-operated sun roof The switch for operating the sun roof is located on the instrument panel. The starting (ignition) key must first be turned to the drive position. On certain models, the sun roof is equipped with a one-touch, AUTO-open function.
1997 Volvo 850 ● To slide open the sun roof: Depress the lower section of the switch until the sun roof has opened to the position you prefer or hold the switch until the sun roof reaches the "comfort position"*. Depress the lower section of the switch again to open the sun roof completely.
1997 Volvo 850 To open the hood Pull the lever located under the left side of the dash to release both hood catches. This also releases and exposes the safety handle in the front of the grille. ● Lift the hood slightly to expose the safety handle. ● Pull the safety handle and open the hood.
1997 Volvo 850 1 Compartment in center console (certain models) 2 Glove compartment 3 Compartment in armrest (certain models) 4 Compartment in door 5 Compartment beside front seat (certain models) 6 C.
1997 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_306.htm (11 of 11)12/30/2006 10:14:13 AM.
1997 Volvo 850 pg. 3:12 Child safety locks, Trunk lid (sedan) Child safety locks The controls are located on the rear door jams. A The door cannot be opened from the inside.
1997 Volvo 850 You can also operate the trunk lock directly with the master key even if the vehicle is centrally locked. The trunk can also be disconnected from the central locking system by turning the key counterclockwise as shown below: Withdraw the key in the horizontal position.
1997 Volvo 850 Tailgate To unlock - fold down the flap covering the lock (see inset illustration above) insert the key, turn it clockwise and allow it to spring back. To lock - turn the key counter-clockwise and allow it to spring back. NOTE: The tailgate is also unlocked and locked at the same time as either of the front doors.
1997 Volvo 850 Child safety lock The tailgate incorporates a safety catch which is located to the side of the lock. A the tailgate cannot be opened from the inside. B the tailgate functions normally NOTE: You must use the end of a key, screwdriver, etc.
1997 Volvo 850 Spare tire The spare tire is located under the carpet in a special well under the floor of the trunk. The jack is placed inside the wheel rim. Make sure that the jack is properly secured in this position after use (see illustration). NOTE: See pages 6:2-6:3 for information on how the jack should be used.
1997 Volvo 850 1 The light is always OFF 2 Light comes on when the tailgate is opened Spare tire and jack The spare tire and the jack are located beneath the floor mat in the large storage bin. Always secure the spare tire and the jack to prevent them from rattling (see illustration).
1997 Volvo 850 Folding rear seat The rear seat is split into two sections so that each section can be folded independently. ● Lift the rear seat belts to the fixed section of the backrest.
1997 Volvo 850 ● Pull the strap to lift the rear seat cushion and swing the cushion up and toward the back of the front seats. ● The outboard head restraints must be lowered before the backrest is.
1997 Volvo 850 pg. 3:18 Folding rear seat, Removing seat cushions (wagon) WARNING! The red lock indicator is VISIBLE (A) when the backrest is NOT locked in position and not visible (B) when the backrest is correctly locked in place. When the backrest is in the upright position, it must always be correctly locked in place.
1997 Volvo 850 WARNING! Do not place extremely heavy articles against the front seats, as the backrest which is folded down is then placed under severe strain. Be sure to secure cargo. Hard and sharp articles could otherwise damage the frontseat backrest and/or cause injury to passengers in the event of rapid braking or a collision.
1997 Volvo 850 Luggage net The luggage net helps prevent cargo from being thrown forward should the vehicle stop suddenly or be involved in an accident. The luggage net unreels from the rear upper edge of the rear seat backrest. The luggage net must be accessed from the cargo storage area.
1997 Volvo 850 6 Make sure the nets are securely attached to the hooks under the covers and pulled taut. Use the reverse procedure to retract the net. The luggage net can also be used when the rear seat is folded down. However, extra brackets (optional) must be installed on the upper front door hand grips.
