Instruction/ maintenance manual of the product Auris Full Hybrid (2010) Toyota
Go to page of 33
Hybrid 2010 Model © 2010 Toyota Motor Corporation All rights reserved. Th is document may not be altered without the written permissi on of Toyota Motor Corporation.
F -i- oreword In Jun 2010, Toyota released the To yota Auris gasoline-electric hybrid vehicle. Except where noted in th is guide, basic vehicle systems and features for the Auris hybrid are th e same as those on the con ventional non-hybrid Toyota Auris.
-ii- Table of Contents Page About the Auris Hybrid 1 Auris Hybrid Identification 2 Hybrid Synergy Drive Component Locations & Descriptions 5 Entry and Start System 8 Electronic Gearshift Selector .
About the Auris - 1 - The Auris joins the Prius as hybrid models for Toyota. Hybrid Synergy Drive means that the vehicle contains a gasoline engine and an electric motor for power. The two hybrid power sources are stored on board the vehicle: 1. Gasoline stored in the fuel tank for the gasoline engine.
Auris Hybrid Identification - 2 - In appearance, the 2010 model year Au ris hybrid is nearly identical to the conventional, non-hybrid Toyota Au ris. The Auris hybrid is a 5-door hatchback. Exterior, interior, and engine com partment illustrations are provided to assist in identification.
Auris Hybrid Identification (Continued) Interior Interior View Instrument Cluster Vie w The instrument cluster (speedometer, READY light, shift position indicators, warning lights) located the dash behind the steering wheel, is different than the one on the conventional, non-h ybrid Auris.
Auris Hybrid Identification (Continued) Engine Compartment Engine Compartment View 1.8-liter aluminum alloy gasoline engine. Logo on the plastic engine cover.
H - 5 - ybrid Synergy Drive Component Locations & Descriptions Component Location Description 12 Volt Auxiliary Battery Right Side of Cargo Area A lead-acid battery that supplies power to the low voltage devices. Hybrid Vehicle (HV) Battery Pack Cargo Area, Mounted to Cross Member behind Rear Seat 201.
H - 6 - ybrid Synergy Drive Component Locations & Descriptions (Continued) Component Location Description A/C Compressor (with Inverter) Engine Compartment 3-phase high voltage AC electrically driven motor compressor. Fuel Tank and Fuel Line Undercarriage and Center The fuel tank provides gasoline via a fuel line to the engine.
H - 7 - ybrid Synergy Drive Component Locations & Descriptions (Continued) Key Specifications: Gasoline Engine: 98 hp (73 kW), 1.8-liter Aluminum Alloy Engine Electric Motor: 80 hp (60 kW), Permanent Magnet Motor Transmission: Automatic Only (electrically controlled continuously variable transaxle) HV Battery: 201.
E - 8 - ntry and Start System The Auris hybrid entry and start system consists of a smart key transceiver that communicates bi-d irection ally, enabling the vehicle to recognize the smart key in proximity to the vehicle.
E - 9 - ntry and Start System (Continued) Vehicle Starting/Stopping The smart key has replaced the conventional m etal cut key, and the power button with an integral status indicator light has replaced the ignition switch. The smart key only needs to be in proxim ity to the vehicle to allow the system to function.
- 10 - Electronic Gearshift Selector The Auris hybrid electronic gearshif t selector is a momentary select shift-by-wire system that enga ges the transaxle in revers e ( R ), neutral ( N ), drive ( D ), or engine brake ( B ) modes.
Hy - 11 - brid Synergy Drive Operation Once the READY indicator is illuminated in the instrument cluste r, the vehicle may be driven. However, the gasoline engine does not idle like a typical automobile and will start an d stop automatically. I t is important to recognize and understand the READY indicator provided in the instrument cluster.
Hybrid Vehicle (HV) Battery Pack - 12 - The Auris hybrid features a high vo ltage Hybrid Vehicle (HV) battery pack that contains sealed Nickel Metal Hydride (NiMH) battery modules. HV Battery Pack • The HV battery pack is enclosed in a metal case and is rigidly mount ed to the cargo area floor pan cross member behind the rear seat.
- 13 - Low Voltage Battery Auxiliary Battery • The Auris hybrid contains a sealed lead -acid 12 Volt auxiliary battery. The 12 Volt auxiliary battery powers the vehicle’s electrica l system similar to a conventional vehicle.
High Voltage Safety - 14 - The HV battery pack powers the high voltage electrical system with DC electricity. Positive and negative orange colored high voltage power cables are routed from the battery pack, under the vehicle floor pan, to t he inverter/converter.
S - 15 - RS Airbags & Seat Belt Pretensioners Standard Equipment • Electronic frontal impact sensors (2) are mounted in the engine compartment as illustrated. • Front seat belt pretensioners are mounted near the base of the B-pillars .
SRS Airbags & Seat Belt Pretensioners (Continued) - 16 - NOTE: The front seatback mounted side airbag s and the side curtain airbags may deploy independently of each other. The driver knee airbag is designed to deploy simultaneously with the frontal airbag.
