Instruction/ maintenance manual of the product CLRCO2075 U-Line
Go to page of 21
www .U-LineService.com Phone (414) 354-0300 • F AX (414) 354-7905 Service & Parts T ech Line s Ph one (800) 779-2547 • F A X (414) 354-5696 OnlineService@U-Line.
www.U-Li neServi ce.co m 2 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator Conte nts Exterior Clea ning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Cut-Out Dime nsions . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Product Dime nsions .
02/2 005 3 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or General Pr ecautions Use this app liance for its in tended purp ose only and follow these general p recautions along with tho se listed throughout this guide: WA R N I N G SHOCK HAZARD — Electrical Gr ounding Required.
www.U-Li neServi ce.co m 4 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator After all the protective coating has be en removed from the unit/door , cle an all Stainless Steel su rfaces with Claire Stainless Ste el Polish and Cleaner o r comparable product or a mild deterge nt and warm water solution and soft cloth.
02/2 005 5 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or Product Dimensions Please note that the unit has adjustable feet that can add one additio nal inch to height during leveling or to match adjacent cabinets (see Figur e 43 on Page 17 ).
www.U-Li neServi ce.co m 6 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator 4. Remove the two door closer inserts from the existing bottom hinge and install as shown on the new bottom hinge (see Figure 8 ). 5. Remove existing bottom hinge (3 screws) and remount on opposite side TOP .
02/2 005 7 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or Side-By-Side Installation Instructions For a complete refreshment center , install your CLRCO2075 Clear Ice Maker/Refrig erator beside a U-Line Drawer or Win e Captain M odel (see Figu re 11 for typical cut-out).
www.U-Li neServi ce.co m 8 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator 3. Pull door gasket out of groove (top edge of door only). Start in the middle and pull outward, moving toward the edge (see Figur e 13 ). This may take s ome force. Do not re move the th ree scre ws beh ind gaske t.
02/2 005 9 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or Route notch in top corner o f overlay pa nel as shown (see T op and Side V iews). T op of notc h is entire depth of panel, front to back. Width: 13/16 " Depth: 1/8" Route notc h in back side of top corner of overla y panel (see Back an d Side View s).
www.U-Li neServi ce.co m 10 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator 5. Remove the top han dl e and discard. (This handle will be replaced with the Modified Handle included in the Full Overlay Door Panel Kit. ) 6. Remove the two screws located on both sides of the lower handle.
02/2 005 11 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or 5. Remove the existing bottom pivot plate and replace with the Full Overlay pivot plate (see Fig ure 23 ). IMPORT ANT Door panel and o verlay panel must be aligne d properly or the door wil l not operate correctly .
www.U-Li neServi ce.co m 12 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator Checking Door Ali gnment The unit’ s do or is aligned a t the factory befo r e shipment. However , its alignment could have been disturbed during shipment or du r ing door pa nel installation.
02/2 005 13 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or CAUTIO N Plumbing i nstallation must observe all sta te and loca l codes. All water and d r ain connec tions MUS T BE made by a licensed/qual ified plumbing contractor .
www.U-Li neServi ce.co m 14 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator IMPORT ANT Before installin g your U-Line CLRCO207 5 with Factory- Installed U-Line P60 Pump, it is extremel y important to check and test all hose co nnections at the drain pump.
02/2 005 15 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or 5. Place a suitable container beneath the pump’ s discharge tube. (The bucket must be able to hold a minimum of one gallon.) 6. Plug the ice maker power cord into a properly grounded, polarized electrical outlet.
www.U-Li neServi ce.co m 16 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator 3. Carefully bend the water supply line into position and connect the line to the solenoid valve (see Figure 39 ). A void kinking the water supply line. IMPORT ANT Normal o peration create s some vibration.
02/2 005 17 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or Leveling Informatio n IMPORT ANT It is extremely importa nt that th e unit is lev el.
www.U-Li neServi ce.co m 18 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator Installation of the C LRCO2075 1. Open the water supply valve in the ma in water source. 2. Make sure the cycle selector switch is in the OFF (middle) position (see Figure 4 6 ).
02/2 005 19 www.U-Lin eService.co m ™ CLRCO2075 — Clear Ice Maker/Refrigerat or Initial Start-Up Once installa tion and leveling is comp lete, the unit is ready for initial start-up and operation. The cycle selector switch is located in the front grille (see Fig ure 46 ).
www.U-Li neServi ce.co m 20 02/200 5 ™ CLRCO2075 — Clea r Ice Maker/Refr igerator Start-Up T roubleshooting Pr oblem Q : Unit does not appear to turn on when switch is set to ON. Solution A: Remember that the compressor will not opera te until the water has been filling for about 3 minutes.
™ ©2005 U-Line Corporation Publication No. 30052E 02/2005 Rev . A U-Line Corpo ration, located in Mi lwaukee, WI, is a family operated manu facturer of built-in undercounter icemakers, Co mbo ® icemaker/refrigerators, Wine Captain ® wine st orage uni ts, refrigerators, refrigerated drawers and refrigerator/freezers.
An important point after buying a device U-Line CLRCO2075 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought U-Line CLRCO2075 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data U-Line CLRCO2075 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, U-Line CLRCO2075 you will learn all the available features of the product, as well as information on its operation. The information that you get U-Line CLRCO2075 will certainly help you make a decision on the purchase.
If you already are a holder of U-Line CLRCO2075, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime U-Line CLRCO2075.
However, one of the most important roles played by the user manual is to help in solving problems with U-Line CLRCO2075. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device U-Line CLRCO2075 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