1997 Volvo 850 WARNING! The eyelets are not to be used as passenger restraints or as anchorages for child restraints. See page 1:9. Wagons only: Unless the station wagon is equipped with Volvo's auxiliary seat for children (option), passengers should not ride in the rear cargo area.
1997 Volvo 850 ● Move the seat as far rearward as possible. ● Adjust the backrest tilt to the most upright position ● Lift the catches on the lower rear side of the backrest ● Without releasing the catches, push the backrest forward ● Move the seat as far forward as possible.
1997 Volvo 850 Starting and driving pg. 4:1 Starting and driving Starting and driving This section on starting and driving contains items such as starting the engine, operating the gear selector, towing, trailers, etc. pg. 4:2 Break-in period pg. 4:2-3 Fuel requirements, Refueling pg.
1997 Volvo 850 the "kick-down" function (automatic transmission). NOTE - ENGINE OIL: Although some oil consumption occurs during normal engine operation, more oil is consumed when the engine is new as the internal parts generate higher friction while wearing-in to each other.
1997 Volvo 850 Unleaded Fuel Each Volvo has a three-way catalytic converter and must use only unleaded gasoline. U.S. and Canadian regulations require that pumps delivering unleaded gasoline be labeled "UNLEADED". Only these pumps have nozzles which fit your car's filler inlet.
1997 Volvo 850 Volvo allows the use of the following "oxygenated fuels; however, the octane ratings listed on this page must still be met. Alcohol — Ethanol Fuels containing up to 10% ethanol by volume may be used. Ethanol may also be referred to as Ethyl alcohol, or "Gasohol".
1997 Volvo 850 CAUTION: Take care not to spill gasoline during refueling. Gasolines containing alcohol can cause damage to painted surfaces, which may not be covered under the New Vehicle Limited Warranty. Do not use gasoline containing methanol (methyl alcohol, wood alcohol).
1997 Volvo 850 Some of the above mentioned items and others are checked at the standard Maintenance Service intervals. NOTE: ( D )rive or 5th gear (manual transmissions) should be used as often as possible to help improve fuel economy. pg. 4:5 Starting the engine Starting and stopping 1.
1997 Volvo 850 noticeable when selecting R. CAUTION: (Automatic transmission only) The engine should be idling; never accelerate until after you feel the gear engage! Too-rapid acceleration immediately after selecting a gear will cause harsh engagement and premature transmission wear.
1997 Volvo 850 pg. 4:6 Manual transmission Shift positions Depress the clutch pedal completely when changing gears. Remove your foot from the clutch pedal while driving. Overdrive (5th gear) should be used as often as possible to help improve fuel economy.
1997 Volvo 850 Engaging reverse gear The gear lever must first be moved to neutral in order to engage reverse gear. CAUTION: Be careful that you do not inadvertently engage reverse while moving forward. pg. 4:7 Automatic transmission P (Park) Use this position when starting the engine or parking the car.
1997 Volvo 850 Never engage R while is moving forward. N (Neutral) Neutral = no gear engaged. Use the parking brake. The engine can be started with the gear selector in this position. D (Drive) D is the normal driving position and should be used as often as possible to help improve fuel economy.
1997 Volvo 850 Kick-down Automatic shift to a lower gear (kick-down) is achieved by depressing the accelerator pedal fully and briskly. An upshift will be achieved when approaching the top speed for a particular gear or by releasing the accelerator pedal slightly.
1997 Volvo 850 Mode selector The push-buttons to the left of the gear lever are for selection of modes. E, S, and W. The desired mode can be selected at any time, including while the car is moving. Winter/Wet mode Enhanced Vehicle Traction This mode may be selected for starting/moving off on slippery roads.
1997 Volvo 850 Economy Mode This mode is used for normal driving. The gearbox changes gears at a lower engine speed to achieve the best possible fuel consumption.
