Instruction/ maintenance manual of the product BI2015 U-Line
Go to page of 17
www .U-LineService.com Phone (414) 354-0300 • F AX (414) 354-7905 Service & Parts T ech Line s Ph one (800) 779-2547 • F A X (414) 354-5696 OnlineService@U-Line.
BI2015 — Ice Make r www.U-Li neServi ce.co m 2 02/200 5 ™ Conte nts Exterior Clea ning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Cut-Out Dime nsions . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Product Dime nsions . .
BI2015 — Ice Make r 02/2 005 3 www.U-Lin eService.co m ™ General Pr ecautions Use this app liance for its inte nded purpose o nly and follow these general p recautions along with tho se listed throughout this guide: WA R N I N G SHOCK HAZARD — Electrical Gr ounding Required.
BI2015 — Ice Make r www.U-Li neServi ce.co m 4 02/200 5 ™ After all the protective coating has be en removed from the unit/door , cle an all Stainless Steel su rfaces with Claire Stainless Ste el Polish and Cleaner o r comparable product or a mild deterge nt and warm water solution and soft cloth.
BI2015 — Ice Make r 02/2 005 5 www.U-Lin eService.co m ™ Product Dimensions Please note that the unit has adjustable feet that can add one additio nal inch to height during leveling or to match adjacent cabinets (see Figur e 35 on Page 14 ).
BI2015 — Ice Make r www.U-Li neServi ce.co m 6 02/200 5 ™ 4. Remove the two door closer inserts from the existing bottom hinge and install as shown on the new bottom hinge (see Figure 8 ). 5. Remove existing bottom hinge (3 screws) and remount on opposite side TOP .
BI2015 — Ice Make r 02/2 005 7 www.U-Lin eService.co m ™ Side-By-Side Installation Instructions For a complete refreshment center , install your BI2015 Ice Maker besid e a U-Line Refrigerator , Combo, or Wine Captain Mod el (see Fig ure 1 1 for typical cut-out).
BI2015 — Ice Make r www.U-Li neServi ce.co m 8 02/200 5 ™ 2. Pull door gasket out of groove (top edge of door only). Start in the middle and pull outward, moving toward the edge (see Figur e 13 ). This may take s ome force. Do not re move the th ree sc rews behi nd gasket.
BI2015 — Ice Make r 02/2 005 9 www.U-Lin eService.co m ™ Route notch in top corner of overlay pa nel as shown (see T op and Side V iews). T op of notc h is entire depth of panel, front to back. Width: 13/16 " Depth: 1/8" Route notc h in backside of top corner of overlay panel (see Back an d Side View s).
BI2015 — Ice Make r www.U-Li neServi ce.co m 10 02/200 5 ™ 4. Remove t he top han dl e and discard. (This h andle will be replaced with the Modified Handle included in the Full Overlay Door Panel Kit. ) 5. Remove the two screws located on both sides of the lower handle.
BI2015 — Ice Make r 02/2 005 11 www.U-Lin eService.co m ™ 5. Remove the existing bottom pivot plate and replace with the Full Overlay pivot plate (see Fig ure 23 ). IMPORT ANT Door panel and o verlay panel must be aligne d properly or the door wil l not operate correctly .
BI2015 — Ice Make r www.U-Li neServi ce.co m 12 02/200 5 ™ Checking Door Ali gnment The unit’ s do or is aligned a t the factory befo r e shipment. However , its alignment could have been disturbed during shipment or du r ing door pa nel installation.
BI2015 — Ice Make r 02/2 005 13 www.U-Lin eService.co m ™ CAUTIO N Plumbing i nstallation must observe all sta te and loca l codes. All wa ter connectio ns MUST BE made by a licensed/ qualified pl umbing contractor . Failure to follo w recommendations and instruction s may result in damage and/or harm.
BI2015 — Ice Make r www.U-Li neServi ce.co m 14 02/200 5 ™ Electrical Spe cifications CAUTIO N Electrical insta llation must observe a ll state and loc al codes. Thi s unit requires connect ion to a groun ded (three- prong), polari zed receptacle that has be en placed by a qualified e lectrician.
BI2015 — Ice Make r 02/2 005 15 www.U-Lin eService.co m ™ Installation of the B I2015 1. Open the water supply valve in the main water source. 2. Make sure the ON/OFF switch is in the OFF position (see Figure 36 ). 3. Plug in the power cord. 4. Gently push the unit into position.
BI2015 — Ice Make r www.U-Li neServi ce.co m 16 02/200 5 ™ Start-Up T roubleshooting Pr oblem Q: Unit does not appea r to turn on when switch is set to ON. Solution A: Make sure unit is plu gged in and outlet has power (circuit breaker has not tripped).
™ ©2005 U-Line Corporation Publication No. 30056E 02/2005 Rev . A U-Line Corpo ration, located in Mi lwaukee, WI, is a family operated manu facturer of built-in undercounter icemakers, Co mbo ® icemaker/refrigerators, Wine Captain ® wine stor age uni ts, refrigerators, refrigerated drawers and refrigerator/freezers.
An important point after buying a device U-Line BI2015 (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought U-Line BI2015 yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data U-Line BI2015 - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, U-Line BI2015 you will learn all the available features of the product, as well as information on its operation. The information that you get U-Line BI2015 will certainly help you make a decision on the purchase.
If you already are a holder of U-Line BI2015, but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime U-Line BI2015.
However, one of the most important roles played by the user manual is to help in solving problems with U-Line BI2015. Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device U-Line BI2015 along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
