Instruction/ maintenance manual of the product CLR2160 STAINLESS U-Line
Go to page of 20
® CLEAR & CLEAR COMBO ® MODELS CLEAR ICE & CLEAR ICE COMBO MODELS CLR2160OD Outdoor USE AND CARE GUIDE CLRCO2175 CLR2160 Stainless The Built-In Under counter Leader Since 1962 U-LINE.
Introduction to U-Line FOR PRODUCT ASSIST ANCE, CALL 1-800-779-2547 MIL WAUKEE, WI U.S.A. Serial/Serie: Model/Modele: HIGH SIDE DESIGN PRESSURE 300 PSI LOW SIDE DESIGN PRESSURE 140 PSI REFRIGERA TOR AND/ BTL LISTED 674R OR FREEZER HOUSEHOLD U C L R US www .
U-Line Use and Care Table of Contents 1 i - Introduction .......................... ......................................... .................................... ....... ........................ ........................... i Read and save this Use and Care Guide.
2 U-Line Use and Care Guide.
U-Line Safety Precautions 3 IMPOR T ANT IMPOR T ANT • PLEASE READ all instru ctions before inst alling, operating, or servicing the appliance. • Proper installation pr ocedures must be f ol lo wed when completing an instal lation or relocation of a unit.
4 U-Line Combo Model and Ice Maker Product Features 3 Pr oduct Fe atures Model F eatures: High daily ice pr oduction and storage. The CLR2160 pr oduces up to 60 pounds of ice per da y and stores up to 30 pounds. While the CLRCO2175 can produce up to 40 poun ds or ice per da y and store up to 15 pounds.
U-Line Product Operation 5 12 3 5 4 4 Pr oduct Operation Air Flo w IMPOR T ANT IMPOR T ANT The unit requires pr oper air f lo w to per form at its highest efficiency . Do not block the fr ont grille or internal fans at any time, or the unit will not p erform as expected.
6 U-Line Product Operation 12 3 5 4 T o check the actual pr oduct temperature in the unit . 1. Partially fill a plastic (nonbreakable) bottle wi th water . 2. Insert an accurate thermometer . 3. Tighten the bottle ca p securely . 4. Place the bottle in the desi red area for 24 hou rs.
U-Line Product Operation 7 Electr onic Control Quick Guide Ta s k To u c h To u c h Displa y Comment T urn ON/OFF Hold 5 seconds Release when °F flashes.
8 U-Line Ice Maker Cle Clear Ice Mak er Cleaning Cycle Interv al - Ev er y 3 Months T o maintain operational efficiency , clean the unit every three months (depending on water con ditions, more or less fr equent cleaning ma y be necessar y).
U-Line Ice Makers 9 The unit will resume operatio n appr oximately 15 min utes after the automated cleaning pr ocess is completed. The wa ter fill valve will energize, fill the wate r reservoir , and shut-off after thr ee minutes. The compr essor begins to operate and water fl ows ov er the eva porator assembly (ice cube tra y).
10 U-Line Combo® Models and Ice Mak ers Maintenance 1 6 Maintenance For Models with adjustable lev eling fee t: 1. Use a level to check the levelness of the unit from fr ont to b ack and from side to side. Place th e lev el along top edge and side edge as show n (1).
U-Line Combo® Models and Ice Mak ers Maintenance 11 Remo ving and Installing Door Shelves For models equpped with door shelves: To r e m o v e t h e d o o r s h e l f : 1. Grasp shelf in center , and lift until the shelf notches (1) clear the pins (2).
12 U-Line Self-Closing Door Alignment and Reversal 1/8" (3.175 mm) 1 23 4 9 Self-Closing Doors Door Alignment and Adjustment Align and adjust the door if it is not level, or is no t sealing properl y . If the door is not sealed the unit ma y not cool pr operly , or excessiv e frost ma y form in the interio r .
U-Line Self-Closing Door Alignment and Reversal 13 3 4 ULI 5 NO TCH 1 2 T o re verse the door : Remo ve door : 1. Hold door to k eep it from fallin g. 2. Remove hinge screw pin (1) from top hinge using a Phillips scre wdriver . 3. Remov e door by tilting f orward and li fting door off bottom hinge closer inser ts.
14 U-Line Combo® Models and Ice Mak er Cleaning To d e f r o s t : 1. Disconnect po wer to the unit. 2. For combo mode ls remov e all products from the interior . 3. Remove ice buck et and discard ice . 4. Pl ace towel or other absorbent materialon bottom of ice bin.
U-Line Combo® Models and Ice Mak er Cleaning 15 Condensor Cleaning Interv al - Ev er y Six Months T o maintain operational eff iciency , kee p the front grille free of dust and lint, and clean the condenser every three months. Depending on envir onmental conditions, more or less frequent cleaning ma y be necessary .
16 U-Line Combo® Models and Ice Mak ers Service 9S e r v i c e Prob lem P o ssible Cause and Remedy Unit Does not operate. Electronic displa y blank No electrical supply . Plug unit in or check circuit breaker No Interior light CLRCO2175, Tighten o r replace bulb, See Maintnence) CLR216 0, Contact Ser vice.
U-Line Warranty 1. U-Line Corporation ("U- Line") warrants each U-Line product to be free from defects in materials and workmanship for a period of one year from the date of purchase.
® ABOUT U-LINE Building on 45 y ears, U-Line has captivated those with an appr eciation for the finer things with exceptional design, inspired inno vations and atte ntion to ev en the smallest details.
An important point after buying a device U-Line CLR2160 STAINLESS (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought U-Line CLR2160 STAINLESS yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data U-Line CLR2160 STAINLESS - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, U-Line CLR2160 STAINLESS you will learn all the available features of the product, as well as information on its operation. The information that you get U-Line CLR2160 STAINLESS will certainly help you make a decision on the purchase.
If you already are a holder of U-Line CLR2160 STAINLESS, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime U-Line CLR2160 STAINLESS.
However, one of the most important roles played by the user manual is to help in solving problems with U-Line CLR2160 STAINLESS. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device U-Line CLR2160 STAINLESS along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