1997 Volvo 850 ● The (E)conomy mode should be selected when the cruise control is engaged. ● While towing a trailer in hilly terrain, do not drive continuously at engine speeds above 4500 rpm to help avoid high engine oil temperatures.
1997 Volvo 850 WARNING! Do not drive with trunk lid or tailgate open! Poisonous exhaust gases may enter via the open trunk lid or tailgate. If the trunk lid/tailgate must be kept open for any reason, proceed as follows: - Close the windows.
1997 Volvo 850 Vehicle load, tire design and inflation pressure all affect vehicle handling. Therefore, check that the tires are inflated to the recommended pressure according to the vehicle load. See "Tire pressure" section. Loads should be distributed so that capacity weight or maximum permissible axle loads are not exceeded.
1997 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_406.htm (10 of 10)12/30/2006 10:14:19 AM.
1997 Volvo 850 pg. 4:12 Emergency towing (pulling of vehicle) Front eyelet Rear eyelet Precautionary steps to observe when the car is in tow ● Steering must be unlocked.
1997 Volvo 850 Only use flat bed equipment * CAUTION: ● Sling-type equipment applied at the front will damage radiator and air conditioning lines. ● It is equally important not to use sling-type equipment at the rear or apply lifting equipment inside the rear wheels; serious damage to the rear axle may result.
1997 Volvo 850 premature completion of a negative circuit. Note the position of the battery terminals and using jumper cables: ● First connect the booster battery positive (+) terminal (1) to car battery positive (+) terminal (2).
1997 Volvo 850 Three-way catalytic converter cautions ● Keep your engine properly tuned. Certain engine malfunctions, particularly involving the electrical, fuel or distributor ignition systems, may cause unusually high three-way catalytic converter temperatures.
1997 Volvo 850 pg. 4:16 Brake system Anti-lock Brake System (ABS) If the warning lamp lights up there is a malfunction of the ABS system (the standard braking system will however function) and the vehicle should be driven cautiously to a Volvo retailer for inspection.
1997 Volvo 850 Severe strain on the brake system The brakes will be subject to severe strain when driving in mountains or hilly areas or towing. The speed is usually low which means that the cooling of the brakes is less efficient than when driving on level roads.
1997 Volvo 850 Trailer towing does not normally present any particular problems, but take into consideration: ● Increase tire pressure to recommended full.
1997 Volvo 850 section "Coolant". The use of "recycled" antifreeze is not approved by Volvo. Different types of antifreeze may not be mixed. ● Try to keep the fuel tank well filled - this prevents the formation of condensation in the tank.
1997 Volvo 850 * These positions always offer the kick-down function. pg. 4:19 Long distance trips Before a long distance trip It is always worthwhile to have your car checked at a Volvo retailer before driving long distances.
1997 Volvo 850 Wheels and tires pg. 5:1 Wheels and tires Wheels and tires The handling and riding comfort of the vehicle is dependent on the inflation pressure and the type of tires fitted. Read the following pages carefully. pg. 5:2 General information, Wear indicator, Tire economy, Flat spots pg.
1997 Volvo 850 wheels. When replacing tires, be sure that the new tires are the same size designation, type (radial) and preferably from the same manufacturer, on all four wheels. Otherwise there is a risk of altering the car's road-holding and handling characteristics.
1997 Volvo 850 up and consequently longer for the flat spot to disappear. CAUTION: (Turbo-charged models) The car must not be driven with wheels of different dimensions. The use of different size wheels can seriously damage your car's transmission.
1997 Volvo 850 Tires for winter use: Owners who live in or regularly commute through areas with sustained periods of snow or icy driving conditions are strongly advised to fit suitable winter tires to help retain the highest degree of traction.
1997 Volvo 850 recommended on the tire information label* located on the inside of the fuel filler flap. This label lists both the tire and vehicle design limits. Do not load your car beyond the load limits indicated. * Please note that the tire information label indicates pressures for both comfort and fuel economy.