Chock Wheels Set Parking Brake P Switch E - 17 - mergency Response On arrival, emergency responders should follow their standard operating procedures for vehicle inci dents.
- 18 - Emergency Response (Continued) Extrication (Continued) Procedure #1 1. Confirm the status of the READY indicator in the instrument cluster. If the READY indicator is illuminated, the vehicle is on and operational. 2. Shut off the vehicle by pushing t he power button once.
- 19 - Emergency Response (Continued) Extrication (Continued) Procedure #2 (Alternate if power button is inaccessible) 1. Open the hood. 2. Remove the fuse box cover. 3. Remove the IGCT fuse (30A) and AM2 fuse (7.5A) in the engine compartment fuse box (refer to illustration).
- 20 - Emergency Response (Continued) Extrication (Continued) • Stabilize Vehicle Crib at (4) points directly unde r the front and rear pillars. Do not place cribbing under the high vol tage power cables, exhaust system, or fuel system. • Access Patients Glass Removal Use normal glass removal procedures as required.
- 21 - Emergency Response (Continued) Extrication (Continued) Roof Removal The Auris hybrid is equipped with side curtain airbags. If the side curtain airbags are undeployed, total roof removal is not recommended. This is to avoid breaching the side curtain airbags, inflators, and wiring harness.
- 22 - Emergency Response (Continued) Extrication (Continued) Rescue Lift Air Bags Responders should not place cribbing or rescue lift air bags under the high voltage power cables, exhaust system, or fuel system. Repositioning Steering Wheel and Front Seats Telescopic steering wheel and seat controls are shown in the illustrations.
- 23 - Emergency Response (Continued) Offensive Fire Attack Fire Normally, flooding an NiMH HV battery pack with copious amounts of water at a safe distance will effectively control the HV battery pack fire by cooling the adjacent NiMH battery modules to a point below their ignition temperature.
Em - 24 - ergency Response (Continued) NOTE: Before disconnecting the 12 Volt auxiliary battery, if necessary, lower the windows, unlock the doors and open the back door as required. Once the 12 Volt auxiliary battery is disconnected, power controls will not operate.
E - 25 - mergency Response (Continued) Spills First Aid The Auris hybrid contains the same common automotive fluids used in other non-hybrid Toyota vehicles, with the exception of the NiMH electrolyte used in the HV battery pack. The NiMH batte ry electrolyte is a caustic alkaline (pH 13.
- 26 - Emergency Response (Continued) First Aid (Continued) If vomiting occurs spontaneously, k eep the patient’s head lowered and forward to reduce the risk of asphyxiation.
- 27 - Roadside Assistance The Auris hybrid utilizes an elec tronic gearshift selector and an electronic P switch for park (P). If th e 12 Volt auxiliary battery is discharged or disconnected, the vehi cle cannot be started nor can it be shifted out of park (P).
- 28 - Roadside Assistance (Continued) Electric Back Door Opener Electric Back Door Opener Switch The Auris hybrid is equipped with an el ectric back door opener. In the event of 12 Volt power loss, the back door cannot be opened from the outside of the vehicle.
- 29 - Roadside Assistance (Continued) Emergency Tire Puncture Repair Kit Tools, Optio nal Jack, Towin g Eyelet and Em ergency Tire P uncture Repai r Kit in the Cargo Area Tools, Jack, Towing Eyelet and Spare Tire i n the Cargo Area The jack, tools, towing eyelet and emergency tire puncture repair kit are provided as shown.
Remote Hood Release Hood Latch Release Remove Fuse Box Cover Open Positive Terminal Cover Jumper Cable Connections Positive Terminal Ground -30- oadside Assistance (Continued) R Jump Starting The 12 V.
An important point after buying a device Toyota Auris Full Hybrid (2010) (or even before the purchase) is to read its user manual. We should do this for several simple reasons:
If you have not bought Toyota Auris Full Hybrid (2010) yet, this is a good time to familiarize yourself with the basic data on the product. First of all view first pages of the manual, you can find above. You should find there the most important technical data Toyota Auris Full Hybrid (2010) - thus you can check whether the hardware meets your expectations. When delving into next pages of the user manual, Toyota Auris Full Hybrid (2010) you will learn all the available features of the product, as well as information on its operation. The information that you get Toyota Auris Full Hybrid (2010) will certainly help you make a decision on the purchase.
If you already are a holder of Toyota Auris Full Hybrid (2010), but have not read the manual yet, you should do it for the reasons described above. You will learn then if you properly used the available features, and whether you have not made any mistakes, which can shorten the lifetime Toyota Auris Full Hybrid (2010).
However, one of the most important roles played by the user manual is to help in solving problems with Toyota Auris Full Hybrid (2010). Almost always you will find there Troubleshooting, which are the most frequently occurring failures and malfunctions of the device Toyota Auris Full Hybrid (2010) along with tips on how to solve them. Even if you fail to solve the problem, the manual will show you a further procedure – contact to the customer service center or the nearest service center