1997 Volvo 850 performance. WARNING! The traction grade assigned to this tire is based on braking (straight-ahead) traction tests and does not include cornering (turning) traction.
1997 Volvo 850 In case of emergency pg. 6:1 In case of an emergency In case of an emergency Even if you maintain your car in good running condition, there is always the possibility that something might go wrong and prevent you from driving, such as a punctured tire, blown fuse or bulb, etc.
1997 Volvo 850 Changing a wheel The spare wheel is located under the carpet on the trunk floor. The jack and crank are secured in the wheel recess. ● Engage the parking brake. ● Put the gear selector in (P)ark (automatic) or in Reverse (manual). ● Remove the wheel cap (where applicable) using the lug wrench in the tool kit.
1997 Volvo 850 Jack attachment There is a jack attachment located in the center on each side of the car. Position the jack on the bar in the attachment as shown in illustration A above and crank while simultaneously guiding the base of the jack to the ground.
1997 Volvo 850 WARNING! ● The jack's attachment must engage the bar in the jack attachment (A). The car's weight must not rest on the jack's attachment (B). ● Be sure the jack is on a firm, level, non-slippery surface. ● Never allow any part of your body to be extended under a car supported by a jack.
1997 Volvo 850 Temporary Spare (certain models) The spare tire of your car is what is called a "Temporary Spare". It has the following designation: T115/70 R15 or T125/90R15. Recommended tire pressure (see decal on fuel filler flap) should be maintained irrespective of which position on the car the Temporary Spare tire is used on.
1997 Volvo 850 pg. 6:5 Replacing bulbs Replacing bulbs Make sure when installing bulbs, that the guide pin on the socket fits into its corresponding recess. When installing Halogen bulbs, do not touch the glass with your fingers since grease, oil or any other impurities can be carbonized onto the bulb and damage the reflector.
1997 Volvo 850 1 - Plastic cover, 2 - Bulb HB4/9006 3 - Bulb HB3/9005, 4 - Connector Headlight bulb replacement 1. Turn the plastic cover counter-clockwise and remove it. 2. Turn the bulb and connector (one unit) 1/4 turn counter-clockwise and remove.
1997 Volvo 850 Lateral headlight adjustment should only be carried out by an authorized Volvo retailer. The lateral adjustment scale (B) should be preset to "0". pg. 6:7 Replacing bulbs (cont.) Lamp location- right side, A- covers, B- bulb holder Tail light bulbs (sedans) 1.
1997 Volvo 850 Location of bulbs in holder All the bulbs in the tail light unit are replaced from inside the trunk as follows: 1. Turn the two plastic screws and open the cover over the rear lamp unit. 2. Loosen and remove the bulb holder. 3. Let the connector with its wires remain attached to the bulb holder.
1997 Volvo 850 Removing speaker from upper section 1,2,4 21W/32cp BA 15s 3,5 21/4W BAZ 15d Tail light bulbs (wagons) 1. Direction indicator 2. Brake light 3.
1997 Volvo 850 ● Press in the plastic catches (A or B) and take out the bulb holder. ● Remove the speaker (optional) from the upper section of the tail light unit. ● Leave the connector and cables connected to the bulb holder. ● Remove the bulb by pressing it inwards and turning it slightly counter-clockwise.
1997 Volvo 850 ●.
1997 Volvo 850 Insert screwdriver and turn Trunk light (sedans)/Rear courtesy light (wagons) ● Switch off the lights. ● Press in the catch with a screwdriver and remove the bulb holder. ● Replace the bulb and reinstall the bulb holder. Phillips-head screwdriver for glass lens License plate lights (sedans and wagons) ● Switch off the lights.
1997 Volvo 850 ● Insert the screwdriver and turn gently to loosen the glass lens. ● Replace the bulb and reinstall the glass lens. pg. 6:11 Replacing bulbs (cont.) Insert screwdriver, turn and pull downward Front courtesy lights ● Switch off the ignition.
1997 Volvo 850 ● Switch off the ignition. ● Insert a screwdriver and turn to loosen the lamp unit. ● Replace the bulb and press the lamp unit back into place. Insert a screwdriver and turn Vanity mirror ● Switch off the ignition. ● Insert a screwdriver under the lower edge and turn to loosen the glass lens.
1997 Volvo 850 Insert the screwdriver and turn gently (rear door) Door warning lights Front ● Slide the lamp unit upward and lift it out. ● Twist off the bulb holder. ● Pull the bulb straight out. ● Replace the bulb. ● Reinstall the holder and lamp unit in reverse order.
1997 Volvo 850 NOTE: Other bulbs may be difficult for the owner to replace. Let your Volvo retailer replace these bulbs if necessary. Front fog lights in spoiler Front fog lights (option) ● Switch off the lights. ● Turn the plastic cover counter-clockwise to remove it.
1997 Volvo 850 pg. 6:13 Fuses Fuse removal tool Defective fuse Intact fuse Replacing fuses If an electrical component fails to function, it is likely that a fuse has blown due to a temporary circuit overload. The fuse box is located in the engine compartment (see illustration) and can be opened by lifting the cover.
1997 Volvo 850 pg. 6:14 Fuses Location * Amperage 1 Fuel injection, distributor ignition system, automatic gearbox 15A 2 Fuel pump 15A 3 Interior courtesy lights 10A 4 – 5 ECC blower (speed 4) 30A 6.
1997 Volvo 850 Location * Amperage 33 Rear window wiper/washer (wagons) 15A 34 Windshield/headlight wipers/washers, horn 25A 35 Instrument panel lights, power sun roof 10A 36 – 37 Power windows, pow.
1997 Volvo 850 In order to help avoid interference and damage to your car's electrical system, your car is equipped with an accessory connector located under the instrument panel on the driver's side.
1997 Volvo 850 Slide the wiper blade along the arm to release it from the hook. Install the new blade (installation is the reverse of removal) and make sure that it is properly attached to the wiper arm.
1997 Volvo 850 To obtain maximum lifetime from a set of wiper blades, clean them with a stiff-bristle brush and warm, soapy water as part of a normal car wash. pg. 6:17 Replacing headlight wiper blades Replacing headlight wiper blades (certain models) Pull the wiper blade in the direction indicated by the arrow in the illustration to remove it.
1997 Volvo 850 Shiftlock release (automatic transmission only) The gear selector is locked in the (P)ark position. To manually release the shiftlock: ● Turn the starting (ignition) key to position I.
1997 Volvo 850 Remove the right floor cover (the center storage compartment must be opened first) and the cover panel on the right lower tail light. Pull on the hook and the fuel tank cover can then be opened. Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_613.
1997 Volvo 850 Car care pg. 7:1 Car care Car care Car care includes not only maintaining the appearance of the car, but also protecting the car exterior from the effects of air pollution, rain, mud or road salt. The paintwork should also be touched up immediately, if damaged, to prevent rust formation.
1997 Volvo 850 Minor stone chips and scratches Material: Primer - can Paint - touch-up bottle Brush Masking tape NOTE: When touching up the car, it should be clean and dry.
1997 Volvo 850 1. Place a strip of masking tape over the damaged surface. Pull the tape off so that any loose flakes of paint adhere to it. pg. 7:3 Paint touch-up (cont.) 2. Thoroughly mix the primer and apply it with a small brush. When the primer surface is dry, the paint can be applied using a brush.
1997 Volvo 850 3 If there is a longer scratch, you may want to protect surrounding paint by masking it off. pg. 7:4 Washing Washing the car ● The car should be washed at regular intervals since dirt, dust, insects and tar spots adhere to the paint and may cause damage.
1997 Volvo 850 ● Wash off the dirt from the underside (wheel housings fenders, etc.). ● In areas of high industrial fallout, more frequent washing is recommended. CAUTION: During high pressure washing the spray mouthpiece must never be closer to the vehicle than 13" (30 cm).
1997 Volvo 850 Bumpers: Wash the bumpers with the same cleaning agent used on the rest of the car. Never clean the bumpers with gasoline or paint thinner. Difficult spots can be removed with denatured alcohol. To avoid scratches, do not dry the bumpers with paper.
1997 Volvo 850 Waxing alone does not substitute for polishing of a dull surface. A wide range of polymer-based car waxes can be purchased today. The waxes are easy to use and produce a long-lasting, high-gloss finish that protects the bodywork against oxidation, road dirt and fading.
1997 Volvo 850 ● Take extra care when removing stains such as ink or lipstick since the coloring can spread. ● Use solvents sparingly. Too much solvent can damage the seat padding. ● Start from the outside of the stain and work toward the center.
1997 Volvo 850 Service and routine maintenance pg. 8:1 Volvo Service Service - an investment An investment which will pay dividends in the form of improved reliability, durability, and resale value. pg. 8:2 Label information pg. 8:3 Maintenance service, Warranty pg.
1997 Volvo 850 Vehicle Identification Number (VIN). Codes for color and upholstery etc. This plate is located on panel above right headlight. 5 Vehicle Identification Number (VIN) * The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door pillar.
1997 Volvo 850 pg. 8:3 Maintenance service, Warranty Maintenance service Volvo advises you to follow the service program which is outlined in the "Maintenance Records Manual". This maintenance program contains inspections and services necessary for the proper function of your car.
1997 Volvo 850 ● Corrosion Protection Limited Warranty ● Seatbelt and Supplemental Restraint Systems Limited Warranty ● Emission Design and Defect Warranty ● Emission Performance Warranty These are the Federal warranties; other warranties are provided as required by state law.
1997 Volvo 850 pg. 8:5 Maintenance schedule (cont.) Maintenance schedule A = Adjust (Correct if necessary) I = Inspect (Correct or Replace if necessary) R = Replace L = Lubricate Maintenance Operation.
1997 Volvo 850 Operation of all lights Level of windshield washer fluid The following should also be carried out at regular intervals: Washing Polishing Cleaning Rust protection Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_801.
1997 Volvo 850 pg. 8:6 Servicing The following precautions must be observed when carrying out repairs to the vehicle WARNING! The distributor ignition system operates at very high voltages. Special safety precautions must be followed to prevent injury.
1997 Volvo 850 axle stands or similar structures. If a two-post hoist is used to lift the car, the front and rear lift arm pads should be centered under the reinforced lift plates on the inboard edge of the sill rail. The position of these plates is marked with arrows molded into the bottom of the sill rail.
1997 Volvo 850 Unstable idle, misfiring, or poor emission control is often caused by leaking vacuum hoses or connections. Check all vacuum hoses and connections. Idle air control system Your Volvo is equipped with an electronically controlled idle air control system that requires no checking or adjustment.
1997 Volvo 850 pg. 8:8 Servicing (cont.) A - inlet manifold, B - EVAP valve, C - charcoal canister, D - roll over valve, E - line to fuel tank Fuel System The fuel system is all-electronic and is microprocessor-controlled. It can continually compensate for variation in engine load, speed and temperature to give the best economy and power.
1997 Volvo 850 This system adds air to the hot exhaust gases as they are expelled from the engine. This causes a secondary combustion of residual hydrocarbons and carbon monoxide, resulting in lower emissions levels in the exhaust gases.
1997 Volvo 850 pg. 8:9 Lubrication No. Lubrication point lubricant No. Lubrication point lubricant 1 Hood lock and latch Oil 6 Window winder (on inside of door) Oil, grease, low temperature grease 2 D.
1997 Volvo 850 CAUTION : Not checking the oil level regularly can result in serious engine damage if the oil becomes too low. Park the car on a level surface and wait for at least 3 minutes after the engine has been switched off. Be sure the oil level is maintained between the upper and lower marks on the dipstick.
1997 Volvo 850 ** Turbo-charged models: Add 0.95 qts (0.9 liters) if the oil cooler has been drained. A - Drain plug, B - Oil filter, C - Oil dipstick, D - Oil filler cap WARNING! Oil spilled on a hot exhaust pipe constitutes a fire risk. pg. 8:11 Engine oil (cont.
1997 Volvo 850 Do not use oils with other viscosity ratings. The use of incorrect viscosity oil can shorten engine life. Volvo recommends the use of energy-conserving oils.
1997 Volvo 850 American Petroleum Institute (API) labels. These labels certify the oil conforms to the applicable standards and specifications of the API.
1997 Volvo 850 pg. 8:12 Power steering fluid, Brake/clutch fluid reservoir Power steering fluid The dipstick has marks for checking hot and cold oil. The oil level when the engine is cold must never be higher than the COLD mark. After the engine has reached normal operating temperature, the level may not be higher than the HOT mark.
1997 Volvo 850 pg. 8:13 Automatic transmission fluid Check the oil level as follows: Park the car on a level surface with the engine idling . Slowly move the gear selector lever through all the shift positions and then to position P. Wait 3 minutes before checking the oil level.
1997 Volvo 850 Fluid type: ATF Dexron IIE/III and Mercon. WARNING! Oil spilled on a hot exhaust pipe constitutes a fire risk. pg. 8:14 Drive belt, Air pump system A - crankshaft, B - A/C compressor, C - generator, D - power steering pump Belt check Check the belt regularly to make sure it is in good condition and is clean.
1997 Volvo 850 Air pump system (certain models) When the engine is being started from cold, an electrical air pump which draws air to the exhaust system is activated. This starts an afterburning process which leads to reduced hydrocarbon and carbon monoxide (HC and CO) emissions and reduces the warm-up period for the catalytic converter.
1997 Volvo 850 adjust the nozzles if necessary. Please use caution to avoid damaging the paintwork. Washer fluid reservoir The washer fluid reservoir is located in the engine compartment and holds approx. 3.2 US qts. (3.0 liters). During cold weather, the reservoir should be filled with windshield washer solvent containing anti- freeze.
1997 Volvo 850 Normally, the coolant does not need to be changed. If the system must be drained, use the following procedure: 1 Remove the expansion tank cap. 2 Move the temperature adjustment control to max. heat. Open the drain cocks at the rear left of the engine block and at the bottom right corner of the radiator.
1997 Volvo 850 CAUTION: The cooling system must always be kept filled to the correct level. If it is not kept filled, there can be high local temperatures in the engine which could result in damage. Different types of anti- freeze/coolant may not be mixed.
1997 Volvo 850 9 Dipstick - automatic transmission 10 Air cleaner 11 Battery 12 Data plate WARNING! The cooling fan may start or continue to operate (for up to 6 minutes) after the engine has been switched off.
1997 Volvo 850 5 Fuse box 6 Washer fluid reservoir 7 Power steering fluid reservoir 8 Dipstick - engine oil 9 Dipstick - automatic transmission 10 Air cleaner 11 Battery 12 Data plate WARNING! The cooling fan may start or continue to operate (for up to 6 minutes) after the engine has been switched off.
1997 Volvo 850 Specifications pg. 9:1 Specifications Specifications This chapter contains facts and figures pertaining to the technical specifications of your car. pg. 9:2 Oil/Fluids specifications pg. 9:3 Engine specifications pg. 9:4 Cooling/fuel distributor ignition systems pg.
1997 Volvo 850 SAE 15W-30 should not be used under normal operating conditions. Viscosity (stable ambient temperatures): Engine oil Quality: Meeting API specification SG or SH Capacity (incl. filter) : 6.1 US qts. (5.8 liters)* Automatic transmission fluid Quality: ATF Dexron IIE/ III and Mercon Capacity: 8 US qts.
1997 Volvo 850 Engine Liquid-cooled gasoline, 5-cylinder, in-line engine. Aluminum alloy cylinder block with cast-iron cylinder liners cast directly into block. Aluminum alloy cylinder head with double overhead camshafts and separate intake and outlet channels.
1997 Volvo 850 Max torque 221 ft. lbs. at 2000-5280 rpm (300 Nm/33-88 rps) Number of cylinders 5 Bore 3.19" (81 mm) Stroke 3.54" (90 mm) Displacement 2.3 liters Compression ratio 8.5:1 Number of valves 20 Valve clearance Self-adjusting Designation: Volvo B 5234 850 R Turbo Output 222 hp at 5280 rpm* (166 kw/88 rps)* Max torque 221 ft.
1997 Volvo 850 Cooling system Type: Positive pressure, closed system Thermostat begins to open at 186°F (87°C) Turbo-charged models 180° F (87° C) Coolant: Volvo original coolant/anti-freeze Capacity: 7.6 US qts. (7.2 liters) Turbo-charged models - 7.
1997 Volvo 850 Delta-link individual rear-wheel suspension with longitudinal support arms, double link arms and track rods. Toe-in measured on the tire sides: 4° +/- 10° All specifications are subject to change without notice. Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_901.
1997 Volvo 850 pg. 9:5 Specifications (cont.) Power transmission Manual transmission: M 56 H Single-disc dry plate clutch. All-synchromesh on all gears including reverse; integrated final drive. Operation via a floor mounted gear lever. Final drive ratio 4.
1997 Volvo 850 Automatic transmission 2 US gals (7.6 liters) Manual transmission 2.2 US qts. (2.1 liters) Power steering fluid 0.8 US qts. (0.8 liter) Washer fluid reservoir 3.2 US qts. (3.0 liters) Brake/clutch system 0.6 US qts (0.6 liters) * Turbo-charged models: Add 0.
1997 Volvo 850 Generator Rated output 1400 W Max. current 100 A Bulbs Bulb US No. Power Socket No/ bulbs Headlights High beam Low beam HB3/9005 HB4/9006 70W 60W – – 2 2 Front parking lights/turn signals 1157 N.
1997 Volvo 850 Glove compartment light – 2 W BA 9s 1 Vanity mirror lights – 1.2 W – 2 Instrument lighting – 3 W W 2.1x9.5d 3 Illumination, control panel gear selector (automatic trans.) rear ashtray – – – 1.2 W 1.2 W 1.2 W W 2x4.6 d W 2x4.
1997 Volvo 850 WARNING! When adding accessories, equipment, luggage and other cargo to your vehicle, the total loaded weight capacity of the vehicle must not be exceeded.
1997 Volvo 850 (with brakes) 2" ball 3300 lbs (1500 kg) 1500 kg 1 7/8" ball 2000 lbs (908 kg) 900 kg Max. tongue weight *** 165 lbs (75 kg) 75 kg * The max permissible axle loads or the gross vehicle weight must not be exceeded. ** For permanent roof racks, check the manufacturer's weight specifications.
1997 Volvo 850 Volvo supports Voluntary Mechanic Certification by the A.S.E. Certified mechanics have demonstrated a high degree of competence in specific areas. Besides passing exams each mechanic must also have worked in the field for two or more years before a certificate is issued.
1997 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1997/1997_850/97850_905.htm (8 of 8)12/30/2006 10:14:32 AM.
An important point after buying a device Volvo 1997 850 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Volvo 1997 850 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Volvo 1997 850 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Volvo 1997 850 you will learn all the available features of the product, as well as information on its operation. The information that you get Volvo 1997 850 will certainly help you make a decision on the purchase.
If you already are a holder of Volvo 1997 850, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Volvo 1997 850.
However, one of the most important roles played by the user manual is to help in solving problems with Volvo 1997 850. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Volvo 1997 850 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
